88888 A WORLD BANK STUDY Biochar Systems for Smallholders in Developing Countries LEVERAGING CURRENT KNOWLEDGE AND EXPLORING FUTURE POTENTIAL FOR C L I M AT E - S M A R T A G R I C U LT U R E Sebastian M. Scholz, Thomas Sembres, Kelli Roberts, Thea Whitman, Kelpie Wilson, and Johannes Lehmann Biochar Systems for Smallholders in Developing Countries A WO R L D BA N K S T U DY Biochar Systems for Smallholders in Developing Countries Leveraging Current Knowledge and Exploring Future Potential for Climate-Smart Agriculture Sebastian M. Scholz, Thomas Sembres, Kelli Roberts, Thea Whitman, Kelpie Wilson, and Johannes Lehmann Washington, D.C. © 2014 International Bank for Reconstruction and Development / The World Bank 1818 H Street NW, Washington, DC 20433 Telephone: 202-473-1000; Internet: www.worldbank.org Some rights reserved 1 2 3 4 17 16 15 14 World Bank Studies are published to communicate the results of the Bank’s work to the development com- munity with the least possible delay. The manuscript of this paper therefore has not been prepared in accordance with the procedures appropriate to formally edited texts. This work is a product of the staff of The World Bank with external contributions. The findings, inter- pretations, and conclusions expressed in this work do not necessarily reflect the views of The World Bank, its Board of Executive Directors, or the governments they represent. The World Bank does not guarantee the accuracy of the data included in this work. The boundaries, colors, denominations, and other information shown on any map in this work do not imply any judgment on the part of The World Bank concerning the legal status of any territory or the endorsement or acceptance of such boundaries. Nothing herein shall constitute or be considered to be a limitation upon or waiver of the privileges and immunities of The World Bank, all of which are specifically reserved. Rights and Permissions This work is available under the Creative Commons Attribution 3.0 IGO license (CC BY 3.0 IGO) http:// creativecommons.org/licenses/by/3.0/igo. Under the Creative Commons Attribution license, you are free to copy, distribute, transmit, and adapt this work, including for commercial purposes, under the following conditions: Attribution—Please cite the work as follows: Scholz, Sebastian M., Thomas Sembres, Kelli Roberts, Thea Whitman, Kelpie Wilson, and Johannes Lehmann. Biochar Systems for Smallholders in Developing Countries: Leveraging Current Knowledge and Exploring Future Potential for Climate-Smart Agriculture. World Bank Studies. Washington, DC: World Bank. doi:10.1596/978-0-8213-9525-7. License: Creative Commons Attribution CC BY 3.0 IGO Translations—If you create a translation of this work, please add the following disclaimer along with the attribution: This translation was not created by The World Bank and should not be considered an official World Bank translation. The World Bank shall not be liable for any content or error in this translation. Adaptations—If you create an adaptation of this work, please add the following disclaimer along with the attribution: This is an adaptation of an original work by The World Bank. Responsibility for the views and opinions expressed in the adaptation rests solely with the author or authors of the adaptation and are not endorsed by The World Bank. Third-party content—The World Bank does not necessarily own each component of the content contained within the work. The World Bank therefore does not warrant that the use of any third-party-owned individual component or part contained in the work will not infringe on the rights of those third parties. The risk of claims resulting from such infringement rests solely with you. If you wish to re-use a com- ponent of the work, it is your responsibility to determine whether permission is needed for that re-use and to obtain permission from the copyright owner. Examples of components can include, but are not limited to, tables, figures, or images. All queries on rights and licenses should be addressed to the Publishing and Knowledge Division, The World Bank, 1818 H Street NW, Washington, DC 20433, USA; fax: 202-522-2625; e-mail: pubrights@worldbank .org. ISBN (paper): 978-0-8213-9525-7 ISBN (electronic): 978-0-8213-9526-4 DOI: 10.1596/978-0-8213-9525-7 Cover collage: (Background) Three women plant seeds in a farm. © World Bank/Maria Fleischmann. (Left inset) Three women using a biochar cookstove. © Johannes Lehmann. (Right inset) Wheat crop. © World ­ ermission required for reuse. Bank/Simone D. McCourtie. All photographs used with permission; further p Cover design: Debra Naylor, Naylor Design, Inc. Library of Congress Cataloging-in-Publication Data has been requested. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Contents Acknowledgments xi About the Authors xiii Abbreviations xv Executive Summary 1 Introduction 1 Background on Biochar 2 Overall Opportunities and Risks of Biochar Systems 3 Survey and Typology of Biochar Systems 7 Life-Cycle Assessment of Existing Biochar Systems 8 Aspects of Technology Adoption 12 Potential Future Involvement of Development Institutions, Including the World Bank 14 Chapter 1 Introduction 17 Potential of Biochar 17 Increases in Research into Biochar 18 Content and Purpose of Study 18 Methodology 19 Chapter 2 Background on Biochar 21 Characteristics and Historical Basis of Biochar 21 Biochar Systems 23 Note 26 Chapter 3 Opportunities and Risks of Biochar Systems 27 Introduction 27 Impacts on Soil Health and Agricultural Productivity 28 Impacts on Climate Change 34 Social Impacts 48 Competing Uses of Biomass 55 Notes 60 Chapter 4 Survey and Typology of Biochar Systems 61 Survey 61 Classification of Biochar Systems 62 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7  v vi Contents Chapter 5 Life-Cycle Assessment of Existing Biochar Systems 71 Life-Cycle Assessment: Definition and Methodology 71 Case Studies 74 Kenya Case Study Life-Cycle Assessment 75 Vietnam Case Study Life-Cycle Assessment 97 Senegal Case Study Life-Cycle Assessment 115 Case Study Comparison and Conclusions 128 Notes 132 Chapter 6 Aspects of Technology Adoption 135 Economics of Biochar 135 Engagement with Carbon Markets 136 Sociocultural Barriers to Adoption 140 Note 141 Chapter 7 Potential Future Involvement of Development   Institutions, Including the World Bank 143 Biochar: Knowns and Unknowns 143 Further Research Needs 144 Supporting the Early Adoption of Biochar Systems 146 Scaling Up Biochar Systems from Pilot to Program 148 Notes 151 Appendix A Survey Results 153 Part I 153 Part II 155 Survey Interpretation 161 Biochar Systems Survey: Project Data 164 Appendix B Case Studies 169 Kenya Case Study Life-Cycle Assessment 169 Vietnam Case Study Life-Cycle Assessment 177 Senegal Case Study Life-Cycle Assessment 183 Appendix C Biographies: Biochar Guidance Group Members 191 References 195 Boxes ES.1 Summary of Kenya Case Study 9 ES.2 Summary of Vietnam Case Study 10 ES.3 Summary of Senegal Case Study 11 5.1 Elements of a Life-Cycle Assessment 72 5.2 Summary of Kenya Case Study 96 5.3 Summary of Vietnam Case Study 115 5.4 Summary of Senegal Case Study 127 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Contents vii Figures ES.1 Biochar as a System-Defined Concept 3 1.1 Acceleration of Published Research on Biochar and Charcoal 18 2.1 Terra Preta Soil Pit near Manaus, Brazil, Showing Thick, Dark, Carbon-Enriched Top Layer 22 2.2 Biochar as a System-Defined Concept 23 3.1  Percentage Change in Crop Productivity upon Application of Biochar under Different Scenarios 29 3.2  General Concept of the Carbon Storage Potential of Biochar Based on 1 Tonne of Dry Feedstock (Slow Pyrolysis) 36 3.3 Impact of Biochar on Climate Change Mitigation 45 3.4 Alternative Scenarios for Biomass Carbon Dynamics 46 4.1 Distribution of Project Locations 62 4.2 Biochar Production Technologies 63 4.3 Utilization of Biochar Production Energy 65 4.4 Word Cloud Showing Biochar Feedstocks Most Frequently Cited by Survey Respondents 65 4.5 Scale of Biochar Production Systems 66 4.6 Typology of Biochar Systems by Type of Energy Recovery and Scale Showing Number of Projects with Each Type of Feedstock 67 4.7 Summary of Dominant Biochar Typologies 68 5.1 Schematic Flow Diagram for Biochar Production in a Pyrolysis Cookstove System 77 5.2 Pyrolysis Cookstove in Kenya Case Study 78 5.3  Sources of GHG Reductions and Emissions, and Carbon Balance for Secondary Feedstock 90 5.4 Contribution Analysis for Net Revenues per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya 92 5.5  Sensitivity Analysis for Net GHG per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya 94 5.6  Sensitivity Analysis for Net Economic Balance per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya 95 5.7 Schematic Flow Diagram for Vietnam Biochar System 98 5.8 Rice Wafer Stove in Vietnam 99 5.9 Mayon Turbo Rice Hull Stove 101 5.10 Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam 109 5.11 Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam with 100 Percent Allocation for Rice Wafer Stove and Upstream Impacts 110 5.12 Contribution Analysis for Net Economic Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam 111 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 viii Contents 5.13 Sensitivity Analysis for Net GHG per Tonne of Dry Feedstock for Biochar System in Vietnam 113 5.14 Sensitivity Analysis for Net Economic Balance per Tonne of Dry Feedstock for Biochar System in Vietnam 114 5.15 Schematic Flow Diagram for Rice Husk Biochar to Onion Production System in Senegal 116 5.16 Photo and Diagram of Pyro-6F Unit 118 5.17 Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Senegal 123 5.18 Contribution Analysis for Net Economic Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Senegal 124 5.19 Sensitivity Analysis for Net GHG per Tonne of Dry Feedstock for Biochar System in Senegal 126 5.20 Sensitivity Analysis for Net Economic Balance per Tonne of Dry Feedstock for Biochar System in Senegal 127 5.21 Comparison of Net GHG Balance of Three Case Studies: Kenya, Vietnam, and Senegal 129 5.22 Comparison of Net Revenues of Three Case Studies: Kenya, Vietnam, and Senegal 130 A.1 Project Phase 153 A.2 Project Location 154 A.3 Utilization of Biochar Product 154 A.4 Biochar Pretreatments and Added Amendments 155 A.5 Barriers to Implementing Biochar Systems 155 A.6 Biochar as a Traditional Practice 157 A.7 How Projects Cope with Limited Supplies of Biochar 158 A.8 Responses to Ranking of Importance of Carbon Offset Payments to Project Finances 160 A.9 Responses to the Question of Who Would Receive Carbon Offset Payments from Biochar Projects 161 A.10 Typology of Biochar Systems by Scale and Feedstock Showing Number of Projects with Each Type of Energy Recovery 161 A.11 Typology of Biochar Systems by Energy Recovery and Feedstock Showing Number of Projects at Scale 162 A.12 Project Dendrogram 163 Tables 2.1 Typical Product Yields (Dry Basis) for Different Types of Thermochemical Conversion Processes That Generate Carbonaceous Residues 24 3.1 Possible Biochar Effects on Nitrogen Cycling 30 3.2 Direct and Indirect Sources of Biochar Emission Reductions 35 3.3 Potential Biomass Use and Limitations 56 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Contents ix 4.1 Biochar System Typology 69 5.1  Primary and Secondary Feedstock Characteristics and Availability for Baseline Scenario 79 5.2  Calculated Air Emissions from Pyrolysis Cookstove and Avoided Emissions from Three-Stone Fire, per Household per Year 83 5.3  Result Vector for Pyrolysis Cookstove in Kenya Baseline Scenario per Tonne of Dry Feedstock 89 5.4 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 94 5.5 Calculated Air Emissions from Rice Wafer Stove per Tonne of Biochar Produced 102 5.6 Peanut Yield Data for Different Treatments 104 5.7 Aboveground Biomass Residue Yield per Peanut Crop 105 5.8 Nitrogen, Phosphorus, and Potassium Uptake of Peanuts as Result of Mineral Fertilizer Applications of NPK 106 5.9 Fertilizer Prices in Vietnam 107 5.10 Result Vector for Vietnam Rice Husk Biochar System Baseline Scenario, per Tonne of Dry Rice Husk Feedstock 108 5.11 Comparison of Net Revenue between LCA Functional Unit and Farmer 112 5.12 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 113 5.13 Air Emissions Estimated for Pyro-6F per Tonne of Biochar Produced 119 5.14 Result Vector for Senegal Biochar System Baseline Scenario, per Tonne of Dry Rice Husk Feedstock 122 5.15 Comparison of Net Revenue between LCA Functional Unit, Farmer, and NGO 125 5.16 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 126 6.1 State of Protocols for Measuring GHG Impacts of Biochar Systems 139 A.1 Description of Barriers to Implementing Biochar Systems 156 A.2 Ideas for Overcoming Barriers 156 A.3 Biochar as a Traditional Practice 157 A.4 Additional Ways to Cope with Limited Biochar Supplies 159 A.5 Ranking of Benefits Project Developers Believe Will Accrue to Project Participants 159 A.6 Further Description of Project Benefits 160 A.7 Summary of Project Data from Survey 164 B.1 Data Quality Scores for Kenya Pyrolysis Cookstove System 170 B.2 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 171 B.3 Sensitivity Results for Primary Feedstock Parameter 171 B.4 Sensitivity Results for Stable Carbon Content of Biochar Parameter 171 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 x Contents B.5 Sensitivity Results for Pyrolysis Emissions Parameter 172 B.6 Sensitivity Results for Three-Stone Fire Emissions Parameter 172 B.7 Sensitivity Results for Duration of Biochar’s Effect on Productivity Parameter 173 B.8 Sensitivity Results for Maize Price Parameter 174 B.9 Sensitivity Results for Maize Yield Response Parameter 174 B.10 Sensitivity Results for Fraction of Nonrenewable Biomass Parameter 175 B.11 Sensitivity Results for Biochar Application Rate Parameter 176 B.12 Sensitivity Results for Soil Nitrous Oxide Emissions Parameter 176 B.13 Data Quality Scores for Vietnam Rice Husk Biochar System 178 B.14 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 178 B.15 Sensitivity Results for Stable Carbon Content of Biochar Parameter 179 B.16 Sensitivity Results for Rice Wafer Stove Methane Emissions Parameter 179 B.17 Sensitivity Results for Rice Husk Burning Methane Emissions Parameter 180 B.18 Sensitivity Results for Duration of Biochar’s Agronomic Effect Parameter 180 B.19 Sensitivity Results for Peanut Price Parameter 181 B.20 Sensitivity Results for Yield Response Parameter 181 B.21 Sensitivity Results for Biochar Transportation Distance Parameter 182 B.22 Sensitivity Results for Soil Nitrous Oxide Emissions Parameter 182 B.23 Data Quality Scores for Senegal Biochar System 183 B.24 Sensitivity Analysis Input Parameters, Including Baseline and Range Values 184 B.25 Sensitivity Results for Stable Carbon Content of Biochar Parameter 184 B.26 Sensitivity Results for Yield Response Parameter 185 B.27 Sensitivity Results for Onion Price Parameter Assuming a 50-Year Effect 186 B.28 Sensitivity Results for Pyro-6F Methane Emissions Parameter 186 B.29 Sensitivity Results for Rice Husk Decay Methane Emissions Parameter 187 B.30 Sensitivity Results for Duration of Biochar’s Agronomic Effect Parameter 187 B.31 Sensitivity Results for Biochar Price Parameter 187 B.32 Sensitivity Results for Pyro-6F Production Time Parameter 188 B.33 Sensitivity Results of Revenue for Biochar Transportation Distance Parameter 188 B.34 Sensitivity Results for Soil Nitrous Oxide Parameter 188 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Acknowledgments This report was written by the following team of authors: Sebastian M. Scholz (senior environmental economist, World Bank), Thomas Sembres (programme officer, UNEP UN-REDD Programme), Kelli Roberts (postdoctoral associate, Cornell University), Thea Whitman (doctoral researcher, Cornell University), Kelpie Wilson (project development director, International Biochar Initiative), and Johannes Lehmann (associate professor, Cornell University). The World Bank task team, led by Sebastian M. Scholz, also included Gerhard Dieterle (for- ests adviser) and Ellysar Baroudy (senior carbon finance specialist). In addition, very constructive peer-reviewed feedback was received from members of the World Bank’s Latin America and Caribbean unit as well as from Sameer Akbar from the Climate Change Group. The authors thank Karin Kemper, director of the Climate Change Group, Climate Change Policy & Finance, who formerly managed the Latin America and Caribbean Environment team. The authors also thank Ede Jorge Ijjasz-Vasquez, sector director of the Latin America and Caribbean Sustainable Development Department at the World Bank. Both were instrumental in providing ongoing advisory support throughout the making of this report. Robert J. Griffin, with the World Bank’s BioCarbon Fund, was instru- mental in managing the report through publication and reviewing all research from contributing authors. The report benefited from the review comments provided by Ian Noble (chief scientist, Global Adaptation Institute) and Erick C.M. Fernandes (adviser, World Bank). Comments were also received from Rosina Bierbaum (professor, University of Michigan) and Christian Witt (senior program officer, Soil Health, Bill & Melinda Gates Foundation). The latter two reviewers were also members of a group of external experts who provided valuable insights and constructive advice during the preparation of this report. Other members of the external guidance group included Pedro Sanchez (director, Columbia University), Sasha Lyutse (policy analyst, NRDC Center for Market Innovation), and Patricia Elias (forest science and policy consultant, Union of Concerned Scientists). The report was strengthened through discussions during a workshop held in Washington, DC, on May 11, 2011. Comments and advice from the workshop participants helped to improve the report. A number of biochar practitioners and researchers from around the world provided project-related information in response to a global biochar systems Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   xi xii Acknowledgments survey, undertaken as part of this study. Their participation is gratefully acknowl- edged, as is access to this network of practitioners that the International Biochar Initiative provided. Core funding for this undertaking was provided by the Program on Forests and the World Bank’s BioCarbon Fund. Additional funding was made available by the Carbon War Room. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 About the Authors Johannes Lehmann is an associate professor of soil biogeochemistry and soil fertility management at Cornell University. He received his graduate degree in soil science at the University of Bayreuth, Germany. During the past 10 years he has focused on nanoscale investigations of soil organic matter, the biogeochemis- try of black carbon, and sequestration in soil. Doctor Lehmann is a member of the steering group of the U.S. National Soil Carbon Network. He has testified in the United States Congress and briefed the President’s Council of Advisors on Science and Technology. He was part of Workgroup 2 on Monitoring and Assessment of Sustainable Land Management of UNCCD, and is on the edito- rial boards of several international journals. Kelli Roberts is a postdoctoral associate at Cornell University in the Department of Crop and Soil Sciences. She completed her PhD at the University of Washington in Seattle and her undergraduate in materials science and engineer- ing at the Massachusetts Institute of Technology. Her research has focused on using life cycle assessment and systems thinking to analyze biochar systems. She also has a strong interest in sustainable agricultural systems and has established a small organic vegetable farm where she lives in Rhode Island. Sebastian M. Scholz is a senior environmental economist. He works mainly in the area of climate finance/carbon finance and climate change mitigation for the Sustainable Development Network of the World Bank. His current regional focus is on Latin America and the Caribbean; he also provides cross-support to other regions, particularly on climate mitigation activities. He has a PhD in agri- cultural sciences and agricultural economics and an MSc in forestry and natural resource management from the Justus-Liebig-University in Giessen, Germany, and the Technical University of Munich, Germany, respectively. Thomas Sembres is an economist working at the UN-REDD Programme in the United Nations Environment Programme in Nairobi. He works at the policy level on strategies and investments to reduce deforestation and forest degradation in the Congo basin. Prior to joining the UN-REDD Programme, Thomas worked at the World Bank’s Forest Team and Program on Forests in Washington, DC. He also worked as adviser on opportunities to reduce deforestation and forest Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   xiii xiv About the Authors degradation in Central and East Africa for the Forests Philanthropy Action Network, based in London, United Kingdom. He holds a Master’s degree in envi- ronmental policy from Cambridge University. Thea Whitman is a PhD graduate student at Cornell University in the Department of Crop and Soil Sciences. She completed her MS at Cornell in 2011, focusing on biochar and climate change, including laboratory research on biochar carbon sta- bility, system dynamics modeling of the climate change impact of a biochar cookstove system in western Kenya, and an investigation into the policy issues surrounding biochar projects for climate change mitigation. Her current research focuses on the interactions between biochar and nonbiochar soil organic matter, microbes, and plants, in a climate change context. She also has an avid interest in international climate change policy and has attended the past three United Nations climate change negotiations (COP14–COP16) as a member of the Canadian Youth Delegation. Kelpie Wilson is a project development director at International Biochar Initiative. She is a writer and mechanical engineer with experience in journalism, technology assessment, community organizing, forest policy, and NGO management. She has worked for IBI on communications and project develop- ­ ment since 2008. Prior to that, she was the environmental editor and columnist for Truthout.org and a contributor to numerous online and print publications. In the 1990s, she was the executive director of the Siskiyou Regional Education Project, a grassroots environmental group protecting wilderness and old growth forests in the Siskiyou Mountains of Oregon. She has a BS (with honors) in mechanical engineering from California State University, Chico. From 1986 to 1989 she worked for several firms doing research and development on Stirling cycle engines, including an internship at the Jet Propulsion Laboratory in Pasadena, California. She has also worked as a technical writer for a solar power company. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Abbreviations AEC anion exchange capacity BC black carbon BEGGE biochar energy, greenhouse gases, and economic BioCF BioCarbon Fund C carbon CDCF Community Development Carbon Fund CDM Clean Development Mechanism CEC cation exchange capacity CH4 methane C:N ratio carbon to nitrogen ratio CO2e carbon dioxide equivalent FAO Food and Agriculture Organization fNRB fraction of nonrenewable biomass GEF global environment facility GHG greenhouse gas GREET  greenhouse gases, regulated emissions, and energy use in ­transportation (model) IBI International biochar initiative IPCC Intergovernmental Panel on Climate Change K2O potassium oxide LCA life-cycle assessment LED light emitting diode MRT mean residence time NGO nongovernmental organization NMHC nonmethane hydrocarbons N2O nitrous oxide NPK nitrogen, phosphorus, and potassium (fertilizer) NRDC Natural Resources Defense Council O:C ratio Oxygen to carbon ratio Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   xv xvi Abbreviations OECD Organisation for Economic Co-operation and Development PAH polycyclic aromatic hydrocarbon PM2.5 particulate matter less than 2.5 micrometers in diameter P2O5 phosphorus pentoxide REDD  reducing emissions from deforestation and forest degradation SImpaCCT Stove Impact on Climate Change Tool SOC soil organic compound SOM soil organic matter TLUD top-lit updraft UNCCD United Nations Convention to Combat Desertification UNEP United Nations Environment Programme UN-REDD  United Nations–Reducing Emissions from Deforestation and ­forest Degradation VND Vietnamese dong All dollar amounts are U.S. dollars unless otherwise indicated. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary Introduction Three of the biggest challenges of the twenty-first century are the need to nearly double food production by 2050, to adapt and build resilience to a more and more challenging climatic environment, and to simultaneously achieve a substantial reduction in atmospheric greenhouse gas concentrations. The surge of interest in climate-smart agriculture, which focuses on solutions to the three challenges, has sparked curiosity in using biochar as a tool to fight climate change while also improving soil fertility. Biochar systems are particularly relevant in developing country contexts and could be leveraged to address global challenges associated with food production and climate change. However the potential effects of biochar application to soils are diverse and its climate impact is contin- gent on the design of the system into which it is integrated. Thus biochar systems are inherently complex and further research is needed to understand their associ- ated opportunities and risks in developing countries. There are a number of reasons why biochar systems might be particularly relevant in developing-country contexts. The potential for biochar to improve soil fertility could result in increased crop yields from previously degraded soils for smallholder farmers. Improved cookstoves that produce biochar as well as heat for cooking could reduce indoor air pollution and time spent on fuel gather- ing. Both of these results could be beneficial to forests. Enhanced food produc- tion capacity could potentially decrease the need to clear more forested land for agriculture, and more efficient cookstoves could decrease wood gathering from forests already in decline. It is vital that further research is undertaken to fill the gaps in our knowledge of biochar systems. This report offers a review of what is known about opportunities and risks of biochar systems including soil and agricultural impacts, climate change impacts, social impacts, and competing uses of biomass. The report benefited from its wide-ranging methodology including a desk review of existing literature; a two- step survey of biochar systems that elicited 154 responses to the initial survey, and 48 responses on the follow-up survey to learn more about the social and cultural barriers to biochar adoption; an expert workshop in Washington, DC to Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7  1 2 Executive Summary assist in analysis of the collected data; development of a typology of biochar systems; and a life-cycle assessment of selected systems in Kenya, Vietnam, and Senegal. Background on Biochar Biochar is the solid product remaining after biomass is heated to temperatures typically between 300°C and 700°C under oxygen-deprived conditions, a process known as “pyrolysis.” Biochar is a system-defined term referring to black carbon that is produced intentionally to manage carbon for climate change mitigation purposes combined with a downstream application to soils for agricultural effects. It is produced with the intent to be applied to soil as a means of improving soil productivity, carbon storage, or both. Although the term “biochar” has come into common usage only relatively recently, the practice of amending soils with char- coal for fertility management goes back millennia. Instances can be found in Africa, Asia, and notably in the Amazon basin where the historically managed terra preta, or “dark earths,” stand out for their capacity to store carbon. Biomass typically contains about 50 percent carbon, which is relatively quick- ly decomposed and reemitted to the atmosphere upon decay in soil. The mean residence time of fresh biomass is in the range of months to years, with longer times for woody biomass and colder climates. Biochar retains between 10 ­ percent and 70 percent (on average about 50 percent) of the carbon present in the original biomass and slows down the rate of carbon decomposition by one or two orders of magnitude, that is, in the scale of centuries or millennia. In principle biochar can be made from any type of biomass. It is important to understand how different production conditions can result in different types of biochars and how these chars interact with different types of soils. Three ­ elements critical to every biochar system are (a) the source of biomass, (b) the means of biochar production, and (c) whether and how it is applied to soil ( ­ figure ES.1). For each element there are a wide range of alternatives. The source, or feed- stock, can be almost any type of biomass including agricultural wastes, rice husks, and urban green waste. However focus is placed on use of “true wastes” in order to minimize disruption to local carbon and nutrient recycling. Production sys- tems range in scale from small household cookstoves to large industrial pyrolysis plants. Systems are generally classified as either gasifiers or pyrolysers depending on the technology applied. Several options exist for the use of biochar system outputs. This report focuses on integrated bioenergy-biochar-soil application systems with benefits for soil health and productivity, farming economies, cli- mate, and human well-being. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 3 Figure ES.1 Biochar as a System-Defined Concept Agricultural Fast/slow waste pyrolysis Urban Gasification waste e rc Pr chno ou te od lo ss uc gy as tio om n Bi Biochar Dedicated System Energy feedstock capture Soil application Soil characteristics Climate Farming system Source: World Bank. Overall Opportunities and Risks of Biochar Systems When considering the overall opportunities and risks of biochar systems, four main factors need to be taken into account: the impacts on soil health and agri- cultural productivity; the impacts on climate change; the social impacts; and competing uses of biomass. Impacts on Soil Health and Agricultural Productivity A number of benefits have been reported for biochar application to soils includ- ing greater yields, better predictability of yields, reduced germination time, exten- sion of cropping season, and greater resilience to drought. However, the impact of biochar application by location and over time can vary given the range of factors involved including: • Soil pH. Most biochars have a neutral to basic pH, and thus have a liming effect in acidic soils, which increases plant productivity. Application of ­ ­ biochar to basic soils does not necessarily lead to increased productivity. • Nutrient availability. Biochar is not a fertilizer per se but a soil conditioner with the potential to improve soil functions by reducing nutrient loss, increas- ing bioavailability of nutrients, and decreasing nutrient leaching. Thus, the application of biochar can reduce the reliance on fertilizer and its associated environmental and economic costs. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 4 Executive Summary • Soil moisture. Due to its porous structure and large surface area, biochar can retain plant-available water and improve the overall water-holding capacity of soils (with the exception of clay soils). • Soil organic matter. The role of biochar in increasing and sustaining organic matter content in soil is related to the soil type and the timescale over which biochar is applied. • Amount of biochar applied. Studies have shown a positive correlation be- tween increasing levels of biochar addition and plant response but only up to a certain point. Further research is needed to clarify the biophysical optimum for each soil–crop system. The emerging body of literature indicates that there is substantial potential for biochar application to improve crop yields of smallholder, subsistence farmers in developing countries. Given the complexity of systems and factors and the many unknowns sur- rounding optional conditions for securing predictable positive effects from bio- char application there is great need for further research and pilot projects. Initially it may be useful to focus on soils that have low organic matter content. The abundance of marginal or degraded soils in many parts of the tropics indi- cates that biochar has great potential to impact agriculture in these regions. Impacts on Climate Change The relevance of biochar for climate change mitigation has caught as much attention as its potential for agronomic purposes. The biochar material itself is a carbon concentrate of the original biomass feedstock, and its stability in soil thus has implications for soil carbon sequestration. Factors relevant to the potential climate change impacts of biochar include: Direct and Indirect Sources of Emission Reductions Carbon storage and stabilization is probably the most direct and important quality for climate change mitigation efforts based on biochar. The crucial calculation here is the difference between the decomposition of the biochar and ­ the decomposition of the original feedstock that would have happened in the absence of pyrolysis. The rate of decomposition of the biochar and consequent- ly its capacity for carbon storage depends on several factors. Two main factors recalcitrant include the ratio of labile carbon (which is readily degradable) to ­ carbon (which is more resistant to degradation), and on the pyrolysis technique used to produce the biochar. Indirect factors contributing to emission reduc- tions include generation of renewable energy through combustion of the syngas by-product of biochar production; waste diversion, thus avoiding methane and nitrous oxide emissions from decomposing wastes; reduced fertilizer manufac- turing, if biochar proves to increase crop productivity through improved nitro- gen use efficiency; reduced soil emissions, including of nitrous oxide; and increased nonbiochar soil carbon due to improved plant response. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 5 Potential Sources of Leakage and Risks to Emission Reduction From a climate change perspective the risks related to biochar lie primarily in the negative feedbacks that may occur directly or indirectly during biochar produc- tion and application. Such risks include emissions of methane and nitrous oxide during inefficient pyrolysis and degradation of soil organic matter after biochar application on unsuitable soils. Another risk is indirect land use change if biochar use leads to changes in demand for certain types of biomass (a risk that can be minimized if only true wastes are used which is what this report argues for). Also, char dust and other small particulate matter arising from biochar production can become airborne with uncertain global warming impacts, but more definitive adverse impacts on human health. The permanence and long-term stability of the biochar carbon store is another issue, and premature decomposition can be a risk. However, many of these risks can be avoided through the application of appropriate standards and safeguards throughout the biochar production chain, which are currently being developed by a constantly growing community of practice supported by science. Interaction with Short-Lived Climate Pollutants Recent science indicates that early and sustained action to reduce black carbon (BC) and methane could reduce near-term warming by up to 0.5°C (UNEP/ WMO 2011). Although their lifetime is shorter than traditional greenhouse gases (GHGs) these two pollutants have the ability to warm the atmosphere and ­ surface (particularly when they land on snow or ice causing glacier and ice melt). To the extent that biochar production and use can have an impact on either of these pollutants, it can create another pathway for affecting climate and develop- ment. For example, a recent World Bank report (On Thin Ice: How Cutting Pollution Can Slow Warming and Save Lives, 2013) shows that biomass cook- stoves are significant sources of black carbon with a global impact on the climate and also on human health. Hence efficient biochar production could be an opportunity to reduce short-term warming form BC emissions (depending on the ratio of BC to other copollutants, which may offset some of the BC warm- ing), and contributing to human development by saving lives. Depending on the source of biomass used to produce biochar, methane emissions may also be offset relative to decomposition in open dumps or in fields. Lifecycle emission analysis could compare BC and methane emissions relative to the non-biochar alternative in order to determine net climate benefits. Life-Cycle Analysis of Climate Impacts In addition to the carbon stored in the biochar itself a number of important processes can enhance, or reduce, its climate change mitigation potential. These ­ feedback effects need to be accounted for in order to assess the actual net benefits that specific biochar systems can deliver to mitigate climate change. The ­ overall net climate impact of biochar can only be assessed through a full life-cycle assessment (LCA) that takes into consideration the indirect effects listed above, Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 6 Executive Summary as well as other secondary sources of GHG emissions (for example transport, energy needed to start the pyrolysis).The LCA is a static snapshot of a situation at a certain point in time. A timeframe can be included that is specific to the product or system analyzed and that represents the impacts at the end of the period. If a series of these calculations are done with different timeframes the development of the emissions balance can be studied over time. More informa- tion on LCA, including case studies, is found below. Potential Global Climate Change Impacts of Biochar at Scale If biochar were brought to scale what could be the size of its contribution to global mitigation targets? If biochar has the potential to be important globally each project must still be assessed for sustainability and net climate impact on an individual basis, and assess how any wider-scale implementation would impact the global and regional social, biological, and economic systems discussed in this report. It is still too early to estimate what the realistic potential is given all exist- ing economic and social constraints, barriers in technology development, and competing uses in a future bioeconomy. The great advantage of biochar is that it is one of the few GHG reduction strategies that can actually withdraw carbon dioxide from the atmosphere. Over long timescales, however, its main challenge lies in the very fact that biochar will eventually decompose, albeit more slowly than the biomass that it was produced from. Social Impacts When designing biochar systems, it is important to take into account that they can affect energy, health, economics, and food security, including in the following ways: Health and Labor Impacts Possible impacts can occur throughout the production process. Use of improved cookstoves in biochar systems can increase fuel efficiency and widen the variety of feedstocks. This can reduce pressure on wooded ecosystems and decrease the bur- den (mainly on women) of fuel gathering. Improved cookstoves can also reduce indoor air pollution providing significant health benefits throughout the develop- ing world especially for women and children. In addition, if biochar improves crop yields or crop resilience the institution of biochar systems could help buffer prac- titioners against crop shortages and hunger. On the other hand, in the process of producing, storing, transporting, and applying biochar there are potential risks to human health. These need to be addressed by designing appropriate biochar and pyrolysis systems. These risks can include potential emission of toxins and inhala- tion of dust and small particulate matter with consequences for respiratory health. Access to Energy through Biomass The provision of energy through biochar projects could bring benefits at many scales particularly for energy-constrained developing countries. Energy could potentially be used for such critical functions as refrigeration of vaccines, water Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 7 pumping, and lighting after sunset. The long-term success of such initiatives depends on adequate technical support, local “ownership” of biomass energy strategies, and conducive regulatory frameworks. Competing Uses of Biomass The availability of biomass is a key part of what defines the potential scope of biochar projects. Precisely which categories of biomass could be most appropri- ate for a biochar system are highly location and system specific. Pyrolysis systems that operate at different scales require different amounts and sources of biomass. Matters of biomass availability, affordability, and alternative uses need to be taken into account. Potential sources and issues arising from their use include: Purpose-Grown Energy Crops A number of issues relate to the use of dedicated energy crops for biochar pro- duction. This includes the diversion of food crops for fuel, diversion of arable land from food crops, direct and indirect land use change, and whether or not energy crops could truly be constrained to degraded or marginal lands that are unsuitable for food crops. Biomass Residues Any time soil is deprived of biomass that would have otherwise decayed in situ and hence protected and enriched the soil there is the potential for loss of nutri- ents. The costs and benefits must therefore be weighed of leaving biomass in situ versus using it to produce biochar that is then added to the soil. The use of pro- cess residues and waste residues, which may normally be sent to the landfill may not result in losses to soils, but each scenario would need to be evaluated inde- pendently to determine what the standard or baseline practice is. Similar trade- offs apply when weighing the benefits of using biomass for animal fodder or biochar production. Other competing uses of biomass include bioenergy, build- ing materials, and fuel. As previously mentioned benefits are most assured when use is made of “true waste,” especially where the waste in question is simply landfilled providing neither climate nor soil nutrition benefits. Survey and Typology of Biochar Systems The use of biochar is a relatively new technique in modern agriculture building on a body of research that is mostly less than a decade old. Dedicated institu- tional capacity to research and develop biochar applications is only now begin- ning to emerge. A survey was undertaken to obtain an overview of the status of biochar projects globally, particularly in developing countries. The survey had four purposes: (a) to provide a snapshot of the types of biochar projects that currently exist in developing countries; (b) to gather information about con- straints and opportunities in these biochar systems; (c) to develop a typology based on the survey results; and (d) to select a few projects to study the life cycle of GHG emission reductions. The survey was conducted by the International Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 8 Executive Summary Biochar Initiative (IBI) who received 154 completed surveys from 41 countries. Most projects were still in their early stages, and only 12 were identified as having adequate data for an LCA. Those projects were sent a follow-up questionnaire to collect additional data. Some key findings of the initial survey were as follows: • Biochar production technology. Choice of technology was closely tied to available feedstocks. Many respondents (32 percent) were making biochar in traditional charcoal pits, while others had moved on to cleaner, more ­efficient technologies such as batch retort kilns (41 percent) and continuous kilns. The most common stove design was the top-lit updraft (TLUD) g ­ asifier. • Energy use. Only 51 percent of projects indicated that they were or would be capturing useful energy released during biochar production. Of these, cooking was the largest single energy use. Relatively few projects set their sights on generating electricity. • Feedstock choice. A very wide range of feedstocks was reported using all types of biomass including rice residues, wood residues, manure, weeds, and slash-and-char. • Project scale. The majority of biochar production systems were identified as small, tending toward household- and farm-scale systems. The survey data was then used to construct a typology of biochar systems categorizing projects based on production technology, energy recovery type, feed- stock choice, and scale. Cooking energy, as expected, dominated at the household scale, and projects generating electricity occurring at larger scales. The farm scale was most likely to produce biochar without energy capture indicating that the system may be driven primarily by the agronomic benefits of biochar. As the technique of developing biochar system typologies is refined it will provide a useful methodology for assessing and developing biochar production technolo- gies that are suitable to the scale and energy needs of users, and enable due con- sideration to be given to all of the other social, ecological, and economic compo- nents of the agricultural and energy systems in which biochar may play a role. Life-Cycle Assessment of Existing Biochar Systems Life-cycle assessment (LCA) is an ISO 14040 normed methodology to evaluate the environmental flows associated with a product, process, or activity through- out its full life. This involves quantifying energy, resources used, and emissions created. Because of its whole system approach, incorporation of economic costs and transparent methodology LCAs are an appropriate method of analysis for estimating the global warming and net economic impacts of biochar systems. The four main elements to the LCA methodology are (a) goal and scope definition, including system boundaries; (b) inventory analysis, including input and output flows of the system; (c) impact assessment, including environmental consequenc- es and climate change impacts; and (d) interpretation, including contribution Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 9 analysis, sensitivity analysis, and data quality assessment. The contribution analy- sis calculates the relative impact of different life-cycle stages (for example, feed- stock production, transportation, pyrolysis) to identify those stages with the most impact, and to identify opportunities to reduce GHG emissions and costs of the system. The sensitivity analysis determines how the results may be affected by uncertainty or variability in the data and between systems. Of the 154 projects that responded to the survey, 25 were selected on the basis of project dataset completeness. From that group, three top projects were select- ed as case studies for an LCA according to six criteria: degree of integration into local economy, variation in biochar production technology and scale, data avail- ability and quality, replicability in a broad range of contexts, impact on GHG reduction (climate change mitigation effect, expressed as c ­ arbon dioxide equiva- lent or CO2e), and geographic location. The following were the three projects: • Kenya: household-scale pyrolysis cookstove producing biochar in addition to providing heat for cooking for subsistence farmers; • Vietnam: biochar production as a by-product of small-scale rice wafer pro- duction from rice husk feedstock; • Senegal: larger-scale continuous process pyrolysis unit producing biochar used by local onion farmers. Each project was analyzed using the LCA methodology described earlier. The findings of the analyses are summarized in boxes ES.1, ES.2, and ES.3. Box ES.1  Summary of Kenya Case Study The Kenya household pyrolysis cookstove system with biochar returned to soil has the potential for climate change mitigation through carbon sequestration and GHG emission re- ­ ductions, while also being economically viable for the smallholder farmer. Using the pyrolysis cookstove for household cooking and producing biochar, the net GHG reductions are –1.8 tonnes CO2e per tonne of dry pyrolysis (secondary) feedstock. The net economic balance is –$1 per tonne of dry matter where no monetary value is assigned to surplus grain, labor savings, or potential carbon credits. If the 62 hours saved in fuelwood collection are mone- tized, the net return would be $8 per year. If carbon credits were received (at $19 per tonne of CO2e), the household could return from $27 to $50 per tonne of dry matter, depending on whether avoided emissions are valued the same as carbon sequestered directly in the biochar. If the surplus maize is valued, the net return would be $1 per cropping season of biochar’s effectiveness, or $245 for a biochar effectiveness of 50 years. Synergistic benefits of the py- rolysis cookstove project may include decreased indoor air pollution and related illnesses, re- duced fuelwood consumption and thereby decreased deforestation pressures, and improved long-term soil fertility. More detailed emissions data for BC and organic carbon are needed to determine if this method results in additional climate benefits through BC reduction. box continues next page Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 10 Executive Summary Box ES.1  Summary of Kenya Case Study (continued) The contribution analysis reveals that the net GHG balance is largely driven by the avoided emissions from the traditional three-stone fire and the sustainability of the primary and ­ secondary cookstove feedstock. If the feedstock is unsustainably harvested and does not regrow, then emissions during cooking would not be offset by the biomass regrowth. ­ Meanwhile, the amount of stable carbon in the biochar contributes 29 percent of the net ­ GHG reductions. Soil nitrous oxide emissions can also play an important role in the GHG balance, thus more data are required to quantify this effect. ­ The sensitivity analysis reveals that the net GHG balance is relatively insensitive to chang- es in methane emissions during traditional or pyrolysis cooking, the crop yield response with biochar additions, and the duration of biochar’s agronomic effect, within the realistic range tested for these parameters. The surplus maize is most sensitive to the crop yield response and the biochar application rate. Meanwhile, the net revenues are very sensitive to the crop yield response and the price of maize. This Kenya pyrolysis cookstove system presents itself as a low-risk biochar project with climate change adaptation, economic, and public health benefits for the smallholder farmers implementing these stoves and utilizing the biochar. Box ES.2  Summary of Vietnam Case Study The Vietnam rice husk biochar system has potential for climate change adaptation and mit- igation through carbon sequestration and GHG emission reductions, while also being eco- nomically viable for the smallholder farmer. The net GHG reductions are −0.5 tonnes of CO2e per tonne of dry rice husk feedstock. The net economic balance is +$948 per tonne of dry matter over the 50 years of biochar’s agronomic effect, or +$7 for a one-crop effect. In this project, carbon credits are not received, but the farmer could potentially return an addi- tional $15 per tonne of feedstock with emissions trading at a price of $19 per tonne of CO2e. Assuming that rice husk remains a sustainable feedstock, the contribution analysis reveals that the net GHG balance is largely (81 percent) driven by the stable carbon in the biochar. Reduced fertilizer needs and soil carbon accumulation play lesser roles in the GHG balance. Soil nitrous oxide emissions could also play an important role in the GHG balance, thus more data are required to quantify this effect. The sensitivity analysis reveals that the net GHG balance is relatively insensitive to chang- es in methane emissions during rice wafer cooking and avoided rice husk burning, the crop yield response with biochar additions, and the duration of biochar’s agronomic effect, within the realistic range tested for these parameters. The net revenues are very sensitive to the crop yield response and the duration of biochar’s agronomic effect, while the relative impact of the transportation distance of the biochar is less. This Vietnam rice husk biochar system presents itself as a low-risk biochar project with climate change adaptation and economic benefits for the smallholder farmers incorporating biochar into their practices. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 11 Box ES.3  Summary of Senegal Case Study The Senegal biochar system has potential for climate change adaptation and mitigation through carbon sequestration and GHG emission reductions, while also being economically viable for the smallholder farmer. The net GHG reductions are –0.4 tonnes of CO2e per tonne of feedstock. The net economic balance is +$6,696 per tonne of dry matter over the 50 years of biochar’s agronomic effect, or +$24 for a one-crop effect. In this project, carbon credits are not received, but the farmer could potentially return an additional $8 per tonne of feedstock with emissions trading at a price of $19 per tonne of CO2e. Assuming that the feedstock remains a sustainable source, the contribution analysis re- veals that the net GHG balance is largely (87 percent) driven by the stable carbon in the bio- char. Soil nitrous oxide emissions could also play an important role in the GHG balance, thus more data are required to quantify this effect. The sensitivity analysis reveals that the net GHG balance is relatively insensitive to ­changes in methane emissions during pyrolysis and avoided rice husk decay, the crop yield response with biochar additions, and the duration of biochar’s agronomic effect, within the realistic range tested for these parameters. Soil carbon accumulation and transportation of the py- rolysis unit also play small roles in the GHG balance. The net revenues are extremely sensitive to the crop yield response, the duration of biochar’s agronomic effect, and the price of onions, while the relative impact of the biochar transportation distance, the biochar price, and the pyrolysis unit production time is less. This Senegal biochar system presents itself as a low-risk biochar project with climate change adaptation and potentially high economic benefits for smallholder farmers incorpo- rating biochar into their practices. Case Study Comparison and Conclusions ­ ollows: The main findings emanating from a comparison of the case studies are as f • The net GHG balance of the three studies ranges from −0.4 to −1.8 tonnes of CO2e per tonne of dry matter. The Kenya cookstove project has the highest amounts of GHG reductions due to the avoided emissions from traditional cooking. • The Vietnam case study in particular highlights the role of reduced agricul- tural inputs, specifically fertilizers, in reducing GHG emissions. • All systems analyzed demonstrate that the emissions from biochar produc- tion (whether cookstove or village-scale unit), transportation, and stove or kiln construction are minimal compared to the net balance of the system. • The most important result regarding the economics is that each project has a very short payback period—within one year of when surplus crops are ­monetized. • The yield of the crops to which the biochar is applied plays the largest role in determining the economic balance, implying that the farmer’s choice of crops can be as important as the type of soil to which the biochar is applied. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 12 Executive Summary • Another important factor in the economic balance is the capital and operat- ing costs of the biochar production technology. In the case of cookstoves, the capital cost over the lifetime of the stove is small and the operating costs are minimal. In contrast the Senegal village-scale pyrolysis unit has significant costs, which are only offset by the large revenues from surplus crop sales. • The price the farmer receives for the surplus crop is also important for deter- mining the economic balance, although less so than the crop yield response to biochar. • The duration of biochar’s agronomic effect plays a significant role in the ­ economics of biochar systems in developing countries. • The biochar application rate is also critical; determining the minimum biochar application rate that still achieves the desired agronomic response ­ will enable farmers to make best use of limited biomass and economic ­resources. Biochar projects in developing countries have the potential to reduce GHG emissions and be economically viable, as demonstrated by the life-cycle assess- ment case studies in Kenya, Vietnam, and Senegal. Ensuring the sustainability of the feedstock for biochar production is the first and most important step in achieving GHG reductions. With the feedstock sustainability in line, the recalci- trant carbon in the biochar is the largest source of direct carbon sequestration by removing atmospheric carbon dioxide and stabilizing it in the biochar. Avoided emissions from traditional biomass management practices, such as traditional cooking, can also play an important role when the feedstock is derived from a nonrenewable source. Avoided rice husk burning or decay is less influential because of the renewability of the resource. Emissions during pyrolysis (biochar production) have only a small impact on the net GHG balance for these systems. Meanwhile, the economics of these projects is largely dependent on the effective- ness of biochar to address soil fertility constraints, the duration of biochar’s agro- nomic effect, the biochar application rate, and the value of the crops to which biochar is applied. Research and development efforts should focus on creating knowledge and understanding of these critical and interdependent parameters. This will enable biochar projects in developing countries to be implemented with the highest probability for improving the livelihoods of smallholder farmers while also mitigating and adapting to climate change. Aspects of Technology Adoption Economics of Biochar The results of the LCA case studies and other biochar analyses demonstrate that biochar systems can offer potential GHG reductions in the range of 0.4–2.0 tonnes of CO2e per tonne of dry feedstock. However, the implementation and sustainability of all biochar systems, particularly those in developing countries where start-up capital and other funds are limited, are dependent on the eco- nomics of these projects. If the economics of the projects are favorable to small- Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 13 holder farmers, the adoption of biochar systems in smallholder agricultural sys- tems will be facilitated and GHG emissions will be further reduced. The economics of biochar systems in developing countries are dependent on multiple factors that are specific to the project. Some factors are easily quanti- fied, such as: the cost of the feedstock, the capital and operating costs of the stove or kiln, transportation, the price of biochar and surplus crop yields, and the sav- ings from reduced agricultural inputs. Others are less easily quantified, such as: decreased labor, improved air quality, and increased household food. Furthermore, additional benefits may potentially arise due to decreased deforestation pres- sures, improved water use efficiency, and climate change adaptation. Finally, although none of the biochar projects receive carbon credits, this contribution may increase revenues as projects progress. Overall, the economics of biochar projects analyzed in the case studies are largely determined by the price farmers receive (or lack thereof) for surplus crops due to biochar additions to the soil. Engagement with Carbon Markets A number of basic guidelines are required for a successful biochar project to reduce GHG emissions and to generate emission reductions, as follows: • Additionality and baselines. Establishing the baseline scenario is critical to demonstrating “additionality,” which implies that a project would not have taken place under a business as usual scenario and without the incentive pro- vided by the price of carbon. • Permanence. Establishing the fraction of biochar that will be relatively stable is critical to maintaining carbon storage. • Leakage and system drivers. Leakage occurs when emission reductions with- in a project boundary result in increased emissions elsewhere. For example black carbon emissions to the atmosphere, or “rebound effects,” that occur when a more efficient stove encourages more cooking and hence more fuel use than otherwise predicted. • Measurement, reporting, and verification. In order to understand the climate effects of a project, it is essential to be able to quantify and verify its impact. The challenge lies in measuring the impact of the biochar, either directly or indirectly. There are currently no approved biochar carbon finance methodologies—­ neither under the Clean Development Mechanism (CDM) nor under any of the voluntary carbon market regimes. Sociocultural Barriers to Adoption No matter what the technical potential benefits of biochar are, their realization depends on whether and how people implement biochar systems. This in turn requires a highly location-specific understanding of people and their needs, val- ues, and expectations. To gain a better understanding of sociocultural factors, including barriers, a second survey was drafted and sent to the respondents to the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 14 Executive Summary initial survey (described above), receiving 48 responses. Barriers identified included: • Lack of awareness of biochar and a need for education and demonstration projects to show farmers that making and using biochar would be worth their time; • Labor barriers, for example extra labor required to operate slash-and-char systems and gather dispersed feedstocks; • Restricted availability of biochar production technologies; • Environmental concerns related to changing resource use patterns. This survey also investigated the prevalence of biochar as a traditional farming practice and found that in many regions, some form of biochar application was a traditional practice that had been swept away by the advent of chemical fertil- izers and other twentieth-century methods. Many felt that the existence of the traditional practice made their job of communicating the benefits of biochar much easier. Regarding the perceived benefits of biochar systems, respondents cited soil improvement, increased crop yields, decreased fertilizer use, improved water use efficiency, clean cookstoves, income benefits, and environmental hygiene. Respondents were split regarding the importance of carbon offset payments to project viability. Almost exactly half said that carbon payments would be nice but that they were not counting on them. The one remaining quarter said their project could not do without carbon payments and the other quarter replied they were not going to pursue them at all. Potential Future Involvement of Development Institutions, Including the World Bank The summary above has demonstrated the wide-ranging potential of biochar systems to contribute to the new paradigm of green growth and development, allied to climate resilience. At the same time, biochar is a relatively new science and many uncertainties exist requiring further research and analysis. Life-cycle assessments are needed, which includes, not just technical and agricultural mat- ters, but also the sociocultural aspects of biochar systems. Given the location- specific nature of biochar systems, a challenge lies in conducting applied long- term research under real-world, developing-country conditions, particularly at scale of implementation. Institutions like the World Bank, particularly through its technical advisory and convening services, could help to forge effective alliances between the research community and development practitioners on the ground. The Global Inventory of Long-Term Soil-Ecosystem Experiments, established by the Duke’s Nicholas School of the Environment and Earth Sciences, is a good example of how such an applied scientific approach could work. As this body of experiences expands it will be possible to refine the criteria of desirable biochar interventions, Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Executive Summary 15 and establish biochar sustainability standards, which could then serve as a basis for policy regulation or certification schemes. As an active partner in the Climate and Clean Air Coalition (CCAC) to Reduce Short-lived Climate Pollutants (SLCPs), the World Bank is committed to supporting new and innovative ways to reduce the emissions and impacts of BC and methane. To the extent that biochar production and use result in net reduc- tions of these SLCPs there are significant opportunities to expand biochar activities throughout the CCAC network of partners. Furthermore, development institutions such as the World Bank could engage in knowledge- and technology-oriented services, as well as financing services for biochar projects or programs. These could include, but are not limited to, devel- opment of carbon finance-related methodologies for different biochar systems. The World Bank’s carbon funds, and other programs such as those administered by the Global Environment Facility, have a potential role to play in that regard. Given the reluctance of the private sector to engage in nascent, unproven tech- nologies, institutions such as the World Bank and particularly the private sector arm of the World Bank, the International Finance Corporation, will be key play- ers in providing financing services for biochar projects in developing countries over the next few years. Publicly funded demonstration, research, and develop- ment will need the engagement of bilateral and multilateral development institu- tions. The feasibility of biochar pilots may be rapidly assessed when considering key questions such as the following: • Will the biomass be sourced from true waste sources? • Will the feedstock be sourced from safe materials? • Will the quantities of biochar required match the availability of suitable feed- stock locally? • Will the pyrolysis system meet certain levels of conversion efficiency and cleanliness? • Will the appropriate biochar be applied to appropriate soils? • Will it be practical during monitoring activities to verify carbon storage of biochar through its application to soils? • Will local farmers likely adopt the technology after the demonstration phase? Involving the private sector will be crucial in bridging the funding gap that typically constrains the implementation of new technologies with long lead times and considerable research requirements. Innovative financing solutions will be needed. For example, front-loading the potential carbon benefits of biochar sys- tems with the aim of attracting private investors early on. Again, there is poten- tial for the World Bank to play a role in helping to set up the complex structures required. Direct financing of biochar projects, facilitating research, and providing knowledge services are other ways in which the World Bank and other organiza- tions can support development of biochar systems. Given the wide-ranging potential of biochar systems, it is important to build synergies with other projects and programs. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 16 Executive Summary Finally, it is clear that detailed analyses of current projects need to be carried out across their life cycle in order to assess the costs and benefits, particularly with regard to climate, energy production, and food security. The LCA projects described in this report should be followed up over time, and new ones added. A project catalog should be maintained, and data collection should continue for all biochar projects. Lessons learned will be extremely valuable for future proj- ects and programs, and systematic and robust systems should be set up for collecting data that can be of scientific value in demonstrating the implications ­ of biochar systems for crops, climate, and human well-being. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 1 Introduction Potential of Biochar Undoubtedly, three of the biggest challenges of the twenty-first century are the need to almost double food production by 2050 (FAO 2009), to adapt and build resilience to a more and more challenging climatic environment, and to simultaneously achieve a substantial reduction in atmospheric greenhouse gas concentrations (IPCC 2007). The surge of interest in ­ ­ climate-smart farming practices with the aim to improve rural livelihoods while mitigating and adapting to climate change has also sparked curiosity in using biochar as a tool to fight climate change while improving soil fertility. Both public and private sector engagements in biochar necessitate a critical investigation of the opportunities and risks for biochar production and inte- gration into managed systems. Biochar is the carbon-rich organic matter that remains after heating biomass under the minimization of oxygen during a process called “pyroly- ­ sis.” Its r ­elevance to preventing deforestation, promoting agricultural resilience, and p ­ ­roducing renewable energy, particularly in developing countries, makes it an important issue. At the same time, the potential ­ effects on fertility of its a ­pplication to soils are diverse, and its climate impact is ­ contingent on the design of the system into which it is integrated, making it a complex issue. There are a number of reasons why biochar systems might be particularly relevant in developing-country contexts. The potential for biochar to improve soil fertility could result in increased yields from previously degraded soils for smallholder farmers. Improved cookstoves that produce biochar as well as heat for cooking could reduce indoor air pollution and fuel gathering. Both these results could also be beneficial to forests, as enhanced food production capacity could potentially decrease the need to clear more forested land for agriculture, and more efficient cookstoves could decrease wood gathering from forests already in decline. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   17 18 Introduction Increases in Research into Biochar Although biochar has gathered much interest in the past few years, active bio- char production and application systems are just beginning to appear, and there are still gaps in our knowledge of biochar systems. While some characteristics are becoming better understood, questions regarding biochar’s impacts on soils, cli- mate, and rural societies remain. Dedicated research started in the late 1990s, apart from some notable early research before 1950 (Lehmann and Joseph 2009), but publication has only accelerated in recent years (figure 1.1). Content and Purpose of Study This report offers a review of what is known about opportunities and risks of biochar systems. Its aim is to provide a state-of-the-art overview of current knowledge regarding biochar science. In that sense the report also offers a recon- ciling view on different scientific opinions about biochar providing an overall account that shows the various perspectives of its science and application. This includes soil and agricultural impacts of biochar, climate change impacts, social impacts, and competing uses of biomass. The report aims to contextualize the current scientific knowledge in order to put it at use to address the develop- ment—climate change nexus, including social and environmental sustainability. Ultimately, forward-looking suggestions will be derived from the review part of Figure 1.1  Acceleration of Published Research on Biochar and Charcoal 160 100 Number of publications in Thomson Reuters Web of Science 140 80 Extrapolation Proportion of biochar and charcoal 120 as a fraction of compost % 100 60 80 40 60 40 20 20 0 0 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 Year Biochar Charcoal Biochar + charcoal Source: Thomson Reuters Web of Science; only articles with keywords compost, biochar, bio-char, agrichar, agri-char, or charcoal for soil application in the title; data from 2011 are for the first four months and extrapolated in white bar for 12 months. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Introduction 19 the report which will show how development institutions, including the World Bank, could support continued research and beneficial application of biochar in development. The report is organized as follows. The present chapter offers some introduc- tory comments and notes the increasing interest in biochar both from a scien- tific and from a practitioner’s point of view; chapter 2 gives further background on biochar, describing its characteristics and outlining the way in which biochar systems function. Chapter 3 then considers the opportunities and risks of biochar systems. Based on the results of the surveys undertaken (see previous ­ ­ paragraph), chapter 4 presents a typology of biochar systems emerging in practice, particularly in the developing world. New, ISO 14040-based life-cycle ­ assessments of the net climate change impact and the net economic profitability of three biochar systems with data collected from relatively advanced biochar projects were conducted for this report and are presented in chapter 5, providing a novel understanding of the full life-cycle impacts of these known biochar sys- tems. Chapter 6 investigates various aspects of technology adoption, including barriers to implementing promising systems, focusing on economics, carbon market access, and sociocultural barriers. Finally, the status of knowledge regard- ing biochar systems is interpreted in chapter 7 to determine potential implica- tions for future involvement in biochar research, policy, and project formulation. Methodology The method for preparing this report was wide ranging and comprehensive, and included the following elements: Desk review. A review was undertaken of the current scientific literature per- taining to biochar and issues relevant to its production and application to soils. Survey of biochar systems. A two-step survey was undertaken to shed light on existing biochar systems, especially those found in developing countries. The initial survey elicited 154 responses, which captured a diversity of biochar projects and biochar systems at different stages of advancement and with different technologies and feedstocks, reflecting differences in the priorities of ­ users. In the second step, an additional survey was drafted and sent to the 154 responders to learn more about the social and cultural barriers to biochar adoption, receiving 48 responses. Findings from an expert workshop. The report was strengthened and improved through discussions during a workshop held in Washington, DC on May 11, 2011. Comments and advice from the workshop participants helped to ­ inform the analysis of survey data. Typology. The data derived from the survey were used to develop a preliminary typology of biochar systems, based on production technology, energy use, feedstock choice, and project scale. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 20 Introduction Life-cycle assessment. The environmental flows associated with biochar systems were evaluated using a life-cycle assessment, based on the ISO 14040 stan- dard. Three projects—located in Kenya, Vietnam, and Senegal—were select- ed, based on their integration into the local economy, variation in technology and scale, data availability and quality, replicability, impact on emission reduc- tions, and geographic location. A comparison of the results of the life-cycle assessments was used to draw conclusions that could inform implementation of future biochar projects. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 2 Background on Biochar Characteristics and Historical Basis of Biochar Biochar is the solid product remaining after biomass is heated to temperatures typically between 300°C and 700°C under oxygen-deprived conditions, a pro- cess known as “pyrolysis.” Through pyrolysis, organic materials fundamentally change their chemical composition and are dominated by aromatic carbon forms, in contrast to the original biomass feedstock that mainly contains cellulose, hemi- cellulose, and lignin. Biochar falls into the spectrum of materials called “black carbon,” which includes substances with a range of properties, including slightly charred biomass, charcoal, and soot (Masiello 2004). Black carbon can be pro- duced during the combustion of fossil fuels such as coal or diesel as well as recently living biomass. However, the term “biochar” excludes black carbon derived from fossil fuels or nonbiomass waste, nor would it include materials called “soot” in general usage. Biochar is best thought of as a system-defined term referring to black carbon that is produced intentionally to manage carbon for climate change mitigation purposes combined with a downstream application to soils for its agricultural effects. This definition of biochar will be used for the purposes of this report. In essence, biochar is distinguished from charcoal in this report by the fact that biochar is produced with the prior intent to be applied to soil, be it as a means of improving soil productivity or carbon storage or both. Also, the array of feed- stocks for biochar is much broader than for wood charcoal used as fuel. In prin- ciple, biochar can be made from any type of biomass. Although the term “biochar” has come into common usage only relatively recently, the practice of amending soils with charcoal for fertility management goes back millennia. New instances of traditional practice using biochar are still being discovered around the world. While there is increasing interest in research- ing new evidence for these ancient practices, for instance in the search for African dark earths (Fairhead and Leach 2009), the currently best-known examples include the ancient practice of adding rice husk charcoal to agricul- tural soils in Asia (Ogawa and Okimori 2010) and the development of the Amazonian soils known as terra preta, or “dark earths” (figure 2.1). Terra preta Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   21 22 Background on Biochar soils are rich in organic matter and highly fertile compared to the adjacent native soils (Lehmann et al. 2003). Terra preta soils also stand out for their capacity to store carbon, with as much as three times the amount of soil organic carbon compared to surrounding soils (Glaser et al. 2001). They are thought to have been created through soil management by pre-Colombian populations who amended the soils with, among other components, charcoal, giving the soils their characteristic black color. While terra preta can help us understand the effects of biochar in soils, biochars can have a relatively wide range of characteristics. Terra preta soils are the product of many different influences in addition to biochar, and not all its properties are a result of biochar additions. Some of the most remarkable and currently best-understood properties of biochars include their effects on soil nutrient dynamics and the high stability of the carbon of which they are composed. These properties are considered in more detail in chapter 3. Because biochar can be produced from almost as many types of feedstock as there are types of biomass, can be created over a wide range of temperatures, and could be applied to a diversity of soil types, it is inappropriate to speak about “biochar” as though it is one homogenous material. Rather, it is important to understand how different production conditions can result in different types of biochars, and how these chars interact with different types of soils. This under- standing is an essential component to the design of any successful biochar system. Ongoing efforts are being led by the International Biochar Initiative (IBI) to develop a characterization standard for biochars (IBI 2012). Figure 2.1 Terra Preta Soil Pit near Manaus, Brazil, Showing Thick, Dark, Carbon-Enriched Top Layer Source: Photograph courtesy of T. Whitman, 2010. Biochar Systems for Smallholders in Developing Countries • http://dx.doi.org/10.1596/978-0-8213-9525-7 Background on Biochar 23 Biochar Systems In order to understand the net impact of biochar, it is essential to understand the entire biochar system (as exemplified by the life cycle assessments investigated in chapter 5). Depending on where the system boundaries are drawn, different elements may be included, but critical to every biochar system are: (a) the source of biomass, (b) the means of biochar production, and (c) whether and how it is applied to soil (figure 2.2). Biomass Source Biochar can be produced from almost any type of biomass, including agricultural wastes, rice husks, bagasse, paper products, animal manures, and even urban green waste (Lehmann and Joseph 2009). The biomass used as feedstock is an example, influential factor for the type of biochar produced and its properties. For ­ rice husk-derived biochars have been found to have relatively high ash contents compared to corn cob-derived biochars (Raveendran, Ganesh, and Khilar 1995). The feedstock choice has implications for the ultimate impact of the biochar system. Because many different biomass types can be used for pyrolysis, care must be taken in selecting a biomass feedstock source. Critical factors include its initial moisture content, distance required to transport biomass to the pyrolysis site, whether the biomass source is rural, urban, or industrial, and whether it is Figure 2.2  Biochar as a System-Defined Concept Agricultural Fast/slow waste pyrolysis Urban Gasification waste e rc Pr chno ou te od lo ss uc gy as tio om n Bi Biochar Dedicated System Energy feedstock capture Soil application Soil characteristics Climate Farming system Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 24 Background on Biochar purpose grown or a co- or by-product of another process (Lehmann and Joseph 2009). Focusing on “true wastes” for feedstocks could help to maintain a low- impact system (Whitman, Scholz, and Lehmann 2010). True wastes are materials whose use as feedstock will not result in disruptions in local carbon and nutrient cycling, as when crop residues are removed from fields, or the creation of drivers for other negative land use impacts, such as clearing forest for devoted biofuel crops. The concept of true wastes is tied directly to competing uses of biomass, discussed in chapter 3. Production Technology Biochar production can be performed at a very wide range of scales, from the level of a household cookstove in Kenya that produces biochar as well as heat for cooking (Whitman et al. 2011), to the level of an industrial pyrolysis plant that generates both bioenergy and biochar (Gaunt and Cowie 2009; Hammond et al. 2011; Roberts et al. 2010). A system’s size and the needs that drive it—whether it is producing energy for cooking, heating, or broader energy needs—are major factors for determining the final impact of such systems. Biochar-producing systems are usually classified as gasifiers or pyrolyzers and produce in essence three different products that depend on the technology used, namely biochar (solid), syngas (gaseous), and bio-oil (liquid by-product). Pyrolysis systems use kilns or retorts, and exclude oxygen while allowing the pyrolysis gases, or “syngas,”1 to escape and be captured for combustion. Pyrolysis systems are classified as slow, fast, and flash pyrolysis, with fast pyrolysis produc- ing more oils and liquids while slow pyrolysis tends to produce more syngas, and flash pyrolysis generating mostly biochar (table 2.1). Gasification systems are usually designed with gas production as the central focus rather than biochar or oil production, and generally produce less biochar than pyrolysis. This is because some oxygen is intentionally introduced in the system; the less oxygen present, the more biochar is produced. However, gasifier systems could be optimized for biochar production, with as much as 30 percent biochar yield predicted to be possible in gasifiers (Brown 2009). For example, rice husk gasifiers are a special Table 2.1  Typical Product Yields (Dry Basis) for Different Types of Thermochemical Conversion Processes That Generate Carbonaceous Residues Liquid Solid Gas (bio-oil) (biochar) (syngas) Type Temperature Time Pressure (%) (%) (%) Hydrothermal 180–250°C 1–12 hours Yes 5–20 50–80 2–5 carbonization Slow pyrolysis 300–600°C 5–30 min to days No 30 30 40 Flash pyrolysis 350–650°C 5–30 min 1–3 MPa 8 40 52 Fast pyrolysis 400–550°C ~ 1 sec No 75 12 13 Gasification 600–900°C ~ 10–20 sec No 5 10 85 Sources: Antal, Mochidzuki, and Paredes 2003; Bridgwater 2007; Libra et al. 2011; Titirici, Thomas, and Antonietti 2007. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Background on Biochar 25 case where the high silica content of rice husks prevents the complete combus- tion of carbon. As a result, rice husk ash may contain as much as 38 percent carbon (Karve et al. 2011), and is often described not as ash but as “carbonized rice husk.” Liquefaction or hydrothermal carbonization is a technology that uses even lower temperatures than pyrolysis, but operates with biomass in liquids under high pressure. Their properties are distinct from biochars, and are not fur- ther examined in this report. In the absence of technology access constraints, the preferred technology will depend on users’ preferences in the arbitration between energy and biochar production. Soil Application of Biochar and Its Alternatives The end use of biochar involves its ultimate application to soil. However, the solid residue from pyrolysis or gasification can also be used for energy through com- plete combustion, treated as a waste product, or used for a variety of ­ medicinal, industrial, or domestic processes. The optimal end use option depends on the values and objectives of the biochar producer, such as climate change impact, energy production, soil fertility, and economics (as discussed in chapter 3). Gaunt and Lehmann (2008) found that avoided greenhouse gas (GHG) emis- sions in a modeled industrial pyrolysis system are between 2 and 5 times greater if biochar is applied to agricultural land as opposed to being solely burned as a fossil fuel. If climate change mitigation was the producer’s objective, then biochar application to soil would be the clear choice for its end use. The global model developed by Woolf et al. (2010) to estimate the total contribution of sustainable biochar to climate change mitigation expands this finding. It concludes that bio- char has greater mitigation potential applied to soil than as an energy source only if it generates soil productivity benefits or reduces emissions of non-carbon diox- ide GHGs from soil. In high-energy-demand scenarios, such as in households where there is a shortage of fuel, combusting biochar for energy could conceiv- ably be chosen over applying it to soils. If biochar were consumed for energy, rather than applied to soils or reserved as a store of carbon, then no agronomic effects of biochar would occur, nor would there be any long-term storage of car- bon. Still, this flexibility could actually be considered an advantage of biochar systems—giving the user greater economic flexibility to utilize the biochar pro- duced for either fuel or soil building, or both, depending on the need at the time. If biochar is neither used for energy, nor applied to soils, it has been suggested that it may simply be stored in geologic reservoirs, such as landfills, abandoned mines, or at sea, as described by Seifritz (1993) and Lee et al. (2010). But, in this scenario, the possible agronomic effects from biochar application to soils would certainly not occur. This would completely remove a potentially important driver for the system—any effects of biochar application on soil fertility—and would result in the withdrawal not only of carbon from the soil system, but also of all other nutrients that may be stored in the biochar. It should be noted, how- ever, that biochar conversion in some systems also reduces nutrient return to soil, mainly the amounts of nitrogen and sulfur, compared to leaving crop residues in the field (chapter 3). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 26 Background on Biochar Thus, for the purposes of this report, the focus is on integrated bioenergy- biochar-soil application systems, and the two scenarios described above will not be considered other than as alternative uses. During the application of biochar to soil, two major aspects to consider are the appropriate selection of biochars for specific soil constraints and the actual biochar application methods. The recognition of appropriate biochar-soil combi- nations or biochar and specific farming practices is essential for any successful biochar system. As discussed further in chapter 3, because biochars and soils can have diverse properties, it is necessary to understand the characteristics of both in order to achieve an effective pairing. Because biochar is a newer technology in modern farming (than, for example, compost or mineral fertilizer management), relatively little work has been done to develop optimal application strategies for agricultural (or other) soils. Biochar could be applied on its own or mixed with other additions such as manure, compost, or mineral fertilizers. It could be incor- porated into the topsoil during plowing; through banding (localized application); by top dressing (applying to soil surface and allowing natural processes to incor- porate it) (Verheijen et al. 2010); in planting holes (Blackwell, Riethmuller, and Collins 2009); as seed coating; in planting tubes; or when soils are built for estab- lishing green roofs (Beck, Johnson, and Spolek 2011) or recreational turf. Note 1. Syngas production from fast and slow pyrolysis depends on the specific system, but is generally composed of a range of gases, including CO, CO2, H2, CH4, and low-molecular-weight hydrocarbons such as C2–C6 (Ioannidou et al. 2009). ­ Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 3 Opportunities and Risks of Biochar Systems Introduction In order to assess the net climate impact and sustainability of a biochar system, it is important to understand the effects of biochar on soil health and produc- tivity, and on greenhouse gas (GHG) emissions. A number of studies have demonstrated that biochar soil management has potential benefits for soil fertility and agricultural productivity, though the range of system variables (including soil and biochar characteristics) makes precise analysis difficult. Similarly, the prospect of climate change mitigation through biochar technolo- gies has attracted widespread attention. Possibilities for emission reductions exist through carbon stabilization, renewable energy applications, and waste diversion. A number of challenges remain to be overcome, however, to ensure that benefits are optimized and leakage of GHGs is avoided. In that regard, efforts should be made to ensure that only “true wastes” are used for biochar production. Undertaking a life-cycle assessment is essential in order to evaluate the net climate impact of biochar systems. It is vital that any review of the potential benefits of biochar systems extends beyond consideration of the technological and scientific aspects to take account of the social dimensions. While various positive impacts have been identified, including increased fuel efficiency leading to a reduction in indoor air pollution and less time spent gathering fuelwood (with particular benefits for women), potential risks are also present, for example threats to health from inhalation of black carbon and toxins. In addition, challenges exist in ensuring that the benefits from biochar systems are shared equitably, and that nonbeneficial changes in land use do not result from the addition of biochar to the competing demands for biomass. This chapter aims to present the current state of knowledge on these oppor- tunities and risks of biochar systems, while recognizing that the complexity of the issues surrounding biochar, and the relative recent recognition of its great potential, means that many knowledge gaps exist and a great deal of research is needed to gain a true idea of the benefits it can offer. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   27 28 Opportunities and Risks of Biochar Systems Impacts on Soil Health and Agricultural Productivity The potential effects of biochar on soil fertility and agricultural productivity are widely reported (Blackwell, Riethmuller, and Collins, 2009; Chan and Xu 2009; Lehmann and Rondon 2006; Sohi et al. 2010; Verheijen et al. 2010). As described in chapter 2, terra preta is a striking illustration of the potential for improving the fertility of highly weathered tropical soils. In a meta-analysis of 86 different bio- char treatments on a range of soil and crop types, Verheijen et al. (2010) reported a grand mean of 10 percent increase in plant productivity. In addition, a growing body of literature indicates that biochar amendments are in some situations able to increase yields substantially, sometimes by more than 100 percent compared to a fully fertilized control (for example, Steiner et al. 2007; Kimetu et al. 2008; van Zwieten, Kimber, Morris, Chan et al. 2010). The potential agronomic bene- fits reported by biochar practitioners are not only greater yields, but also better predictability in yields, reduced germination time, extension of the cropping season, and improved resilience to drought (Hayes 2010; Couto 2010; Reinaud 2010). Looking at the properties of some specific biochars, it is reasonable to expect that biochar soil management in some circumstances could even open new possibilities for cropping, producing crops on normally unsuitable sites (Lehmann and Rondon 2006). Key Factors That Influence Biochar’s Impact The high variability of biochars and soils requires systematic studies across soils to identify important variations between different biochars, soil types, and quan- tities applied. In addition, the physical structure and chemical properties of biochars evolve over time (Cheng et al. 2006; Cheng, Lehmann, and Engelhard 2008; Nguyen et al. 2008), which makes predicting the long-term effects on soil fertility and agricultural productivity through short-term experimentation more challenging. Studies are often difficult to compare as they use biochars of differ- ent origins and production methods, different soil types, and different climatic conditions, and often track only plant growth as a proxy for crop yields. One important problem with short-term experiments is that some improvement in plant productivity is likely attributable to the nutrient-rich ash content of the char, which provides a real but relatively short-lived fertilizing effect. This section will review the mechanisms and risks associated with some of the key factors that influence the impact of biochar on soil health and agricultural productivity, including soil pH, nutrient availability, soil moisture, soil organic matter, and the amount of biochar applied. Soil pH Biochar pH values can range from acid to basic (pH from < 3 to > 12) (Cheng et al. 2006; Lehmann 2007). Most of the biochars currently in use have a neutral to basic pH,1 which is why biochar applied in acidic soils tends to cause a liming effect. In their study, Verheijen et al. (2010) found that the soil pH rose on aver- age from pH 5.3 to pH 6.2 after biochar application. There was a significantly higher gain in plant productivity following biochar addition in acidic Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 29 Percentage Change in Crop Productivity upon Application of Biochar under Figure 3.1  Different Scenarios Acidic free 282 21 draining Free 18 3 draining Volcanic 60 10 parent material Grand mean 930 86 Loam 378 40 Calcarosol 192 12 –20 –10 0 10 20 30 40 50 60 Change in plant productivity % Source: Verheijen et al. 2010. Note: Figure shows percentage change in crop productivity upon application of biochar at different rates along with varying fertilizer coamendments to a range of different soils. Points show mean and bars show 95 percent confidence intervals. The numbers in the two columns on the right show number of total “replicates” upon which the statistical analysis is based (bold) and the number of “experimental treatments” that have been grouped for each analysis (italics). free-draining soils than in calcarosols (alkaline soils formed from calcium-rich sediments of variable texture), where the trend is rather negative (figure 3.1). The authors conclude that their results provide evidence to support the increase of plant productivity due to the liming effect of biochar. Biochar thus has the potential to reduce the need for conventional liming operations, cutting back the costs associated with this practice. However, the effects of biochar pH values vary. In basic soils, biochar applica- tion may be a hindrance: van Zwieten, Kimber, Morris, Chan et al. (2010) found that additions of a biochar with a pH of 9.4 to a basic soil with a pH of 7.7 decreased crop yields. In addition, the pH of the biochar itself will change over time in soils. The magnitude of this change in pH varies with type of feedstock used to produce the biochar, as well as the production conditions. It may increase for biochars that contain substantial amounts of base cations, or decrease for biochars made from woody species (Nguyen and Lehmann 2009). Nutrient Availability The impact of biochar on nutrients present in the soil and their bioavailability to plants is very important and can occur in many ways (see table 3.1 for a discus- sion of nitrogen as an example). Biochar is not considered a fertilizer per se but rather a soil conditioner that affects the retention and mobilization of existing nutrients for plant uptake. Biochar can help improve soil functions by reducing nutrient loss below the root zone, increasing the bioavailability of nutrients to plants over time (Shackley and Sohi 2010) and decreasing nutrient leaching Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 30 Opportunities and Risks of Biochar Systems Table 3.1  Possible Biochar Effects on Nitrogen Cycling Effect category Possible effects Implications for nitrogen References Biological and Biochar loses 50% or more of its Over the short term, microorganisms Clough et al. 2004; Lang, nutrient nitrogen (N) during pyrolysis and trying to decompose the high-C bio- Jensen, and Jensen cycling has relatively more carbon (C) char may immobilize (“tie up”) N that 2005; Novak et al. effects than N compared to other soil would have been available to plants 2010; Robertson and organic matter (a high C:N ratio) Groffman 2007; Ron- don et al. 2007 Different microorganisms are Certain microorganisms responsible for active at different pHs nitrous oxide (N2O) production are more abundant at lower pH Different microorganisms are Microbially driven nitrogen cycling is active at different oxygen affected by aeration—for example, contents, which are affected N2O is produced under anoxic, water- by how much water is filling logged conditions soil pore space Chemical Biochar may retain positively CEC could potentially retain nitrogen in Cheng et al. 2006; properties charged ions, depending on its the form of ammonium (NH4+)—more Cheng, Lehmann, and of biochar cation exchange capacity (CEC), developed in older biochars Engelhard 2008; Laird which may increase over time et al. 2010 Biochar is less likely to have anion Changes in nitrate (NO3+) retention are exchange capacity (AEC) negligible Chemical Biochar addition to soil may A neutral pH will increase N mineraliza- Chan and Xu 2009 changes in change pH tion and availability the soil Biochar addition to soil may add Some biochar-N will be present, but a nutrients directly large portion of it is lost during pro- duction and most of the N remaining in the biochar is unavailable to plants over short periods of time Physical Biochar may change porosity and If water movement through soil is DeLuca et al. 2006; Laird changes in water-holding capacity, alter- decreased, leaching of nitrogen, et al. 2010 the soil ing water dynamics particularly in the form of NO3+, could be reduced Increased adsorption of phenols in forest soils will increase nitrification Source: World Bank. (Dünisch et al. 2007; Laird et al. 2010; Lehmann et al. 2003; Novak et al. 2009; Steiner et al. 2007), likely due to the porosity and internal surface area of the biochar particles. However, the ability to improve nutrient availability may vary depending on the plant species. Woolf et al. (2010) reviewed available field and greenhouse data and found that cereals responded roughly three times more than leguminous species. Biochar’s ability to improve nutrient availability has the potential to reduce reliance on fertilizer and its associated environmental consequences (Verheijen et al. 2010). This is why biochar is of great interest to countries such as Australia that rely on a costly foreign fertilizer supply (CSIRO 2010). Similarly, the appli- cation of fertilizing agents jointly with biochar has been observed to increase the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 31 positive response to the biochar in various cases (Chan et al. 2007; van Zwieten, Kimber, Downie et al. 2010). One of the techniques in traditional Chinese agri- culture may have been the use of rice husk biochar mixed with “night soil” (Beagle 1978). Recent studies have also found that biochar can reduce nitrogen losses during composting of manure (Steiner et al. 2010). Fresh biochar can also contain nutrients that were present in the original feedstock. Any nutrient that does not volatilize during pyrolysis is conserved, ­ which is the case for most nutrients except nitrogen and sulfur (Lang, Jensen, and Jensen 2005; Shackley and Sohi 2010). When the biochar is applied to the same piece of land that produced the pyrolyzed feedstock, the nutrient cycle remains broadly balanced. Any geographic separation between biochar production (feedstock sourcing) and biochar application will likely create disruptions to the ­ local nutrient cycle and may jeopardize long-term fertility. Similarly, if biochar production uses feedstocks grown remotely from the land receiving the biochar, ­ there is a risk of depriving some areas of biomass and associated nutrients in order to enrich others. Closed-loop systems would avoid this problem. ­ otentially Intriguingly, using specific wastes, such as urban green wastes, could p establish a flow of nutrients from cities back to rural areas, particularly in regions progressively drained of their nutrients as they feed growing cities. Not only could this provide a closed-loop biochar system, it may help solve an important waste management challenge and provide new business opportunities. However, the quality of urban waste must be taken into consideration: biochar could con- centrate toxic elements (such as heavy metals), and land contamination is a risk if biochar is produced from waste of unknown composition. Soil Moisture Biochar can improve water infiltration and retention in soils through a combina- tion of direct and indirect mechanisms. The direct effect of biochar-induced water retention is related to its porous structure and large surface area. Plant-available water is better retained in soils with intermediate pores (0.2–20 ­ micrometers). Biochar itself holds greater amounts of plant-available water, and the changes to soil after biochar application also improve overall water-holding capacity (Sohi et al. 2010). Additional studies have shown that biochar can improve porosity, infiltration, and water efficiency in a number of soil types (for example, Kammann et al. 2011; Ayodele et al. 2009); however, for some types of soils, such as clay soils with a high water retention capacity, biochar is less benefi- cial or even a hindrance (Busscher et al. 2010; Martin and Moody 2001; Tryon 1948). It is thus important to characterize the porosity of different biochars over time and target their application. For example, field studies with biochar application to sandy soils with a low water-holding capacity have shown positive ­ results, as this is where improved water retention is most needed. The indirect, longer-term effects of biochar on soil moisture are also positive, though the processes remain much less understood. According to Glaser, Lehmann, and Zech (2002), terra preta that received biochar several thousand years ago retains 18 percent more water than adjacent soils with low biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 32 Opportunities and Risks of Biochar Systems contents. Studies have postulated that biochar may improve the ability to retain plant-available soil moisture and increase infiltration in the long term due to greater amounts of soil organic matter and increased aggregation resulting from microorganisms (Lehmann et al. 2011; Tisdall and Oades 1982). Soil Organic Matter Biochar cannot replace the portion of organic matter that supplies the soil biota with energy, and the impact of biochar application on the preexisting soil organic matter is thus fundamental. In tropical regions, where climatic conditions generally result in faster cycling of soil organic matter, the depth of organic ­ ­ carbon accrual found in terra preta sites has raised some expectations on the indirect role that biochar could play in generating and sustaining high levels of soil organic matter. Indeed, plant litter input to terra preta soil was stabilized to a greater extent than litter added to adjacent soils with low biochar contents (Liang et al. 2010). That said, studies have shown a short-lived “priming” effect: an increased min- eralization of existing soil organic matter and disappearance of litter, likely due to direct impacts of biochar application, such as pH changes and nutrient addi- tions (Hamer et al. 2004; Wardle, Nilsson, and Zackrisson 2008). However, greater stabilization of soil organic matter was observed in the long term (Kuzyakov et al. 2009; Zimmerman, Gao, and Ahn 2011). In a two-year field study, Major et al. (2010) found that long-term increases in plant growth likely played a greater role in improving stocks of soil organic matter than direct soil changes. As with moisture-rich clay soils and high-pH basic soils, evidence indicates that biochar added to peat or soils with very high concentrations of ­ organic matter is less likely to increase soil fertility and may even reduce it (Kimetu et al. 2008). Amount of Biochar Applied Plant response to biochar also varies with the amount of biochar applied. Another recent meta-analysis of 19 published field and greenhouse trials (Crane- Droesch et al. 2010) found that plant biomass increased on average by 3.8 per- cent ± 2.4 percent per tonne of biochar applied per hectare at moderate applica- tion rates. For example, according to this study 10 tonnes of char per hectare would increase plant biomass by 38 percent on average. With optimum condi- tions (which remain to be fully characterized, but an example might be drought- susceptible sandy acidic soils paired with a basic biochar), yield increases may be even higher. A positive correlation between increasing levels of biochar addition and plant response may only persist up to a certain point (Kammann et al. 2011; Lehmann and Rondon 2006; Rondon et al. 2007). At higher application rates, the effect on yield may decrease, and may in some cases become negative (Crane-Droesch et al. 2010; Rondon et al. 2007). The specific biophysical optimum for each ­­ soil– crop system remains to be determined. It may vary from a few tonnes per hectare for certain situations, to much larger quantities in other circumstances. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 33 The economic optimum, however, may lie significantly below the biophysical optimum, considering costs of biochar applications and expected revenues from ­ gains in crop yield. Important agronomic benefits have been observed even with rates of biochar application that are obtainable by subsistence farmers. Lehmann and Rondon (2006) noted improvements in productivity from 20 percent to 220 percent at application rates of 0.4 to 8 tonnes of carbon per hectare on degraded soils in Kenya. Kimetu et al. (2008) report a doubling of maize yields after applying 8 tonnes of biochar per hectare in the central Amazon, and Steiner et al. (2007) found similar increases for rice with 8 tonnes of biochar per hectare. This is ­ particularly interesting as smallholders in developing countries would be expected to produce relatively small quantities of biochar, either due to a lack of ­ unused biomass available locally or due to other constraints specific to smallholders. Typically, maize residues allow application of 0.5–2 tonnes of ­ biochar per hectare per season (using slow pyrolysis) when recognizing the need ­ for a 50 percent crop residue return to soils. Biochar production by smallholders using a pyrolysis cookstove would be limited according to their cooking needs. In practice, smallholders may never produce more than 1 tonne of biochar per year ­ per household (Whitman et al. 2011). In western Kenya, cooking with a pyrolysis stove generates approximately 0.5 tonnes of biochar per hectare per year (Torres et al. 2011). Toward Optimization of Biochar Use Poor design of biochar systems runs the same crop failure risk as other nonchemi- cal techniques that aim to improve agricultural productivity. In agroforestry, for instance, the wrong tree–crop combination may increase plant competition for light and water and lead to crop failure. However, unlike agroforestry, which now benefits from decades of on-farm research, biochar use is still hampered by a lack of experience and understanding of the enabling conditions for securing ­ predictable positive effects. Knowledge of optimized biochar–soil–crop combinations is incipient. The use of sound pilot tests before any full-scale, ­ on-the-ground implementation is therefore highly recommended for any biochar ­ activity. The fact that biochar, once incorporated, cannot be removed from the soil calls for a precautionary approach. More research is needed to explore the duration of biochar’s effect on soil properties and thus crop productivity. If the positive biochar effect on the soil is due to improved cation exchange capacity, increased soil organic carbon, or improved soil water-holding capacity, then the effects can be ­ expected to be long term. This has been demonstrated in terra preta soils (Liang et al. 2006). However, if the positive biochar effect is due to improve- ment in pH or acidity decline or nutrients added with the biochar, then the duration of these positive effects could potentially disappear before the bio- char decomposes. An ­ understanding of the soil constraint that the biochar addresses will help estimate the expected duration of the biochar’s positive effects (Lehmann 2009). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 34 Opportunities and Risks of Biochar Systems There is a relatively safe array of biochar applications where risks of crop fail- ure are limited. For example, drought-susceptible sandy or acidic soils seem to be particularly suited for the addition of biochar with basic pH and no harmful contaminants to increase crop yields. Evidence indicates that biochar application to clayey soils, high pH soils (Asai et al. 2009; van Zwieten, Kimber, Morris, Chan et al. 2010), peat, or soils with very high concentrations of organic matter (Kimetu et al. 2008) is less likely to increase soil fertility and may even reduce it. Given the uncertainties that remain around the interactions between biochar and preexisting soil organic matter, it may be useful initially to focus on soils that are poor in organic matter. The abundance of marginal or degraded soils in many parts of the tropics, in particular, means that biochar’s potential in agriculture could be large. Impacts on Climate Change Biochar is a multifaceted technology and its relevance to climate change mitiga- tion has probably caught as much attention as its potential for agronomic pur- poses. The biochar material itself is a carbon concentrate of the original biomass feedstock, and its stability in soil thus has implications for carbon sequestration. A number of important processes can enhance or reduce its climate change miti- gation potential at different stages of the biochar system, including, for instance, land use changes occurring before biochar application (sourcing of biomass for pyrolysis) and after (plant response). This section reviews the direct and indirect ways biochar prevents and sequesters GHG emissions, the potential risks and sources of leakage, and the importance of viewing the biochar systems from a life-cycle perspective. Finally, the potential for biochar to make a contribution to regional and global mitigation targets is discussed. Direct and Indirect Sources of Emission Reductions One of the largest differences between emission reductions from biochar and bioenergy is the former’s benefits when added to soil, such as greater plant growth and reduced soil emissions (Roberts et al. 2010; Woolf et al. 2010). Carbon storage and stabilization is probably the most direct and most important quality for climate change mitigation efforts based on biochar. Other relevant processes also come into play indirectly, including the generation of renewable energy, waste diversion, reduced fertilizer manufacturing, reduced soil emissions, and increased nonbiochar soil carbon. A summary of all sources of emission reductions from biochar is provided in table 3.2. Carbon Stabilization Biomass typically contains about 50 percent carbon, which is relatively quickly decomposed and reemitted to the atmosphere upon decay in soil. The mean resi- dence time of fresh biomass is in the range of months to years, with longer times for woody biomass and colder climates (Mungai and Motavalli 2006). Biochar retains between 10 percent and 70 percent (on average about 50 percent) of the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Table 3.2  Direct and Indirect Sources of Biochar Emission Reductions Relative importance for total Source Description Trade-off Dominant GHG GHG balancea Carbon Biochar decomposes more slowly than the biomass Potential energy production is lost due to Carbon dioxide (CO2) 50–65% (26–42% in cookstove stabilization from which it was produced, taking into account retention of biomass fuel as biochar. system) the initial carbon loss during pyrolysis. Renewable The energy produced during pyrolysis can be used to Minimal trade-offs exist if pyrolysis is an ef- CO2 (N2O and CH4 20–40% (56–72% in cookstove energy replace energy needs normally filled by fossil fuels ficient and appropriate energy source for the in inefficient system) or unsustainably harvested biomass. system. systems) Waste If the feedstock biomass would have decayed under No CH4 is captured for bioenergy through CH4, N2O 0–75% diversion low-oxygen conditions, such as in a landfill, then digestion. methane (CH4) and nitrous oxide (N2O) would be emitted, increasing the climate impact of the baseline scenario. Reduction in If biochar production reduces the need for fertilizers, If nitrogen immobilization occurs for a limited N2O Not quantified fertilizer the energy and emissions associated with their time after biochar additions due to miner- manufacturing production would be reduced. alization of the labile fraction of biochar, nitrogen fertilizer requirements may actually be increased. Reduction in soil Biochar application to soils may reduce net emis- Biochar applications to soil may increase emis- CH4, N2O 0–5% emissions sions of CH4 and N2O. These effects are currently sions of CH4 and N2O. If nitrogen immobiliza- poorly understood. If biochar reduces nitrogen tion occurs for a limited time after biochar fertilizer applications, this could directly reduce additions due to mineralization of the labile N2O emissions. fraction of biochar, additional nitrogen fertil- izer is needed. Increased non- Biochar application may increase plant growth and Biochar may initially increase mineralization of CO2 ~ 2% from increased soil organic BCb soil carbon the associated inputs to soil carbon through resi- soil carbon (the “priming effect”) through carbon inputs in cookstove dues and root growth. Biochar may also stabilize additions of nutrients or labile carbon, or pH system; carbon stabilization soil carbon, reducing decomposition. increases (transient phenomenon). not quantified Source: World Bank. a. Estimates of relative importance calculated with data from Gaunt and Cowie 2009; Hammond et al. 2011; Roberts et al. 2010; Woolf et al. 2010 (industrial systems); and Whitman et al. 2011 (cookstove system) b.  BC = black carbon. 35 36 Opportunities and Risks of Biochar Systems carbon present in the original biomass (Lehmann et al. 2003), and slows down the rate of carbon decomposition by one or two orders of magnitude, that is, in the scale of centuries or millennia (Cheng, Lehmann, and Engelhard 2008; Lehmann et al. 2008; Spokas 2010; Zimmerman 2010). The most important issue from a carbon point of view is the difference between the decomposition of the biochar and the decomposition of the original feedstock that would have happened in the absence of pyrolysis. The relative decomposition rate between biomass and bio- char is affected by in-soil decomposition rate, the biochar’s labile to recalcitrant ratio (see below), and the pyrolysis technique used to produce the biochar. Many factors determine the rate at which decomposition occurs, including chemistry of the biochar and biomass and the soil conditions. Biochar has rela- tively more bonds that are harder to break apart, such as carbon-carbon double bonds in interconnected aromatic ring structures of variable sizes (Keiluweit et al. 2010; Nguyen et al. 2010), making it slower to decompose than most other forms of organic matter. Decomposition can also occur at very different rates from one environment to the next. Organisms are more active and decompose more organic matter in ideal soil conditions (Cheng, Lehmann, and Engelhard 2008; Nguyen and Lehmann 2009; Nguyen et al. 2010). The presence of mineral matter in soil can also slow decomposition and enhance carbon stabilization (Glaser et al. 2000; Lehmann and Solomon 2010; von Lützow et al. 2006; Nguyen et al. 2008). All evidence from field and laboratory studies shows that biochar decomposi- tion is initially rapid over timescales of weeks and months, after which the rate of loss decreases (Brodowski 2004; Kuzyakov et al. 2009; Zimmerman 2010). This variation in decomposition times suggests the presence of a labile fraction in the biochar that degrades rapidly, distinct from the recalcitrant fraction that may take millennia to completely disappear.2 Therefore, the carbon sequestration Figure 3.2  General Concept of the Carbon Storage Potential of Biochar Based on 1 Tonne (t) of Dry Feedstock (Slow Pyrolysis) Carbon (degradable) Carbon (stable) 1 ton dry Fresh biochar Aged biochar biomass 0.3 ton 0.20 tC 0.5 tC 0.25 tC Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 37 potential of biochar may be determined by the relative sizes of the recalcitrant and labile fractions. Estimates of these fractions would be expected to vary from one biochar to the next, and would depend on a number of factors, such as initial feedstock, pyrolysis temperature, and pyrolysis duration. Only rudimentary guid- ance currently exists in the literature about biochar properties that predict recal- citrance. For example, one of the principal bottlenecks for the establishment of a sound biochar protocol for carbon markets is the so-called volatile matter of the oxygen to carbon (O:C) ratios (Spokas 2010; Zimmerman 2010) (see chapter 6 for further discussion). According to model-derived estimates, delivering carbon sequestration over the next few hundred years would require either the labile fraction of the biochar to be below 10 percent or the entire biochar to have a mean residence time3 of a thousand years or more (figure 3.2). In addition to the labile to recalcitrant ratio of the biochar, the pyrolysis sys- tem used to create the biochar also affects the relative rate of decomposition by impacting the amount of carbon captured in the biochar. Some biochar produc- tion techniques may capture less than 40 percent of original carbon due to equipment inefficiency (for example, during initial development stages of bio- char stoves), the type of feedstock used (for example, carbon retention through pyrolysis is greater with woody biomass than with manure), or the type of bio- char production technology (gasifiers favor a lower biochar to bioenergy produc- tion ratio compared to pyrolyzers; see table 2.1). Greater pyrolysis temperatures usually decrease the carbon captured in the biochar (Lehmann 2007), while also increasing the stability of biochars (Zimmerman 2010) and the proportion of stable biochar (Nguyen and Lehmann 2009). In theory, biochar produced through slow pyrolysis can store for the long term about 1 tonne of “stable” carbon for each 5 tonnes of dry feedstock. As shown in figure 3.2, the estimates used to reach this 1:5 ratio assumes the following: dry biomass is 50 percent carbon, 50 percent of the carbon is lost during biochar production through pyrolysis, and 80 percent of the remaining carbon is rela- tively recalcitrant. These numbers correspond to biochars produced through slow pyrolysis and would change if pyrolysis conditions change (Spokas 2010; Zimmerman 2010). Hydrothermal carbonization, for instance, can virtually sup- press carbon dioxide emissions during pyrolysis, but at the expense of a much less resistant biochar (half-life under 30 years according to Woolf et al. (2010); for example, see Steinbeiss, Gleixner, and Antonietti 2009). The understanding of biochar’s potential for carbon storage—particularly given the diversity of feed- stocks, environmental conditions, and pyrolysis techniques—is an area that requires further studies and research. Renewable Energy and Energy Efficiency In addition to carbon stabilization, biochar systems may also displace business- as-usual emissions to provide indirect sources of emission reductions. A certain amount of GHG emissions are produced during pyrolysis; however, this risk does not feature prominently in biochar literature, as it is assumed that the methane produced during pyrolysis will be combusted and used as a source of renewable Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 38 Opportunities and Risks of Biochar Systems energy (including the energy required to run the pyrolysis unit). Most biochar technologies are tailored for combustion of the syngas by-product of biochar production. Even very small-scale, highly disseminated technologies, such as bio- char stoves, can be efficient in using this syngas for heat energy. Less efficient pyrolysis technologies, such as biochar kilns that aim to maximize char produc- tion without combined valorization of the volatile energy released, should be carefully scrutinized in this respect. An important double climatic benefit occurs when not only the potential methane emissions are avoided, but the useful renewable energy is used to offset fossil fuel combustion. This is, however, contingent on both the “renewability” of the particular system design and biomass source, and having a surplus of energy after using what is needed for operating the pyrolysis unit. As the pyrolysis pro- cess is exothermic, surplus energy is usually available (Bridgwater 2007; Brown 2009), but it may be compromised by the use of wet feedstocks that require a portion of the energy to be used for drying. In certain circumstances, the energy produced through pyrolysis may not off- set fossil fuel use, but may reduce unsustainable wood harvesting. For instance, the introduction of efficient biochar cookstoves may replace less efficient meth- ods for cooking. However, nonpyrolytic improved combustion cookstoves are also much more efficient than traditional three-stone fires (Johnson et al. 2008; MacCarty et al. 2008), and benchmarking against the best available technology has not been done to a sufficient extent (Whitman et al. 2011). Fuel savings can also occur more indirectly when soil enriched with biochar reduces the need for cultivation and irrigation (for example, reducing fuel used for plowing), but this is extremely context dependent and challenging to quantify. Waste Diversion Biochar systems also avoid emissions in situations where biochar is produced from wastes that would normally decompose anaerobically, releasing methane and nitrous oxide in the process. However, it is important to consider what con- stitutes “true waste.” Typically, all biomass that is usually burned without any nutrient or energy capture or left to decay off farm (for example, sawdust, municipal green waste) with no other use can be considered a true waste. Reduction in Fertilizer Manufacturing The impact of biochar on nitrous oxide emissions is promising if biochar can indeed increase crop productivity through improved nitrogen use efficiency (Chan et al. 2007; Steiner et al. 2008; van Zwieten, Kimber, Morris, Chan et al. 2010) and help farmers cut back on the use of nitrogen fertilizers. However, it remains to be fully assessed how significant such an effect of biochar application might be as it depends on soil type, climate, local weather conditions, crop, and farmers’ preferences. Roberts et al. (2010) report that the nitrous oxide avoid- ance effect accounts for probably not more than 2–3 percent of the overall GHG abatement potential of biochar, under the conservative assumption that the dura- tion of biochar’s effect is only one year. If biochar’s effect on soil emissions is Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 39 longer than one year or even lasts for its entire lifetime, the role of nitrous oxide avoidance would become more substantial and potentially a major driver for the total life-cycle emission reductions of biochar systems. Reduction in Soil Emissions In addition to reducing the total need for nitrogen additions to soil, biochar may also affect the soil processes that lead to the production of nitrous oxide. For instance, a study by Taghizadeh-Toosi et al. (2011) found that biochar applica- tion allowed for a 70 percent reduction in nitrous oxide emissions from cattle urine patches over the course of the 86-day study period (further research is needed to understand the persistence of the emission reductions). Reductions in nitrous oxide emissions from soils after biochar additions observed by van Zwieten, Kimber, Morris, Downie et al. (2010) were suggested to be due to other changes in the soil that resulted in the release of nitrogen gas (N2) instead of the GHG nitrous oxide, such as improvement in aeration or a pH shift. This may explain why large reductions in nitrous oxide emissions were reported in some instances (Kammann et al. 2011; Taghizadeh-Toosi et al. 2011), while other stud- ies showed no effects or emissions that varied with time (Singh et al. 2010) or soil water content (Yanai, Toyota, and Okazaki 2007). Research on methane emissions from biochar-amended soils is progressing slower, but shows similar trends to nitrous oxide emissions (Haefele et al. 2011; Karhu et al. 2011). Increased Nonbiochar Soil Carbon Another important indirect GHG-related effect of biochar is related to plant response: the change in above- and below-ground biomass (and hence stored carbon) that results from the application of biochar. As discussed above, the potential for enhanced biomass growth only exists when biochar is able to address a plant growth constraint. Therefore, improved plant response will likely be more easily achieved in degraded soils, and soils with high sand content, low pH, and a large proportion of highly weathered minerals (iron and aluminum oxides and kaolinite). Also, biochar additions have been associated with signifi- cant reductions in disease occurrence in crops (Elad et al. 2010; Elmer and Pignatello 2011) and yield increases through stimulation of growth-promoting microorganisms (Graber et al. 2010) or plant hormones (Spokas, Baker, and Reicosky 2010). Both plants and a range of biological processes in soil respond to the introduc- tion of biochar, in turn increasing nonbiochar soil carbon stocks. Soil carbon stocks are highly significant: Batjes (1996) estimates that the first meter of depth of the world’s soils contains about 1,500 gigatonnes of carbon, which corre- sponds to about twice the amount of carbon present in the atmosphere (IPCC 2007). However, the interaction between biochar, nonbiochar soil organic car- bon, and decomposition is not well understood. As discussed previously, results from various studies suggest that adding biochar to soil reduces the decomposi- tion of nonbiochar soil organic matter in the long term (for example, Bruun, El-Zahery, and Jensen 2009; Kimetu and Lehmann 2010; Kuzyakov et al. 2009; Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 40 Opportunities and Risks of Biochar Systems Spokas et al. 2009; Zimmerman, Gao, and Ahn 2011). Some studies present interesting explanations for this effect. Novak et al. (2010) combined biochar with powdered switchgrass, which the authors conclude may have shifted the preference of soil microbes from “resident” soil carbon to newly added switch- grass carbon. However, others observe a short-lived “priming effect,” where pH, labile carbon, and nutrient additions cause a short-term increase in soil organic matter decomposition (Hamer et al. 2004; Wardle, Nilsson, and Zackrisson 2008; Zimmerman, Gao, and Ahn 2011). Potential Sources of Leakage and Risks to Emission Reduction From a strictly climate change mitigation perspective, the risks related to biochar lie primarily in the negative feedbacks that may occur directly or indirectly dur- ing biochar production and application. Emissions of methane and soot may occur during inefficient pyrolysis, and native soil organic matter may be degraded after biochar application on unsuitable soils. The risk of indirect land use change from increased pressures on biomass is also important and challenging to quan- tify. Issues of permanence also arise, particularly related to site erosion and fires. In theory, all of these risks may be avoided with appropriate standards and safeguards throughout the biochar production chain. Such standards are cur- rently lacking, but their progressive definition and possible implementation—in particular through carbon market protocols and certification schemes—could well rule out certain biochar systems. For example, the slash-and-char model (an alternative to slash-and-burn agriculture) raises some concern in terms of meth- ane emissions during pyrolysis in inefficient kilns. With traditional charcoal kilns used in Kenya and Brazil (Pennise et al. 2001), for instance, emissions of methane from slash-and-char are expected to surpass emissions from biomass burning by 1–6 grams per kilo of dry feedstock. The net GHG impact of the slash-and-char strategy may still be positive, but this risk has to be taken into consideration. Source of the Biomass Feedstock One important feedback effect is the risk of indirect land use change with bio- char production and application. Biochar is too small of an industry today to be causing substantial indirect land use change. However, it could become an issue in the future if biochar increases overall demand for biomass or changes the rela- tive economic value of certain crops that are particularly suited for biochar pro- duction. The risk of indirect land use change can be minimized as long as biochar producers use only “true wastes”—feedstocks that, if pyrolyzed, would not cancel out any positive ecological process (compared to the baseline scenario). Living biomass should only be used as feedstock if it is truly renewable, with no pres- sures on living biomass elsewhere. As Searchinger (2010) describes: Biofuels [or biochar] can only reduce greenhouse gases if the biomass results from “additional” carbon capture. Additional carbon means carbon that would otherwise be in the atmosphere if not incorporated in biomass used for fuel. The carbon must be captured either through additional plant growth or by saving biomass from being broken down through some other pathway. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 41 Under certain circumstances, the changes in land use induced by biochar can also be positive from a climate and ecological perspective. Biochar could be widely beneficial for ecosystem preservation if the gains in agricultural produc- tivity where biochar is applied reduce the need to expand cultivated areas. Again, this is an issue for which the presence or absence of agronomic benefits is crucial to the climate impact of biochar. Soot and Aerosol Production Although not taken into account in the Kyoto Protocol to the United Nations Framework Convention on Climate Change, soot is believed to be only second after carbon dioxide as a global warming factor (see, for example, the discussion in Molina et al. 2009). Unlike carbon dioxide, soot is very short lived in the atmosphere, but its warming effect can last much longer when it deposits on ice, which can lead to a dramatic change in albedo, causing rapid melting of ice sur- faces in the cryosphere—the snow-capped mountain ranges, brilliant glaciers, and vast permafrost regions. Biochar does not include soot, but because some bio- chars can easily fractionate into small dust particles, the question must be asked: Can char dust created during applications of biochar be lifted into the upper atmosphere, where it can be transported to fall out onto the cryosphere’s glaciers and icecaps? Aerosols of concern from biomass burning are typically of 2.5 micrometers or less (Brock et al. 2011). Particles larger than this can become airborne for short periods of time, but they tend to be deposited very close to the source. However, larger particles may be transported long distances under exceptional circum- stances, for example during dust storms, when particles can be lifted to high altitudes in conditions of extreme wind and dry soil. The critical question, then, is related to the size distribution of biochar particles. This would vary depending on the feedstock and production conditions used, but biochar dust particles are likely to be much larger than the combustion particles (that is, soot).4 Thus, bio- char particles, as compared to the smaller soot particles generated as a product of incomplete combustion, are not expected to be routinely transported beyond the local environment. Appropriate soil conservation tillage methods help to reduce risk of wind erosion during and after biochar application (Blackwell, Riethmuller, and Collins 2009). Such soil conservation practices should be fol- lowed wherever conditions favoring wind erosion exist, whether or not biochar is applied to soil. Indeed, if not properly incorporated into the soil, a fraction of the biochar could possibly become airborne and potentially turn into another climate prob- lem (see discussion above), but at minimum would reduce efficacy as a soil amendment and pose concerns over the health and safety of farm operators. However, a number of simple alternatives to tillage exist, such as humidification or mixing of biochar with manure before surface application or concentrated biochar application in planting holes. In addition, because biochar is so stable, systems could be envisaged where it is not applied every year, limiting the num- ber of times the soil would need to be tilled to incorporate it. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 42 Opportunities and Risks of Biochar Systems Methane and Nitrous Oxide Production A potentially more significant and immediate effect is avoided methane and nitrous oxide emissions in situations where biochar would divert wastes that would normally decompose anaerobically, releasing methane and nitrous oxide during this process. If pyrolysis can avoid methane and nitrous oxide emissions when the baseline is anaerobic decomposition, as in landfills, it can also increase such emissions compared to full combustion. Thus, the baseline scenario is criti- cal. For example, methane emissions from inefficient charcoal production are a well-known concern, and the Clean Development Mechanism of the Kyoto Protocol contains a specific methodology to curtail them (UNFCCC 2006). In the case of biochar production, this risk does not feature prominently in the lit- erature, as it is assumed that the methane produced during pyrolysis will be combusted and used as a source of renewable energy (including the energy required to run the pyrolysis unit). However, the question of unintended losses of methane and nitrous oxide during pyrolysis has to be quantified more rigorously and poses a significant research gap. Virtually no scientific studies have been published on this topic, and projects are only now being initiated to fill that knowledge gap. Permanence Thus, while microbial and abiotic decomposition of biochar to carbon dioxide will occur, the longevity of the carbon storage potential of biochar would cer- tainly suffice to address permanence-related considerations, as currently required by afforestation and reforestation projects generating carbon credits. There are studies that predict a half-life of less than a few hundred years (Spokas 2010), though some looked at chars formed under uncontrolled wildfire conditions that likely contained considerable amounts of instable material (Woolf et al. 2010). Moreover, short-term biochar loss in the field may not necessarily occur solely through decomposition, as a significant fraction may have simply been displaced by erosion or transported deeper into the ground by water leach- ing and soil fauna (Bird et al. 1999; Lehmann et al. 2008; Nguyen et al. 2008). Major et al. (2010), for instance, observed that 45 percent of applied biochar was eroded and only 2 percent decomposed after two years. However, other studies attest to the long-term stability of biochar, finding biochar remnants in soils that are hundreds to thousands of years old to show a chemical composition identical to fresh biochars (Lehmann et al. 2008; Liang et al. 2008). Studies of ancient charcoal deposits face tremendous methodological difficulties in distinguishing between char decomposition and disappearance from erosion, while studies of young chars have a limited time horizon and must resort to unreliable extrapola- tions from initial rates of decay and artificial ageing (Lehmann et al. 2009). Although biochar seems to have the potential for stable carbon storage com- pared to most other land-based climate change mitigation options, risks related to permanence deserve attention. In most cases, biochars can be produced in a way that microorganisms and abiotic processes will take centuries or millennia to decompose half of the carbon compounds of biochar incorporated in the soil. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 43 However, more research is needed to understand how these processes may acceler- ate under some specific circumstances. It is not well quantified whether oxidation of biochar carbon to carbon dioxide upon entry to river systems can pose a real risk to permanence, or whether decomposition decreases as indicated by enrich- ment of biochar-type compounds along transportation pathways from rivers to oceans (Golding, Smernik, and Birch 2004; Mitra et al. 2002). Erosion and deposi- tion within the landscape appears to decelerate carbon decomposition in general (Van Oost et al. 2007), but would need to be verified for biochar. In light of cur- rent uncertainties and concerned about the possibility of field monitoring of bio- char amendments, De Gryze, Cullen, and Durschinger (2010) proposed to limit biochar applications to nonsloping lands in order to reduce risks of lateral erosion and transport of biochar away from its point of application. Erosion is indeed pos- ing a great challenge for measurement, reporting, and verification of the climate impact of biochar projects, which is explored in more detail in chapter 6. Loss of biochar and of its carbon may also occur prematurely through fire, whether intentional or unintentional. Fire during storage and transportation is a common hazard and has to be managed using regulations that are already in place (Blackwell, Riethmuller, and Collins 2009). Unintentional loss of biochar through fire is likely to be very limited when biochar has been thoroughly incorporated in or mixed with soil. Verheijen et al. (2010) suggested that large concentrations of biochar in soils may also be prone to the risk of smoldering combustion, but high levels of application should be avoided anyway for other reasons in agricul- ture. Appropriate application rates for soil improvement of typically less than 1–2 percent by mass (20–40 tonnes per hectare if mixed in the topsoil) are unlikely to combust even in the event of a vegetation fire, but can be a risk if biochar is added on top of the litter layer in forests (Knicker 2007). A more important risk, probably, is related to intentional burning of the char as a source of energy. About half of the energy contained in the original feedstock is still present in the biochar. The line between charcoal and biochar only rests on its use, whether for energy or soil application. (The other difference is that charcoal is exclusively made from wood, whereas biochar can be made from any type of biomass.) This risk of intentional biochar combustion disappears once it is incorporated in soil, but appropriate incentives must be in place before this decision is made. Life-Cycle Analysis of Climate Impacts In addition to the carbon stored in the biochar itself, a number of important processes can enhance or reduce its climate change mitigation potential. These feedback effects need to be accounted for in order to assess the actual net ben- efits that specific biochar systems can deliver to mitigate climate change. In other words, there is a move from the narrow perspective of climate change mitigation through direct carbon storage, through biochar production and addition to soils, to a broader view of all the direct and indirect effects of biochar on the GHG balance. Assessing all the impact flows of a product or system is here done in a narrative manner, while chapter 5 will attempt to quantify (most of) these pro- cesses through life-cycle assessment methods. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 44 Opportunities and Risks of Biochar Systems Role of Life-Cycle Assessment The overall net climate impact of biochar can only be assessed through full life- cycle assessment (LCA) that takes into consideration the indirect effects listed above, as well as other secondary sources of GHG emissions (for example, trans- port, energy needed to start the pyrolysis). Some biochar GHG assessments and LCAs have been published (Gaunt and Cowie 2009; Gaunt and Lehmann 2008; Hammond et al. 2011; Roberts et al. 2010), but due to methodological con- straints and lack of data, none is comprehensive enough to include all aspects discussed above (for example, changes in albedo). They nonetheless tend to take into account, at least to a limited extend, all processes expected to be most important from a climate mitigation point of view (stable carbon in soil, indirect land use change, renewable energy generation, avoided methane and nitrous oxide emissions from landfill, reduion of black carbon (BC) settlement in the cryosphere, emissions from transport, construction of the pyrolysis equipment). However, two dimensions that are potentially quite significant tend to be not sufficiently covered: possible combustion emission as part of the pyrolysis (for example, soot) and potential gains in plant growth and agricultural productivity. Another feature of this first generation of biochar LCAs is that they all took biochar systems specific to temperate developed countries with large-scale pyrolysis units (Australia, the United Kingdom, and the United States). The LCAs presented in chapter 5 of this report intend to respond to the lack of LCAs on biochar systems specific to (tropical) developing countries, with a focus on smaller-scale pyrolysis units. With these caveats in mind, it is worth noting that the few LCAs published all indicate that the mitigation potential of biochar is greater than the mere recalcitrant carbon stored in the soil, except when negative land use change is involved. The lower-range estimates of most studies converge quite well toward a saving of 1 tonne of carbon dioxide equivalent (CO2e) per tonne of dry feed- stock converted into biochar (with no indirect land use change).5 A significantly higher degree of mitigation is possible when avoided methane emissions from biomass decay are accounted for (Gaunt and Cowie 2009). Roberts et al. (2010) explain that of this total GHG abatement potential, about 60 percent is attrib- utable to the stable carbon sequestered in the char (which is in line with the rule of thumb of 0.2 tonne of biochar carbon per tonne of dry feedstock explained in figure 3.2), and 30 percent to avoided fossil fuel consumption (using the renewable energy released through pyrolysis). Reduced nitrous oxide emissions from the soil after biochar amendment is however likely to be limited if the soil effect is short lived (2–4 percent of avoided GHG emissions, accord- ing to the same source). When there is indirect land use change associated with biochar production, however, the picture may look completely different. Roberts et al. (2010) calcu- lated that if biochar is made from purpose-grown switchgrass on U.S. cropland (expected to displace agricultural production elsewhere), the overall balance could be as high as 0.353 tonnes of CO2e emitted—not sequestered—per tonne of feedstock used for biochar. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 45 Figure 3.3  Impact of Biochar on Climate Change Mitigation Direct effects Indirect effects Net balance Pyrolysis emissions Soot emissions and albedo Land use change Transport ? Labile C Others Avoided N2O Plant response and yields Enhancement of SOM Avoided CH4 from compost Avoided energy use Stable C In biochar ? Photosynthesis Source: World Bank. Note: C = carbon; CH4 = methane; N2O = nitrous oxide; SOM = soil organic compound matter. As mentioned earlier, the net emission reductions from a biochar system are, under most assumptions, only superior to a full combustion of the biomass if there are soil benefits that yield additional emission reductions. These could arise from improved growth, reduced fertilizer requirements, or lower methane or nitrous oxide emissions from avoided landfill or from soils that received biochar. If no soil benefits are achieved, the emission reductions of a biochar system are likely not greater than those of a bioenergy system using combustion (Roberts et al. 2010; Woolf et al. 2010). Figure 3.3 summarizes the overall impact of biochar on climate change miti- gation (GHG emissions and other processes such as changes in albedo) as a combination of direct and indirect effects. This overall impact can be positive or negative, depending on the characteristics of specific biochar systems. Time Dimension The net climate impact of biochar also varies with time. LCAs are static snap- shots of a situation at a certain point in time, and unlike system dynamics model- ing, which uses systems of equations representing stocks and flows modeled dynamically over time, temporal dynamics are not included. However, a time- frame can be included that is specific to the product or system analyzed and that Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 46 Opportunities and Risks of Biochar Systems Figure 3.4  Alternative Scenarios for Biomass Carbon Dynamics Growing tree Carbon remaining (% of initial carbon stock) 120 100 80 60 40 Biochar 80% recalcitrant, MRT = 500 20 Recalcitrant fresh biomass (woody) 0 Labile fresh biomass (herbaceous) Time Source: Whitman, Scholz, and Lehmann 2010. Note: Each curve represents the fate of an equivalent mass of organic matter. MRT = mean residence time. represents the impacts at the end of that period. The selection of this timeframe will influence the net impact of the system. If a series of these calculations is done with different timeframes, the development of the emissions balance can be stud- ied over time (still, no feedbacks can be included in such a serial LCA). In the first months, or years, after pyrolysis, biochar does not compare well with alterna- tive scenarios in carbon terms. Indeed, pyrolysis releases instantaneously about 50 percent of the carbon contained in the original biomass, which would have taken longer to decay naturally (figure 3.4). If the baseline scenario is biomass burning or fast decay of labile biomass, biochar production quickly results in increased carbon storage, while for slowly decaying organic matter, biochar can pay back its carbon debt only after a period of time. It is generally agreed that land-based mitigation strategies with payback periods of more than 10 years (which is the case for various biofuel models) should be avoided (Woolf et al. 2010). In the longer term, another effect comes into play: the positive feedback that a biochar cycle can cause on the next, through increased plant growth and avail- ability of biomass residues for future pyrolysis. (This aspect has been well under- stood by proponents of the slash-and-char strategy.) The contribution of such a virtuous cycle to the overall mitigation potential of biochar is hard to quantify— and is once again very context specific—but should not be neglected. The system dynamics model developed by Whitman et al. (2011) to predict the effect of the introduction of a biochar-producing cookstove into a western Kenyan household Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 47 on the GHG impact of the system demonstrates one way to quantify this effect. In the model, based on field data, biochar application to soils increases maize yields, which, in turn, results in more crop residues available to be used as stove fuel, replacing unsustainably harvested fuelwood. However, this effect occurs gradually as the stove produces biochar over the years. The opposite effect may occur if biochar accrual in soil reaches levels that do not further improve produc- tivity or even reduce it; similar arguments can be made for nitrous oxide emis- sions from soil. At some point in time, more biochar accumulated in soil will not result in a linear increase in emission reductions. Without a time dimension to modeling efforts, it is very challenging to quantify such nonlinear effects. Potential Global Climate Change Impacts of Biochar at Scale The previous discussion assessed the net impact of turning 1 tonne of biomass into biochar and using it as a soil amendment. If biochar were brought to scale, what could be the size of its contribution to global mitigation targets? This dis- cussion does not allow determination of the scale at which biochar systems should be implemented, but rather provides guidance as to whether biochar has the potential to be a real contributor to climate change mitigation on a global scale. If biochar has the potential to be important globally, each project must still be assessed for sustainability and net climate impact on an individual basis, and how any wider-scale implementation would impact the global and regional social, biological, and economic systems discussed elsewhere in this report. Woolf et al. (2010) examined the theoretical (or “technical”) global mitigation potential of biochar within the boundaries of sustainability criteria. To avoid endangering food security and ensure habitat and soil conservation, the authors restricted their analysis to clearly identified waste feedstocks (for instance, paddy rice straw not used for animal feed) or biomass generated through limited land use changes that do not reduce agricultural production (for instance, transition from pasture to silvopasture). The availability of sustainable feedstocks is clearly identified as the limiting factor for a large-scale deployment of biochar, not the availability of suitable land (at least for the foreseeable future). According to their calculations, annual net emissions of carbon dioxide, meth- ane, and nitrous oxide can be reduced by a maximum of 1.8 gigatonnes of carbon per year, equivalent to 12 percent of current anthropogenic emissions (half of the avoided emissions are expected from the carbon sequestered in the char, 30 per- cent from replacement of fossil fuel energy by pyrolysis energy, and 20 percent from avoided emissions of methane and nitrous oxide). It is not possible to esti- mate at this point what a more realistic potential is, given all existing economic and social constraints, barriers in technology development, and competing uses in a future bioeconomy. The cited potential merely serves here as a justification for further inquiry about biochar’s utility on a project level. Many biochar proponents emphasize that biochar deserves particular atten- tion in a mix of strategies (or wedges; Pacala and Socolow 2004), as being one of only a few options that can actually withdraw carbon dioxide from the atmo- sphere. The overwhelming majority of mitigation technologies, including carbon Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 48 Opportunities and Risks of Biochar Systems capture and storage in the coal industry, propose to limit present and future emissions only, but cannot reduce the excess carbon dioxide in the atmosphere. As a threshold of cumulative emissions is likely to be reached beyond which no level of emissions can be considered safe, strategies that can actually absorb car- bon dioxide from the atmosphere will become more essential than others (Woolf et al. 2010). The only really available “technology” that at present captures car- bon dioxide from the atmosphere on a large scale is photosynthesis. Biochar can slow down the decay of this captured carbon dioxide in plants that would oth- erwise be fully returned to the atmosphere. Contrary to other land-based mitiga- tion strategies, such as reforestation, no tillage, or reducing emissions from defor- estation and forest degradation (REDD), which also have the advantage of drawing down atmospheric carbon dioxide, biochar does not face so strongly the issue of permanence; it is harder to reverse the effects of biochar systems com- pared to forestry systems, which are particularly prone to the risk of destruction through fire or diseases. In comparison to full combustion of biomass, however, biochar systems do face greater variability in a portion of their emission reduc- tions, because they accrue or have to persist over time (such as greater plant growth or lower GHG emissions from soil). On very long timescales of several hundred to thousands of years, the disadvantage of biochar lies in the very fact that biochar will eventually decompose, albeit more slowly than the biomass that it was produced from (see above). Social Impacts The Roundtable on Sustainable Biofuels fifth principle states, “In regions of pov- erty, biofuel operations shall contribute to the social and economic development of local, rural and indigenous people and communities” (RSB 2010). This guiding principle is also essential to the success of any biochar project. Because biochar systems can affect energy, health, economics, and food security, among other major issues, it is absolutely necessary that care be taken in their design, particu- larly in developing countries. Health and Labor Impacts The institution of biochar systems has potential positive impacts on the health of system users, particularly in the case of biochar-producing stove projects. However, there are also risks associated with such systems. These various health impacts will be investigated in the following subsections. They could occur throughout the production process, and include decreased fuel-gathering pres- sures, reductions in indoor air pollution, risks associated with handling of biochar and inappropriate conversion technology and operation, and the effects of improved crop yields. Increased Fuel Efficiency and Decreased Fuel-Gathering Burden Along with potentially decreasing indoor air pollution, decreased fuel demand has been an important driver for the development of improved cookstove proj- ects. While wood gathering for fuel may not be the primary reason for Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 49 deforestation in many at-risk areas (Defries et al. 2010), it may still be an impor- tant factor in some regions of Africa (Fisher 2010), and it is certain that the chal- lenge of gathering sufficient wood for cooking in a wood-constrained region is substantial. It is usually the women in developing countries who spend 4–14 hours per week collecting sufficient fuel for their household needs (WHO 2000). Decreasing the burden on women through cookstove improvements could be substantial. In the case of biochar-producing cookstoves, these improvements could come both from increased fuel efficiency, similar to improved combustion stoves (Johnson et al. 2008; MacCarty et al. 2008), and more importantly from expansion of potential fuel sources (Torres et al. 2011). The wider variety of feedstocks for pyrolysis and gasification stoves greatly enhances opportunities to satisfy on-farm fuel needs and reduces labor required to collect wood (Torres et al. 2011; Whitman et al. 2011). Together with the biochar production for soil improvement, the reduction in wood gathering may be an important driver for adoption. Equally important is the flexibility of biochar-producing stoves, not only in giving wider access to different types of fuel, but also in allowing the user to choose how to use the biochar. Depending on the stove design, biochar can be either further combusted in the stove for additional cooking energy or removed from the stove and saved. Once removed, the user can then have the options of returning the biochar to the stove to use as fuel, applying it to soil, or using the biochar for applications such as water filtration or sanitation. Research on energy efficiency and emissions of biochar-producing stoves is still in its infancy (Roth 2011; Torres et al. 2011). It is important to recognize that if decreasing absolute fuel use in addition to wood use is the ultimate goal, improved combustion cookstoves would be a better choice than biochar-produc- ing cookstoves. Because as much of the fuel biomass as possible is combusted for energy in improved combustion cookstoves, and biochar-producing cookstoves explicitly aim to retain some of the biomass in the form of biochar, it would be technically impossible for a biochar stove to gain as much energy from a given amount of biomass as an improved combustion cookstove could (Johnson et al. 2008). However, biochar cookstoves may be substantially more efficient than traditional cookstoves, and if the soil or climate benefits of biochar are valued, then the biochar-producing stove may be preferred over a combustion stove. Reduction of Indoor Air Pollution Every year, indoor air pollution causes nearly 2 million deaths (WHO 2011). Since improved cookstove projects began, one of the major impetuses for devel- oping and promoting improved cookstoves in developing countries has been their potential to reduce indoor air pollution (Hyman 1985; Raju 1954). While complete combustion of hydrocarbons will produce only carbon dioxide and water, when sufficient oxygen is not available, harmful products of incomplete combustion, including carbon monoxide and small respirable particulates, are produced. These compounds are associated with harmful effects, including pneu- monia and other acute lower respiratory infections, chronic obstructive pulmo- nary disease such as chronic bronchitis, and systemic effects as carbon monoxide Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 50 Opportunities and Risks of Biochar Systems limits the oxygen-carrying capacity of the blood (WHO 2011). The effects of products of incomplete combustion are exacerbated when cooking is carried out indoors, without adequate ventilation. These negative impacts affect women and children disproportionately. Women in many societies are responsible for the cooking, and spend between three and seven hours each day near the stove pre- paring food, often with their children close by. Because of this, most deaths attributable to indoor air pollution occur in females (WHO 2011). The development and introduction of cleaner-burning and more efficient cookstoves has been promoted for decades to address this problem, with vary- ing degrees of success (Barnes et al. 1993). Stoves have been shown to reduce the production of products of incomplete combustion both on a per unit of biomass burned basis and on a per unit cooking energy basis (Johnson et al. 2008; MacCarty et al. 2008; Roden et al. 2009). For example, MacCarty et al. (2008) found that the relative emission of products of incomplete combustion for an improved gasification stove (which would have similarities to a pyrolysis cookstove) in laboratory testing was about half that of the traditional three- stone cookstove. While air pollution concerns are greatest surrounding cook- stoves, it should also be noted that modern gasifiers and improved charcoal kilns that flare or recycle off-gases produce fewer emissions than traditional charcoal kilns (Brown 2009). While it is reasonable to expect that improved biochar systems have the potential to be cleaner than traditional methods, data compar- ing them to other improved cookstoves or kilns are currently lacking. Extensive emissions testing of biochar cookstoves is currently under way, and the contin- ued development of these stoves will naturally focus on reducing indoor air pollution in addition to reducing GHGs. For example, a recent World Bank report (On Thin Ice: How Cutting Pollution Can Slow Warming and Save Lives, 2013) shows that improved biomass (wood) and coal heating stoves could save about 230,000 fewer lives annually with the vast majority of these health ben- efits occurring in Organisation for Economic Co-operation and Development (OECD) countries. Of course, the positive effects of improved cookstoves will only be realized if the new technologies are adopted. Key elements suggested for successful stove adoption in various improved cookstove programs include educating women on the harmful effects of smoke and emissions, basing stove designs on traditional forms, targeting specific stove types to areas with different needs (for example, portable or not), and creating business opportunities for local stove makers and intermediaries (Aggarwal and Chandel 2004; Barnes et al. 1993; Hyman 1985). Potential Negative Health Impacts Due to Particulate Black Carbon and Toxins In the process of producing, storing, transporting, and applying biochar, there are several potential risks to human health. The primary areas of concern are black carbon emissions or charcoal dust, silicon dust, and toxins—particularly polycy- clic aromatic hydrocarbons, dioxins, and furans. No peer-reviewed data that investigate the risks of toxins and black carbon or charcoal dust for biochar sys- tems are available, but some reports provide insights. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 51 As described above, one of the major potential benefits of improved cook- stoves is the reduction of indoor air pollution from compounds such as carbon monoxide and respirable suspended particulate matter (Kanagawa and Nakata 2007). While this benefit could be realized during the cooking process, care would have to be taken to ensure that risks from handling the fine particulate matter of the biochar product are minimized. Small particles (less than 10 micrometers in diameter) are thought to be the most dangerous for human health, and studies often focus on particulate matter less than 2.5 micrometers in diameter (PM2.5), which is capable of penetrating deep into the lung, causing severe respiratory effects (WHO 2000). Similarly, charcoal dust is another potential area of concern where biochar is being produced in traditional ways or handled by workers. Workers who produce charcoal, process it into briquettes, or bag it for distribution are routinely exposed to charcoal dust, yet there is very little published literature on the impact of exposure to charcoal dust. The primary identified occupational hazard among workers in traditional charcoal industries is smoke inhalation (Kato et al. 2005). However, De Capitani et al. (2007) examined three cases of pneumoconiosis (black lung) in wood charcoal workers and found that highly exposed workers accumulated carbon dust in the lungs over long periods. The authors conclude that, “Despite the few cases published so far, pneumoconiosis due to wood char- coal might be an underestimated occupational risk, and early diagnosis and pre- vention must be addressed mostly in developing countries, where low industrial hygiene standards might expose workers to dust above threshold limits.” In sys- tems where biochar is being produced using traditional kiln technology, this risk should be monitored and appropriate health and safety precautions should be taken. Strategies would also need to be developed to ensure that practitioners are not exposed to particulate matter risks during biochar handling or application to soils. These strategies could include keeping it covered during storage and trans- port and wetting the biochar during its application to reduce dust formation. Methods for containing dust from charcoal that is being crushed for briquetting have been developed (Thomas 2008), and could be used by farmers needing to crush biochar prior to field application. The knowledge of health impacts from dust that contains silicon fibers is much stronger—silicosis is a serious health impact for workers in many industries that process materials containing silica, such as ceramics. Even dust from crop wastes high in silica, such as rice husks, can cause a silicosis-like syndrome in rice mill workers (Lim et al. 1984). Rice husk biochar also contains silica, and during pyrolysis or gasification silica could crystallize, increasing its threat to health. The transition of silica in rice husk from the amorphous form to the crystalline form generally takes place at temperatures above 850°C, and heating time is also a factor. More investigation is required, but pyrolysis and gasification below this temperature threshold may not be likely to produce much crystalline silica (Shinohara and Kohyama 2004). Polycyclic aromatic hydrocarbons (PAHs) are chemical compounds that are produced as by-products of fuel burning (whether fossil fuel or biomass). Some Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 52 Opportunities and Risks of Biochar Systems PAHs are carcinogenic to humans, but many are not. PAHs are found naturally in soils as a result of wildfire, and many microbes are able to metabolize them. PAHs have been identified in some biochars (Brown et al. 2006; Jones, Lopez Capel, and Manning 2008), but the conditions under which they form and how pyrolysis systems could be designed to prevent them remain to be clarified. Karve et al. (2011) analyzed PAH levels in several biochars, including carbonized rice husk produced by a number of rice husk gasifiers operating in Cambodia, and found one species of PAH that exceeded levels of concern. However, this may not be critical, given that (a) the biochar would be diluted in much greater volumes of soil, and (b) the PAHs in biochar may not be leachable or plant avail- able due to being strongly sorbed by the biochar. Dioxins are predominantly formed at temperatures above 1,000°C. Most pyrolysis technology operates well below that temperature. However, any pro- posed high-temperature pyrolysis or gasification technology should be assessed and monitored for possible dioxin production. A low-temperature pathway for dioxin also exists (the de novo pathway), which requires the presence of oxygen and chlorine. Because pyrolysis operates under no or low oxygen contents, this pathway is also unlikely in biochar systems, but feedstocks that contain signifi- cant amounts of chlorine or metals are more prone to dioxin production (Garcia- Perez 2008) and need to be scrutinized. Increased Labor under Slash-and-Char Systems The practice of converting swidden, “slash-and-burn” agricultural systems to “slash-and-char” systems has been suggested as a means of improving soil fertility and reducing carbon loss from the system (Lehmann et al. 2002). The case study described by Lehmann and Waddington (Lehmann and Joseph 2009) involves wood being hauled from the cleared area to be charred in buried or improved kilns before the remaining small biomass is burned. The biochar could then be sold as charcoal fuel, or returned to the soil, where even a small, 2–3 percent increase in yield of high-value pineapple and annatto could offset biochar pro- duction costs in one year (Lehmann and Joseph 2009). However, this process could require substantially more labor, with an estimated 10.5 person-days per hectare for gathering the woody material, 6.8 person-days for building the kilns, and 2.8 person-days to return the woody material to the soil. This increased labor, for people who already work very hard, may not be an acceptable change unless the payback is substantial. Nutrition Effects from Improved Crop Yields Soil degradation is strongly linked to human nutrition and health (Lal 2009) and farmers and pastoralists of Asia and Africa make up nearly two thirds of the world’s hungry (Borlaug 2007). If biochar improves crop yields or crop resilience (as discussed in section “Impacts on Soil Health and Agricultural Productivity” above), the institution of biochar systems could help buffer practitioners against hunger. Whether or not the application of biochar to soils results in an alteration of the nutrient content of crops, an increase or maintenance of yields under Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 53 environmental stresses such as climate change could be critical for smallholder farmers, for example those in Sub-Saharan Africa, where yields of staple crops are projected to decline by between 5 percent and 22 percent by 2050 as a result of climate change (Ringler 2010). As discussed above, targeting biochar to soils and agricultural management systems may—if appropriately applied—help ensure that these benefits are realized. Access to Energy through Biomass Energy Implications of Biochar Substantial portions of the world currently rely on inadequate energy supplies and energy forms for even basic household needs such as lighting, heating, and cooking. In 2001, the World Bank reported that 1.6 billion people used no mod- ern fuels (coal, kerosene, electricity, natural gas, or liquefied petroleum gas), and that populations in developing countries consumed 5 percent of the modern energy that those in developing countries consumed per capita (Energy and Mining Sector Board 2001). The introduction of a biochar system to a region would be expected to create changes in the accessibility of biomass and energy. This is critical, because energy consumption is strongly correlated with national income as well as human development (Energy and Mining Sector Board 2001). For small-scale biochar cookstove projects, this improved access to energy could yield the many positive improvements related to health impacts described above, while for larger-scale biochar energy projects, the provision of energy could sup- ply lighting after sunset (extending the workday or time during which children can concentrate on schoolwork), power machines to increase productivity, and provide energy for critical functions such as the refrigeration of vaccines or water pumping. More broadly, the ability to generate income through nonagricultural activities such as microbusinesses is limited by energy, among other factors (Kaygusuz 2011). While all these energy services are valuable, for a given project it would be important to consider which kinds of services should be targeted and which groups would benefit from those services. The prioritization of energy services would be expected to differ from region to region, and should be determined in consultation with the community or groups involved. Barriers to Success in Biochar Energy Projects A case study of the implementation of a gasifier system fueled by fast-growing tree biomass (with parallels to a midscale pyrolysis unit) in Vanuatu found that it ran successfully for several years, providing electricity to a school (Woods, Hemstock, and Burnyeat 2006). Its ultimate failure was due to a lack of technical support and barriers imposed by external agencies rather than local social or environmental factors, suggesting that the development of a long-term strategy for supporting new energy systems may be critical for ensuring their success. In the same report, the authors noted that highlighting the fact that local energy needs can be met locally would help promote “ownership” of biomass energy strategies on a local to regional basis. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 54 Opportunities and Risks of Biochar Systems While the issues surrounding alternative uses of biomass are investigated in section “Competing Uses of Biomass” below, these dynamics would be expected to influence certain groups of people in different ways, with the potential for systematic marginalization of vulnerable groups. Furthermore, when biomass is being used to produce bioenergy for essentially an unlimited demand (as opposed to demand for energy for a relatively fixed use, such as daily cooking needs), the likelihood of unsustainable biomass use or negative social impacts is increased. A report from the International Institute for Environment and Development (Nhantumbo and Salomão 2010) examined biofuel projects in Mozambique as a case study for understanding the impacts of biofuels on the livelihoods of the rural poor. The study found that inadequate planning and failure to implement existing regulatory policies has resulted in conflicts between different resource uses and users. Indeed, some interviewees cited comparatively lax regulatory standards in Mozambique as a reason for the greater rate of biofuel project devel- opment there compared to South Africa. This observation highlights the need for international standards and their enforcement. Community consultations have been found to be inadequate to protect the rights of communities, and the prom- ised positive social impacts of projects have been provided on an ad hoc basis, without clear timelines for their implementation. If biochar projects are designed explicitly in the context of community development, rather than economic investments, then this could be a strong step toward avoiding similar issues. Kaygusuz (2011) stresses the importance of the gender dynamics of energy production and access. Due to differences in access and control over land and productive assets, the risks of biofuels are expected to affect men and women differently (FAO 2008). Women tend to be those responsible for spending long hours or travelling long distances to gather biomass for fuel. Also, women are often responsible for producing food crops in many areas. While altering these activities through a biochar energy strategy could alleviate pressures on women and also provide them with new energy resources, the changing dynamics of biomass or an increase in land clearing for large-scale biofuel production could also disproportionately impact these women (Kaygusuz 2011). That said, house- hold- and community-scale bioenergy projects likely have the potential to improve energy services for basic needs and generate income in rural developing regions while alleviating health and labor burdens, particularly if a participatory approach is used when developing and implementing projects and if gender- differentiated impacts are considered in their design (Kaygusuz 2011). Benefit-Sharing Issues Arising with the Potential Development of Biochar through Carbon Credit Schemes The nascent economic topic of potential carbon credits for biochar systems is covered in chapter 6, but there is certainly a social aspect to carbon crediting as well, which is briefly addressed here. Two issues arise: the general principle of using carbon credits generated in regions of the world with the fewest per capita GHG emissions in order to offset the emissions of industrialized countries; and the ques- tion of who benefits ultimately financially from the generation of carbon credits. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 55 The only way the first issue can be justified—also from a climate mitigation perspective—is if the activity is “additional” and social and economic develop- ment are at the core of the project, so that carbon credits are applied in order to enable access to these positive benefits (Whitman, Scholz, and Lehmann 2010). In consideration of the entire value chain of a biochar system, where there are a number of different actors throughout the process chain, determining who should receive payments for the carbon credits can become complex. As outlined in table 3.2, reductions in emissions can occur at many points, and their value may be influenced by other parts of the process. For example, the biochar pro- ducer is responsible for stabilizing the feedstock biomass as biochar as well as for the initial emissions during pyrolysis. For the producer’s efforts to result in net carbon reductions, the farmer responsible for applying biochar to soils must fol- low the expected procedure (that is, protocol or method) and ensure that the biochar is not burned for energy or applied to inappropriate soils, resulting in net GHG emissions. Thus, it is essential that the project be conceived in its entirety, with the agreement of all participants as to what any carbon financing will be applied to, and ensuring that carbon credits are not double counted. Although the aforementioned complexity of a biochar system might seem challenging, there is—particularly from a social perspective—an inclusiveness factor involved in operating a successful biochar operation particularly at the scale of smallhold- ers. While larger systems might incorporate and combine several process steps for which then only one project entity is responsible, a smallholder setting would suggest that different process steps might be carried out by different actors which will ultimately only be eligible to receive carbon credits if the biochar system in its totality functions as one. As a result, increased cooperation and inclusiveness might be observable along the value chain of a well-operating biochar system. However, it is still too early to fully assess these social effects, given the nascent nature of biochar systems per se. Competing Uses of Biomass The availability of biomass is a key part of what defines the potential scope of biochar projects. Precisely which categories of biomass could be most appropri- ate for a biochar system are highly location and system specific. Many different types of biomass can be used in pyrolysis systems to produce biochar, and dif- ferent fuel types would be optimal in different systems. Pyrolysis systems that operate at different scales require different amounts and, thus, sources of bio- mass. Furthermore, even if the biomass is suitable for pyrolysis, it may not be available or affordable. There is often an opportunity cost attached to the use of a specific biomass source for pyrolysis. Biomass management is a particularly sensitive issue for those developing countries with widespread degraded soils and limited biomass resources. There are many factors that limit how much biomass should be considered “available” (table 3.3), all of which must be taken into account for successful biochar projects. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 56 Opportunities and Risks of Biochar Systems Table 3.3  Potential Biomass Use and Limitations Potential Limitations considered Theoretical Biological production Geographic Existing land area Technical Land required for food, housing, infrastructure, and natural areas Economic Profitability Implementation Social and policy constraints Sustainable Food security, habitat conservation, and soil preservation Sources: Offerman et al. 2011; Woolf et al. 2010. Here, some common uses of biomass that may compete with biochar produc- tion are investigated. Competing uses for a potential feedstock can be predicted to some extent by the broad category the biomass type falls into. This discussion of biomass sources follows the framework applied by Offerman et al. (2011), which distinguishes between energy crops and residues. Energy crops are pur- pose-grown plants for bioenergy production while residues are divided into three categories: harvest residues, such as straw, leaves, or tree thinning residues; pro- cess residues, such as bagasse, manure, or mill wastes; and wastes, such as rotten food products, waste wood, invasive species, or municipal solid waste. None of these categories is exempt from competing uses. Purpose-Grown Energy Crops The use of energy crops for biochar production would be expected to face all the same issues as is the case in other bioenergy or biofuel projects with respect to growing dedicated biomass. Briefly, these include the diversion of food crops for fuel, diversion of arable land from food crops (Pimentel et al. 2009), direct and indirect land use change (Lapola et al. 2010), and whether or not energy crops could truly be constrained to degraded or marginal lands (that is, land unsuitable for food crops) (FAO 2008). These issues have been investigated at varying degrees of depth, but all could potentially act as competing uses for biomass feedstocks. Furthermore, while it is feasible that some biomass types could be appropriate for making biochar but not for other standard bioenergy uses, it is likely that there could be competition from other biomass energy systems besides biochar production. The issues surrounding this category of feedstock are highly complex, making it particularly challenging to prevent negative externalities. Biomass Residues Composting or Soil Application Any time soil is deprived of biomass that would have otherwise decayed in situ and hence protected and enriched the soil, there is the potential for loss of nutri- ents. Dead biomass that remains on soils, whether it is forestry slash, maize resi- dues, or leaf litter, protects the soils from erosion and will eventually decompose, putting at least parts of the carbon and nutrients back into the soils (Lal and Pimentel 2007). If these functions are valued, care must be taken not to Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 57 excessively remove biomass, and for some easily degradable soils, any biomass removal would put the soil at risk. Using harvest residues for bioenergy produc- tion is a clear example of this process—where biomass would have been returned to the soil, it is now being diverted. However, in the case of a biochar system, if the biochar is returned to the soil from which the residues came, many of the mineral nutrients could be returned (with the important exclusion of much of the nitrogen and sulfur—see section “Impacts on Soil Health and Agricultural Productivity” above), and soil carbon stocks could be enhanced (although it is important to differentiate the form and function of biochar carbon in soil from non-BC soil carbon). However, important functions of leaf litter mulches for ero- sion protection may not be delivered by biochar incorporation to soil. This requires scrutiny and may significantly limit or even exclude the use of crop resi- dues in certain regions at risk from soil erosion. The use of process residues and waste residues, which may normally be sent to the landfill, may not result in losses to soils, but each scenario would need to be evaluated independently to determine what the standard or baseline practice is. For example, Offerman et al. (2011) designate manure as a process residue, which in a concentrated animal feeding operation may be too abundant locally to apply safely to soils without risk of eutrophication (Bradford et al. 2008), but on a small Ethiopian farm is an important agricultural resource (Duguma, Darnhofer, and Hager 2009). In addition, the choice to apply biomass for one use over another does not have to be permanent, but could vary over time. For example, biochar could be produced from biomass that is normally used as com- post once every decade if that would optimize soil nutrient management and fertility. An important question here, as elsewhere, is what the baseline scenario is. For example, if the baseline is application of fresh biomass with a high C:N ratio (such as wood), it may tie up nitrogen during decomposition, making the nutrients unavailable, while turning it into biochar would make the carbon less available to microbes, reducing this effect (Torres 2011). Animal Fodder Competition for biomass to be used for animal fodder instead of biofuel systems runs in parallel to those associated with human food–fuel trade-offs, where land or crops previously used for animal feed are diverted for bioenergy production. Particularly important for harvest and some process residues, it is relevant in both developed- and developing-country contexts. For example, in a concentrated animal feeding operation in Iowa, United States, maize plants previously used for silage production for cow feed might be diverted for or made more expensive due to their demand for bioenergy production. In the small Kenyan households studied by Torres et al. (2011), 25 percent of maize residues were reported to be used for animal feed or building materials, leaving 75 percent potentially avail- able for pyrolysis in a biochar-producing cookstove, for which the need for soil protection has to be considered (Whitman et al. 2011). Whereas the Iowan farmer might turn to the grain markets for alternatives, the Kenyan smallholder may be more constrained. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 58 Opportunities and Risks of Biochar Systems “True Waste” Despite the fact that biomass is a resource in many scenarios, in some instances it could be considered “true waste” (Whitman, Scholz, and Lehmann 2010). While from a soil nutrient perspective composting municipal green waste would be better than using it for bioenergy, from a climate change standpoint the oppo- site may be true, and in many situations it is simply landfilled, providing neither climate nor soil nutrition benefits (Lundie and Peters 2005). If the default or business as usual scenario for biomass use would simply be rotting in a landfill without contributing to soil nutrient enhancement or being used as animal fod- der and if this true waste could be economically diverted and used for bioenergy production, it could be an attractive option as feedstock for a biochar system. Indeed, in such scenarios the cost of this feedstock might be zero, or even nega- tive in cases where the feedstock provider would have otherwise been paying a tipping fee to dispose of it. However, one challenge associated with using munici- pal wastes for biochar production is often its high moisture content. Roberts et al. (2010), for example, found that yard waste required the most energy for dry- ing before the pyrolysis process compared to corn stover and switchgrass feedstocks. Another model of true waste could include biomass that could be used to produce biochar while providing its original function. For example, if traditional swidden agricultural practices could be adapted to use charring instead of out- right burning of biomass to clear lands for agriculture (Lehmann and Joseph 2009), then some of the advantages of biochar production and its application to soils could be gained while the original use of the biomass is not compromised. However, the success of such a system would depend on social, economic, and environmental factors specific to each farming system. The use of true wastes for biochar production could minimize unwanted land use impact and leakage (Whitman, Scholz, and Lehmann 2010). However, the concept of true waste is system defined, as one person’s rotting food is another’s compost, for example. While the same outcomes of burning—to clear land for hunting or cultivation—may be achieved through a slash-and-char system, other important ecological functions may not be, such as the stimula- tion of plant growth or germination through fire (Bond and Keeley 2005). In biomass-constrained developing regions, very little biomass can be considered “waste.” However, if its alternative use is inefficient burning in a cookstove, then using an improved cookstove that also produces biochar could provide a viable alternative use (Torres et al. 2011). Conversely, as discussed above in section “Impacts on Soil Health and Agricultural Productivity”, many biological wastes that are indeed true wastes would also be unsuitable for biochar pro- duction and application to soil. Any contamination that is not destroyed through the pyrolysis process, such as heavy metal pollution, would remain in the biochar and could have harmful effects. Thus, it is critical that the value of a true waste does not overshadow the risks of contaminated waste products when selecting a feedstock. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Opportunities and Risks of Biochar Systems 59 Alternative Bioenergy Production Whether the biomass in question is an energy crop or any sort of residue, another bioenergy system could compete with biochar production for its use. The critical questions in these scenarios might include what form of energy is being produced and how it serves the community’s needs; and if it is serving the same function (as with improved cookstoves replacing three-stone fireplaces), which process is more efficient or best meets other criteria such as indoor air pollution. For example, the analysis conducted by Woolf et al. (2010) to predict maximum global sustainable potential biochar production notes that the extent of their biochar scenarios is incompatible with a simultaneous nonbiochar biomass energy strategy. They propose a mixed approach whereby each system is applied where it would produce the optimal outcome. For example, the effect of biochar on soil fertility and the carbon intensity of the energy it is replacing are key for achieving a beneficial climate outcome, so in regions with fertile soils and where coal combustion would be replaced with bioenergy, nonbiochar strategies may be preferred. Similarly, Whitman et al. (2011) find that an improved combustion cookstove may be preferred over a biochar cookstove in scenarios where fuel use is very high and fuel gathering is more unsustainable. Risk Assessment Biomass and even what are considered biomass residues are often important components of elements such as building materials, fuel, livestock feed, direct soil amendments, and soil protection. Regions or locations where biomass sources can be identified where such alternative uses are minimal or unimportant will likely be better suited for biochar interventions. It is expected that biochar will best complement locations characterized by high biomass availability coupled with compromised agricultural yields and soils. In such locations, biochar would be more likely to demonstrate its value quickly enough to be of interest to the people, improving adoption rates. It is essential that any biochar production does not rely on biomass that previously supplied other critical uses. It is important to be aware that these uses may not appear to have high economic value but can in fact be providing essential services. The concept of true wastes is a useful principle for the development of bio- char projects, but should be carefully applied to very specific categories of bio- mass residues. Key indicators of a true waste biomass may include a net cost for its management, its ultimate fate being combustion without energy capture or decomposition in peri-urban or industrial landfills without contributing to soil nutrients, soil protection, and soil carbon. Its use should not endanger food secu- rity, natural habitats, or soil health (Woolf et al. 2010). Human appropriation of the world’s net biomass production is in the vicinity of one quarter of total biomass produced (Erb et al. 2009). The optimal use of a given amount of biomass is always going to be defined by value judgments. Different weighting of the importance of soil health, nutrient cycling, energy production, climate change impacts, economic value, and many other factors will Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 60 Opportunities and Risks of Biochar Systems almost inevitably result in different recommendations for its ideal use. Because there is no unbiased “optimal” use for a given biomass supply, transparency in the value judgments that underlie any biomass use decisions is of the essence. Notes 1. Chan and Xu (2009) reviewed a large number of biochars from a variety of feedstocks and found a mean pH value of 8.2. 2. “Labile” carbon is less resistant to weathering and can readily be broken down and released as carbon dioxide into the atmosphere. “Recalcitrant” carbon—which gener- ally constitutes a much larger proportion of total carbon content of biochar than labile carbon—is much more resistant to degradation. 3. The mean residence time is the average time that biochar carbon remains in the soil before being completely broken down. 4. C.A. Masiello, personal communication. 5. Lower-range estimates (in tCO2e per tonne feedstock) are 0.86 for Roberts et al. (2010) with late stover in the United States, 1.3 for Gaunt and Cowie (2009), and slightly above 1 for Hammond et al. (2011) with barley straw in the United Kingdom. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 4 Survey and Typology of Biochar Systems Survey The use of biochar is a relatively new technique in modern agriculture, building on a body of research that is mostly less than a decade old. Dedicated institutional capacity to research and develop biochar applications is only now beginning to emerge. A survey was undertaken to obtain an overview of the status of biochar projects globally, particularly in developing countries. The survey had four pur- poses: (a) to provide a snapshot of the types of biochar projects that currently exist in developing countries; (b) to gather information about constraints and opportunities in these biochar systems; (c) to develop a typology based on the survey results; and (d) to select a few projects to study the life-cycle greenhouse gas (GHG) emission reductions. The survey was conducted by using the existing electronic network of the International Biochar Initiative (IBI). With 3,500 news- letter subscribers from 113 countries, IBI has become the nexus of a fast-growing multidisciplinary network of people interested in biochar, five years after its cre- ation at a side meeting held at the 18th World Congress of Soil Science, Philadelphia, United States, 2006. In order to cast the widest possible net, the request was also posted at various online discussion forums for biochar and for cookstoves (recently, biochar-mak- ing cookstoves have become a topic of interest to cookstove developers). In response, IBI received 154 completed surveys from 41 countries (figure 4.1). The majority of the projects identified themselves as still in the beginning stage. Only 39 projects were self-identified as mature or having measurable results. Of these, 12 projects were identified as potentially having enough results and sufficient data quality for a life-cycle assessment (LCA). These projects were contacted in January 2011 and were sent a follow-up questionnaire to collect additional project data. An additional survey was drafted and invitations were sent to those who responded to the initial survey in order to learn more about various social and cultural barriers to biochar adoption. This survey had 48 responses to questions about barriers, existing indigenous biochar use, how projects cope with limited supplies of biochar, and project reliance on carbon financing. The results of this Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   61 62 Survey and Typology of Biochar Systems Figure 4.1  Distribution of Project Locations India Indonesia China Ghana Thailand Mexico Kenya Vietnam Nigeria South africa Philippines Mongolia Malaysia Egypt, Arab Rep. Sri lanka Nepal Congo, Dem. Rep. Costa rica Brazil Zambia Pakistan Lao PDR Cambodia Burkina faso Uzbekistan Tanzania Swaziland Senegal Nicaragua Madagascar Guyana Ecuador El salvador Colombia Chile Cameroon Belize Bangladesh 0 5 10 15 20 25 Number of biochar projects Source: World Bank. Note: While the primary aim of the survey was to shed light on biochar projects in developing countries, a number of responses were received from developed-country projects and are included in this figure and in the data analysis below. second survey are discussed in chapter 6. Results of both the initial surveys are presented in appendix A. Classification of Biochar Systems Typology Design As biochar systems move from the drawing board to implementation, concepts are tested and systems either advance toward adoption or are abandoned. Even in the process of setting up pilot projects, ideas that may have seemed feasible Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey and Typology of Biochar Systems 63 initially are often modified as the realities at a particular location become clearer. The survey of the IBI network is, necessarily, a snapshot in time of a rapidly grow- ing and changing field of endeavor. Even so, some clear trends can already be perceived in the types of systems that are being proposed and implemented, particularly in developing countries. This section discusses those trends and constructs a preliminary typology of systems using the survey data. This typology ­ is based on production technology, energy use, feedstock choice, and project scale, as outlined in the following subsections. Production Technology There are many possible ways to classify biochar systems. One important consid- eration is the type of biochar production technology that is used. Most biochar production technologies represent a significant capital investment and once the technology choice is made, it may be difficult to change later. Figure 4.2 shows the distribution of different production technologies that survey respondents reported. The choice of technology is closely tied to the available feedstocks— most feedstocks perform best in the particular technologies most suited to han- dle their characteristics, whether those are chemical composition, size and shape, or degree of moisture. However, it is also the case that many of the production technologies are flexible enough to handle a variety of feedstock types. Many of the biochar survey respondents (32 percent) make biochar in tradi- tional charcoal pits or mounds that are known to be both polluting and ineffi- cient. However, this is often a way to initiate testing biochar in their soils using Figure 4.2  Biochar Production Technologies Cookstove top lit updraft fasifier Other, (TLUD),18 29 Cookstove Anila, or annualar retort design, 1 Traditional pit, mound, or Bath brick kiln, Retort kiln, 32 41 Gasifier, including Continuous TLUD unites not kiln, 11 used as cook stoves, 10 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 64 Survey and Typology of Biochar Systems existing technology to see if there is enough benefit to justify investing in cleaner, more efficient biochar-producing technology. In some cases, there is no active technology choice because the biochar projects are utilizing charcoal fines from existing fuel charcoal production. If charcoal is being produced currently for fuel, there are strong reasons to deploy cleaner, more efficient technologies such as batch retort kilns (41 percent) and continuous kilns (11 percent), no matter what the end use of the charcoal is. Several different kinds of biochar-making stoves exist, and new ones are being developed, with two major types being represented in this survey. The top-lit updraft (TLUD) gasifier is the most common stove design represented here (18 percent of total), while the Anila-style stove uses an annular retort design, and is further described in chapter 5. Another relatively prevalent technology (10 percent) is the gasifier (not used as a cookstove). Most gasifiers are designed to gasify all the biomass carbon, including most of the char. Gasifiers that generate electricity and that also pro- duce significant amounts of biochar are usually rice husk gasifiers. Rice husk gasifiers currently produce biochar only as a by-product, but the volume of this carbonized rice husk can be quite large because the high silica content of the rice husk inhibits gasification of the char. An inherent inefficiency in the gasification process thus becomes a benefit for those seeking a source of biochar. Energy Use Technology choices are also influenced by the energy recovery that is desired. Only 51% of the projects surveyed indicated that they were or would be captur- ing useful energy released during biochar production. Of these, cooking was the largest single energy use (figure 4.3). Heat energy is the easiest kind of energy to recover from a pyrolytic gasifier, but the small size of cookstoves limits the amount of biochar produced. Several projects indicated in comments that they were including both biochar-making cookstoves and a larger batch or continuous kiln dedicated to biochar production in order to produce adequate supplies of biochar for their specific applications. While a large number of projects were interested in using recovered heat for drying crops or produce, relatively few projects set their sights on generating electricity. There were two basic approaches to generating electricity used in the surveyed projects: generators driven by internal combustion engines running on gas supplied by a thermal biomass gasifier, and solid-state thermoelectric genera- tors attached to stoves operating on heat conducted through the metal stove body. Thermoelectric generators are low-output devices that are fairly costly. They are suitable for tasks such as cell phone charging and running LED lights. Large biomass gasifiers are capable of generating several to hundreds of kilowatts of electrical power. Feedstock Choice Another important criterion in classifying biochar systems is feedstock use. For example, some stoves can use unconsolidated crop wastes such as straw, but the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey and Typology of Biochar Systems 65 Figure 4.3  Utilization of Biochar Production Energy Oil collection Electricity and refining, 3 generation thermo Other, 16 electric generator, 12 Electricity generation internal combustion engine, 12 Cooking household, 39 Space heating, 15 Cooking Food, fuel or institutional, 9 crop drying, 28 Cooking commercial, 7 Source: World Bank. Figure 4.4  Word Cloud Showing Biochar Feedstocks Most Frequently Cited by Survey Respondents Source: World Bank. most common design, the TLUD stove, requires either small feedstocks, such as nut shells or seeds, or small briquettes or pellets that can be made from a variety of crop wastes or weeds. The survey used an open-ended question format to col- lect information about feedstocks. This returned a wide range of results that was very useful for the purpose of sampling the spectrum of potential feedstocks, but Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 66 Survey and Typology of Biochar Systems was rather difficult to classify. Figure 4.4 displays a visual impression of the vari- ety of feedstocks used and the frequency of references to them (word size rep- resents frequency of use). Project Scale The project scale determines key factors, including the community that will be influenced by the project, the area of potential available feedstocks, and the types of energy that may be useful. The survey asked respondents to answer the ques- tion, “What is the scale of the biochar production system?” choosing from a scale that ranged from household to regional. While it was expected that the answers would roughly correspond to the size of the actual pyrolysis technology, there may be some discrepancies, such as a far-reaching cookstove project. As f ­ igure 4.5 shows, the majority of biochar production systems were identified as small, tend- ing toward household- and farm-scale systems. Typology Construction To construct a typology of biochar systems based on the survey response data, each project was categorized based on energy recovery type, scale, feedstock type, and production technology. For the scale categories, village and cooperative scales were combined to simplify the presentation. Because many different feedstocks were used, six categories were designated. Feedstocks such as field stover, nut hulls, empty palm fruit bunch, and bagasse were all grouped into the category of crop residues. Because there were a large number of references to rice crop Figure 4.5  Scale of Biochar Production Systems Regional, 14 Household / Cooperative, 16 family, 37 Village, 17 Farm, 59 Source: World Bank. Note: Due to the nature of the survey, the breakdown above should not be considered representative of all biochar projects. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey and Typology of Biochar Systems 67 residues (mostly rice husk), rice residues was kept as a separate category. Wood resi- dues include sawmill residues, fuelwood, urban greenwaste, and plantation thin- ning and prunings. The manure category is mostly composed of dried dung. Weeds are invasive species, both herbaceous and woody, with water hyacinth and Prosopis juliflora being the primary examples. Slash and char refer to projects that are attempting to slow down cycles of slash-and-burn agriculture by returning char rather than just ash to newly cleared fields in the hope that they will retain pro- ductivity for longer. The other category includes several projects that were using charcoal fines from an existing charcoal production process (for fuel), as well as all of those projects that declined to state what feedstocks they were using. After categorizing all the projects, they were plotted to make the bubble chart in figure 4.6, where the size of the bubble indicates the number of projects for each feedstock type at a given combination of energy type and scale. Total bubble size is not additive—bubbles lie on top of each other. The differently shaded bubbles represent different feedstocks, and these are plotted with energy on the y-axis and scale on the x-axis. The first aspect to note from figure 4.6 is that cooking energy predominates at the household scale, as would be expected. Also, most of the projects Figure 4.6  Typology of Biochar Systems by Type of Energy Recovery and Scale Showing Number of Projects with Each Type of Feedstock (n = 154) This circle size indicates n = 2 projects Oil Electricity Energy Heat Cooking None Household Farm Cooperative/ Regional village Scale Crop residue, Rice crop Manure Slash and char wood, weeds residues Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 68 Survey and Typology of Biochar Systems generating electricity are at the larger scales. The farm scale is the most likely to be producing biochar without any energy capture, indicating that the system may be driven primarily by the agronomic benefits of biochar. As the complexity of the form of energy increases (toward oil and electricity), the number of projects decreases. Crop residues, wood residues, and weeds were used under similar conditions (figures A.11 and A.12 in appendix A), so they were grouped together in figure 4.6, and join rice residues to be the predominant feedstocks. Rice residues, how- ever, were primarily used at the farm or cooperative/village scale, rather than household or regional scales. The slash-and-char systems surveyed had no energy recovery and were concentrated at the farm or cooperative/village scale. These trends are summarized in figure 4.7. These typology charts reflect all of the 154 project survey responses. Keeping in mind that more than 40 percent of the projects identified themselves as phase 1 projects (assembling concepts, partners, and funding), a table of system typolo- gies was constructed, grouping projects hierarchically based on the most com- mon types and the level of similarity between projects (table 4.1). The relative importance of each category was determined using the dendrogram in figure A.13 in appendix A, which demonstrates that the most influential grouping cat- egory is scale, followed by energy use, and feedstock. The common production technologies used for each of these is also listed, although they are, of course, closely tied to the energy use in many cases. The work of developing biochar system typologies is in the early stages and will evolve as biochar projects advance. Once the available feedstock opportuni- ties are identified, biochar production technologies should be assessed and devel- oped that are suitable to the scale and energy needs of the farmers and project participants. In addition, consideration will need to be given to all of the other social, ecological, and economic components of the agricultural and energy sys- tems in which biochar may play a role. Figure 4.7  Summary of Dominant Biochar Typologies Energy Cooking None Electricity Household Regional Slash and char Rice waste Crop residues, wood waste, and weeds Feedstock Source: World Bank. Note: Arrow designates scale, from household, to farm, to cooperative/village, to regional, while areas above the arrow designate prevalence of energy uses and areas below the arrow designate prevalence of feedstock uses. Energy uses and feedstocks without strong trends are not indicated on this figure; areas are giving only a relative approximation of importance. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey and Typology of Biochar Systems 69 Table 4.1  Biochar System Typology Systems Energy use Feedstock Production ­technologiesa Category Household Cooking All sources cookstove, TLUD; ­cookstove, Ia Anila or annular retort design; batch retort kiln; traditional kiln None All sources batch retort kiln; traditional Ib kiln Heat Crop/wood/weed cookstove, TLUD; batch Ic retort kiln Electricity Wood batch retort kiln Id Farm None All sources but ­manure; traditional kiln; batch retort IIb slash and char kiln Heat All sources except traditional kiln IIc for rice residues Electricity Crop/wood/rice gasifier; batch retort kiln IId Oil Crop/wood commercial pyrolysis pilot IIe plant Cooperative/ Cooking Crop/wood/weed/rice gasifier; traditional kiln; IIIa village batch retort kiln None All sources; slash batch retort kiln; IIIb and char ­continuous kiln Heat Crop/wood/weed/rice continuous kiln; batch IIIc retort kiln; traditional kiln Electricity Rice/weeds gasifier IIId Oil Crop gasifier IIIe Regional None Crop/wood continuous kiln IVb Heat Crop/wood/manure/ gasifier; continuous IVc weeds kiln; batch retort kiln; ­traditional kiln Electricity Crop/wood/manure continuous kiln; batch IVd retort kiln Source: World Bank. Note: The most prevalent categories of energy use at a given scale, as seen in figure 4.6 and figures A.11–A.13 (appendix A), are shown in bold, while the categories in which a given feedstock is concentrated are shown by italicizing the feed- stock. Categories are I for household, II for farm, III for cooperative/village, and IV for regional scale biochar system. The letter (a) categorizes energy as being used for cooking, (b) no energy use, (c) the off heat is being used, (d) the biochar system produces electricity, (e) the system produces bio-oil. a. Note on terminology: TLUD = top-lit updraft gasifier; “traditional” kilns were described in the survey as “traditional pit, mound or brick kiln.” Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 5 Life-Cycle Assessment of Existing Biochar Systems Life-Cycle Assessment: Definition and Methodology Life-cycle assessment (LCA) is a methodology to evaluate the environmental flows associated with a product, process, or activity throughout its full life by quantifying energy and resources used and emissions created. The life cycle of a product “from cradle to grave” includes four principal phases: materials extrac- tion and processing, product manufacture, product use, and product disposal or The LCA methodology used in this study has been standardized by “end of life.”   the International Organization for Standardization according to the 14040 series (ISO 1997). Because of its whole systems approach and transparent methodo­ logy, LCA is an appropriate analysis for estimating the global warming impacts of biochar systems. In addition to its rigor as an environmental impact assessment tool, economic costs can be included in an LCA, making it a versatile method for analyzing the profitability of a given system. In order to avoid unintended consequences it is necessary to conduct analyses of potential life-cycle impacts of biochar systems. It would be undesirable to have the system actually emit more greenhouse gases (GHGs) than are sequestered or consume more energy than is generated. Analyses such as LCA provide not only insightful information as to the potential impacts of biochar systems, but also a framework for considering the production chain of feedstocks and transparency in defining system boundaries for the assessment. In addition, an LCA can also be used as a tool to identify data gaps and key processes or effects within the life cycle that have the greatest impact on the results. This information can be used to direct future research and system improvements. The four main elements to the LCA methodology are (a) a goal and scope definition; (b) the inventory analy- sis; (c) the impact assessment; and (d) the interpretation, as described in box 5.1. The contribution analysis calculates the relative impact of different life-cycle stages (for example feedstock production, transportation, pyrolysis) to identify those stages with the most impact, and to identify opportunities to reduce GHG emissions and costs of the system. The sensitivity analysis determines how the results may be affected by uncertainty or variability in the data and between systems. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/XX.XXXX/978-0-8213-9525-7   71 72 Life-Cycle Assessment of Existing Biochar Systems Box 5.1  Elements of a Life-Cycle Assessment Goal and scope definition • Clearly defining the breadth of the study, the system cutoffs, and the system boundaries Inventory analysis (life-cycle inventory) • Researching and collecting the process data with all of the input and output flows of the system • Developing the life-cycle inventory model Impact assessment • Analyzing the environmental consequences of the flows of the inventory analysis Interpretation • Contribution analysis • Sensitivity analysis • Data quality assessment • Recommendations for pollution prevention and resource conservation. Goal and Scope The purpose of the LCA case studies is to conduct cradle-to-grave analyses of the GHG and economic inputs and outputs of biochar systems in developing countries. System Boundaries The system boundaries are best defined and illustrated in a process flow diagram for each case study. Determining the system boundaries in LCAs is important for defining allocation procedures. Allocation issues arise when a multioutput process is defined in terms of one product. The question arises how to separate or desig- nate the impacts of only one of those products. The ISO guidelines state that whenever possible allocation should be avoided by (a) increasing the level of detail of the model; or (b) using the system expansion method. Although increasing the level of detail is preferred, it is not always possible because of data limitations. System expansion and allocation by partitioning are methods for handling the allocation problem. System expansion means that the system boundaries include all processes affected by changes in the studied system. System expansion includes the avoided processes as part of the life cycle of the product, that is, the avoided processes are subtracted from the model. Allocation by partitioning is done when the impacts are divided among the coproducts, based on weight, energy content, economic value, or similar (Baumann and Tillman 2004). The case studies utilize both methods as deemed necessary and are described in each study separately. Impact Categories The impact categories for this assessment are the global warming impact (total GHG emissions and reductions) and the net economic impact (total costs and revenues). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 73 Input/Output Data Requirements The cutoff criteria for the input and output data have been set as follows: if any given input or output is less than 5 percent of the energy or mass of the feedstock per functional unit, these data are not included if they are not available. If data are available, they are included regardless. Any inputs or outputs that are not included are noted in the process descriptions. Data Quality Assessment The data quality requirements are those outlined in the ISO 14040 standards and Ansems and Ligthart 2002, in addition to the methodology developed by the University of Washington’s Design for Environment Laboratory. The data quality assessment utilizes a scoring method based on time, geographic, and technology coverage parameters, and precision, completeness, representativeness, consisten- cy, and reproducibility considerations. Each process is assigned a data quality score for each indicator on a scale of 1 to 5, with 1 being the best. The assignment of a score to each category is based on the capability of the dataset to meet spe- cific requirements. The average of the scores was calculated for each process. The results from the data quality assessment can be found in appendix B. Life-Cycle Inventory Detailed descriptions of the subprocesses and their input/output data are includ- ed under each case study, using an adapted version of the biochar energy, green- house gases, and economic (BEGGE) model (Roberts et al. 2010).1 Impact Assessment The common 100-year global warming potentials of carbon dioxide, methane, and nitrous oxide (1, 25, and 298 CO2e, respectively) from Intergovernmental Panel on Climate Change (IPCC) 2007 were used to calculate the climate change impacts of each process. The net climate change impact is the sum of the net GHG reductions and the net GHG emissions. To be consistent with termi- nology, the “net GHG reductions” are the sum of the “CO2e sequestered” and the “avoided CO2e emissions.” The carbon sequestration is a direct result of the sta- ble carbon in the biochar, while the avoided emissions are from the avoided processes such as traditional cooking and crop residue burning. The biogenic carbon dioxide is fully accounted for in the analysis in the following manner: the carbon uptake during feedstock growth is included for sustainable feedstock harvest but not for unsustainable feedstock, and the carbon emissions during thermal conversion and the carbon sequestration in the biochar. None of the case studies include improvements to the soil structure, or direct impacts on BC set- tlement in the cryosphere due to lack of data. These differences or absence of specific soil improvements could further impact GHG emissions, some of which are explored in the sensitivity analyses for each case study. The costs and revenues of the biochar systems are dependent on the nature and organization of each biochar project. All monetary costs are included as Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 74 Life-Cycle Assessment of Existing Biochar Systems appropriate (for example cookstove, transportation) as compared to current practices. The changes in time or labor (collecting feedstock, applying biochar) of the biochar system compared to the traditional system are monetized where possible, and when not possible they are tracked separately from the economic costs and revenues and then monetized as part of the discussion. Carbon offset credits are currently not received by any of the case study projects, thus are only included in the analysis as a discussion item. Case Studies Criteria for Selection The initial survey of the International Biochar Initiative (IBI) network (a global network of biochar practitioners that includes academic researchers, commercial interests, farmers and gardeners, government representatives, and nongovern- mental organization project developers) to identify biochar projects in develop- ing countries yielded preliminary data on roughly 150 different projects in 41 countries, as described in chapter 4. About half of these projects are still in the planning stage. Therefore, the initial selection filter was to identify projects that were actually being implemented on the ground and likely to have reportable results on at least some of the key parameters examined in the LCA (for example feedstock characteristics, crop yield, energy use). Looking for only the most com- plete project datasets, the selection was narrowed down to 25 projects. From that group the top three projects were selected using a more complete set of criteria, which are described further below (in no order of priority): 1. Degree of integration into local economy. A project having connections to the local economy is more representative than a research project conducted by academics only. Although several academic research projects had good crop yield data, they lacked any integration into the surrounding real-life econom- ic setting, meaning they had few or no data about labor and other inputs and how these projects would actually function and operate in the “real world.” However, some academic research projects are working directly with farmers and in many ways these are useful cases because they tend to have high- quality data. 2. Variation in biochar production technology and scale. The case study selec- tion was oriented toward smallholders and cooperatives rather than industrial scale. The first selected Kenya project is a cookstove project, so the selection process focused on small batch kilns and medium-scale pyrolyzers or gasifiers as alternative biochar production methods. 3. Data availability and quality. None of the projects submitted had an entirely complete dataset for the LCA that included, for instance, multiyear crop yield data measured scientifically against a control. In every case, at least some pa- rameters are considered primarily via a sensitivity analysis. 4. Replicability in a broad range of contexts. The projects were screened for replicability to ensure that those analyzed in the LCA would provide poten- Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 75 tially wide-ranging insights if the models showed that they were successful in reducing GHG emissions or increasing agricultural production, flexibility, and climate resilience. Variables that guided the selection process included the availability of waste material as feedstock, soil conditions suitable for biochar application, and biochar production technology that could be economically fabricated and used in different, predominantly rural settings. 5. Impact on GHG reduction (climate change mitigation effect). Admittedly, prior to the LCA it was not entirely certain whether or not a project would have a positive climate change mitigation effect. However, key input param- eters such as feedstock uses and transportation were considered to eliminate any obviously unsustainable projects. 6. Geographic location. The goal of the study was also to look for a variety of project locations in low-income developing countries where the need is great- est for climate-smart farming practices that improve rural livelihoods while mitigating and adapting to climate change. Project Descriptions Ultimately, three projects in different geographic locations—Kenya, Vietnam, and Senegal—were selected for the LCA based on the above criteria. The Kenya case study is based on a household-scale pyrolysis cookstove that produces bio- char in addition to providing heat for cooking for subsistence farmers. The Vietnam case study represents biochar produced as a by-product of small-scale rice wafer production from rice husk feedstock, and the biochar is purchased by local peanut farmers. The Senegal case study looks at a larger-scale continuous process pyrolysis unit that produces biochar and is used by local onion farmers. In-depth descriptions of each case study are provided below. Kenya Case Study Life-Cycle Assessment System Overview The project in Kenya is conducted by Cornell University, under Professor Johannes Lehmann of the Department of Crop and Soil Sciences. Improved pyrolysis cookstoves are being tested in subsistence farming households in the western part of Kenya, where biochar and heat energy for cooking are coproducts of utilizing these stoves. The biochar stove under consideration uses primary (woody) and secondary (herbaceous) feedstocks for operation. Crop residues from the farm that are not otherwise used (for animal feed or other household needs) can be used as the secondary feedstock as well, thus decreasing primary fuelwood consumption and deforestation pressures. The case study assumes the biochar is applied to maize fields on the farm. However, the biochar could also be applied to vegetable gardens, but the agronomic trials (and thus data avail- ability) have focused on maize crops to date. The biochar trials were begun in 2005, and the pyrolysis cookstove testing began in 2008. The project involves approximately 60 farms in the region. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 76 Life-Cycle Assessment of Existing Biochar Systems Currently, the pyrolysis cookstove in this project is in the prototype stage and has not been optimized yet. The pyrolysis cookstove has been brought to house- holds for testing for a week at a time, but families have not had extended use of the stove so far. An improved design of the pyrolysis cookstove is in develop- ment. The biochar produced using the cookstove is not currently applied to the family’s crop fields, but rather is used for testing. The crop yield data are from farms in the same region, which are sometimes the same households as the ones for the biomass assessment and cookstove measurements. However, the biochar in the field trials was produced not through cookstoves, but in a kiln from woody biomass feedstock (more detail in “Biochar Effect on Maize Yield” subsection below), and applied at a rate of 18 tonnes of carbon per hectare, or 27 tonnes of biochar per hectare. The goal of the project is for each household to have an improved pyrolysis cookstove and apply the biochar to their own fields at an application rate that is high enough to see agronomic returns (actual biochar application rates might well turn out to be much lower than the 18 tonnes of carbon per hectare used in the field trials to date). Methodology Function, Functional Unit, and Reference Flows Biochar production is a multioutput system with up to four coproducts for the Kenya cookstove system: biomass management, soil amendment, carbon sequestration, and bioenergy production. The outputs of the pyrolysis process are dependent on the needs of the producer, and the relative amounts of the final products can be altered by feedstock selection and processing conditions. The functional unit of the pyrolysis cookstove system is 1 tonne of dry crop residues, used as secondary feedstock for a household pyrolysis cookstove on a farm in Kenya. Results are also presented with alternative functional units (such as the yearly cooking energy for one year per household, and 1 tonne of biochar), taking into consideration the cookstove technology and biochar pro- duction limitations, as well as the biomass availability limitations on the farm, as the quantity of biochar produced is in fact limited by the cookstove and the biomass. System Boundaries A flow diagram of the biochar system is illustrated in figure 5.1. The system is organized into four modules (bold outlined boxes): feedstock, cookstove, biochar, and crop response. Under each module a summary of subprocesses is listed. Scenarios Throughout the analysis, the so-called “baseline” scenario is the most reasonable pyrolysis cookstove scenario, which is not to be confused with a “business as usual” scenario. The business as usual scenario is the current traditional practice (cooking with a three-stone fire), and is actually included in the baseline scenario by subtracting out these avoided traditional practices in the LCA model (see detailed process descriptions in the following “Life-cycle Inventory” section). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 77 Figure 5.1 Schematic Flow Diagram for Biochar Production in a Pyrolysis Cookstove System On-farm On-farm Off-farm crop residue wood wood SOC Crop residue Wood depletion collection collection Soil application Cookstove Recalcitrant C Crop residue production air-drying Wood air-drying Maize yield Labile C Feedstock Cookstove Biochar Crop response Avoided Avoided soil nitrous SOC traditional cooking oxide emissions accumulation Duration of Avoided wood collection biochar’s effect Overall system boundary Process module Subprocess including monetary or labor inputs Subprocess within module Subprocess included only in the sensitivity analysis Source: World Bank. Note: SOC = soil organic compound. The pyrolysis cookstove for this case study is a rocket-style Anila stove ­ (figure 5.2), which utilizes primary and secondary feedstocks. The Anila stove operates with a rocket design, where the primary feedstock (woody biomass) is inserted through an opening on the lower part of the stove and is combusted in the center chamber of the stove. The outer ring of the stove is the pyrolysis chamber, which utilizes the secondary feedstock and can accept herbaceous bio- mass such as crop residues. The outer chamber is a low-oxygen environment, and the gases driven off the secondary feedstock flow out of holes to the primary chamber where they are combusted, thus adding to the cooking energy of the primary fuel. In comparison, a traditional three-stone set-up is an open fire using woody biomass as the only feedstock, where usually three stones or bricks are set around the fire and the cooking pot is set on top of the stones. Because the crop residue feedstock is not purposefully grown, the production of the feedstock is considered a by-product and therefore no environmental bur- dens are associated with its generation (except for those impacts that would not otherwise occur in conventional management). The feedstock is collected, air- dried, and chopped to fit the cookstove as necessary for specific feedstock types. The fuelwood for primary combustion in the pyrolysis cookstove is included in this module. The amount of primary fuelwood required for the pyrolysis cook- stove is less than for a traditional cookstove. Thus, the difference in primary fuelwood collection is accounted for as an avoided process in the feedstock mod- ule. Without a pyrolysis cookstove, these same crop residues would be left to decompose in the field (those not collected for animal feed or other household uses that are considered not available for cooking). Under the cookstove module, the production and transportation of the cook- stove are accounted for. During the cookstove operation, slow pyrolysis, cooking Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 78 Life-Cycle Assessment of Existing Biochar Systems Figure 5.2  Pyrolysis Cookstove in Kenya Case Study a b Fine biomass Cooking pot/Heat exchanger material to produce biochar Secondary air Heat loss Transfer of heat from from flames walls Steam from Dry drying zone biomass Torrefaction Torrified Pyrolysis with formation wood of syngas tars Syngas with some Biochar cracking of tars Wood and primary air through door Sources: 5.2a. Prototype pyrolysis cookstove in use in Kenya (image courtesy of D. Torres, 2010). 5.2b. Schematic diagram of the rocket-style Anila pyrolysis cookstove (image courtesy of S. Joseph, International Biochar Initiative). energy, and air emissions are included. The avoided emissions associated with a traditional cookstove are part of this module. The biochar is transported and applied to soils by hand. The behavior of biochar in soils is described by the sta- bility of the carbon in the biochar, where the recalcitrant and labile carbon frac- tions are included in the biochar module. The crop response upon biochar appli- cation is compared to yields for control crops. The effect of biochar on soil nitrous oxide emissions is a subprocess illustrated in the flow diagram that is not in the baseline scenario but is included in the sensitivity analysis. The system expansion method is used for modeling avoided biomass fuel collection, avoided biomass management, and avoided traditional cookstove cooking. Life-Cycle Inventory Feedstock Torres et al. (2011) conducted a detailed biomass assessment of farm households in the study region. In this work the total biomass was estimated for 50 house- holds. The available feedstock for pyrolysis was calculated by subtracting the biomass required for other household and farming needs, such as animal fodder and building materials, from the total biomass. Thus, in this LCA both primary (wood) and secondary (crop residue) biomass collected on the farm are “sustain- able” in that they account for other biomass requirements and harvest practices that allow regeneration of the biomass. (However, this does not account for soil cover against erosion, as discussed later.) Based on these data, the average on- farm wood available for cooking is 1.62 tonnes of dry matter per household per year, and the on-farm crop residues available are 3.33 tonnes of dry matter per household per year. From table 5.1 it is evident that the primary and secondary feedstock consumption for the pyrolysis cookstove is met with sustainable Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 79 Table 5.1  Primary and Secondary Feedstock Characteristics and Availability for Baseline Scenario Wood Residues Unit Moisture content 16.28% 68.00% Dry matter on wet basis (70°C for 48 hours) Carbon content 47.86% 46.29% On-farm availabilitya 1.62 3.33 Tonnes per household per year On-farm pyrolysis ­feedstock 1.15 1.87 Tonnes per household per year consumed Off-farm pyrolysis feedstock 0 0 Tonnes per household per year consumed Source: World Bank. a. Based on sustainable harvest and other biomass uses. on-farm supplies. The on-farm wood comes from woodlots composed mostly of fast-growing single species of trees and from trees and shrubs scattered through- out the farm and around the perimeter (Torres et al. 2011). Crop residues avail- able on the farm are predominantly maize stover, in addition to collard green stalks and banana leaves. Table 5.1 lists the primary and secondary feedstock properties, availability, and quantities consumed using a pyrolysis cookstove per household per year. As the fraction of available banana leaves and collard green stalks are only 5 percent and 0.6 percent respectively of the total available resi- due, the secondary feedstock characteristics utilize maize stover data. However, the other crop residues would not significantly affect the results, as the feedstock properties (heating value and carbon content) are similar to that of stover (Phyllis 2008). The on-farm wood collection is assumed to occur regardless of the household having a traditional or pyrolysis cookstove because the wood fuel requirements for a traditional stove would consume all on-farm wood, plus off-farm wood. Thus, time for collecting on-farm wood is not included. The off-farm wood col- lection requires significant time, and was determined from a self-reported survey of 31 households in the region, where the time to collect off-farm fuelwood was estimated at 4.6 minutes per kilogram of dry wood.2 The crop residues are collected entirely from the farm under the baseline scenario. During maize harvest, it is common practice for farms larger than about 1 hectare to cut the entire aboveground maize plant and make a windrow of plants to allow the grain to dry.3 After drying the grain is removed. Approximately 25 percent of the stover is used for animal feed or other purposes (Torres et al. 2011), and the remaining stover is typically applied back to the field.4 Farms smaller than 1 hectare are more likely to harvest each individual maize, and cut down the stalk and leave it in the field.5 Those residues not used as fodder or fuel decompose in the field. As the average farm size from the study region is 1.77 hectares, the baseline scenario assumes the stover residue is collected regardless of its use in the cookstove. Therefore, the time to collect on-farm residue is not included in the LCA. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 80 Life-Cycle Assessment of Existing Biochar Systems As 25 percent of the total aboveground crop residue is utilized for fodder, construction, or other household purposes, it is assumed that the remaining 75 percent of the residue would be returned to the fields if a traditional ­ three-stone cookstove were in use. Returning crop residues to the field is impor- tant for minimizing erosion. The amount of residue retained on the field to mini- mize erosion is dependent on soil, slope, climate, and crop. Under the baseline scenario, all secondary feedstock (crop residue) needed for the pyrolysis cook- stove is assumed to be collected on the farm. Based on the pyrolysis cookstove’s rate of secondary fuel consumption and measurements of on-farm biomass, 42 percent of the total aboveground crop residues are collected as secondary fuel for cooking and biochar production, while 33 percent of the total aboveground crop residues are returned to the soil, in addition to the biochar that is applied to the soil. The total average aboveground residue available per household is 4.44 tonnes of dry matter per household per year (2.5 tonnes of dry matter per hectare, using the average farm size of 1.77 hectares). Thus, 1.46 tonnes of dry matter per household per year (0.82 tonnes per hectare) of residue would be returned to the soil, 1.11 tonnes used for fodder, and 1.87 tonnes available for pyrolysis. The 33 ­ percent crop residue returned to the soil may or may not be sufficient for erosion protection, as studies specific to the region have not yet been conducted. Limited crop residue production and competing uses for resi- dues on the farm are challenges for soil conservation (Unger et al. 1991). A ­seven-year study of the effect of mulch rates and tillage systems on oxisols in Brazil recommends that 4–6 tonnes per hectare of residues be kept on the soil to reduce runoff and erosion most effectively (Roth et al. 1988). The study found that the soil cover must be at least 90 percent for complete infiltration of high rainfall amounts, where the typical quantities of 1.5 and 2.5 tonnes per hectare of wheat and soybean residue left on the field, respectively, covered 60 percent of the soil surface. From the Kenya case study, even if all the residues were left on the field, 2.5 tonnes of dry matter per hectare would be insufficient to fully prevent runoff and erosion, according to Roth et al. (1988). Given the limited residue production and competing uses, additional strategies for erosion protec- tion, such as selective residue removal, substituting high-quality forages for residues, alley cropping, and using wasteland areas to grow biomass (Roth et al. ­ 1988), should be considered. If the 33 percent residue return is insufficient for erosion protection, then some of the secondary feedstock for the pyrolysis cook- stove would need to be collected off the farm. For example, if 50 percent of the total residues were retained for erosion prevention, an additional 0.76 tonnes of dry matter of off-farm residue would be needed each year. Sources of herbaceous residues could come from local s ­awmills or roadside vegetation. The effects of collecting secondary feedstock off the farm retaining all residues on the field and ­ are discussed in the sensitivity analysis. Cookstove Construction The fuel use, cooking, and biochar production data are from direct measure- ments using a prototype pyrolysis cookstove made of metal. The stove was built Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 81 at Cornell University and brought to Kenya for testing. It is anticipated that the cookstove design could be duplicated using scrap metal locally available in Kenya, or from clay, as is currently under way in the project. The mass of the stove is approximately 2.25 kilograms. The cost of the stove to the farmer is estimated at $10, based on the price of other scrap metal stoves designed to burn sawdust. The lifetime of cookstoves is dependent on the material, construction, and use of the stove. The stoves in this project are still in the early stage and have not come to the end of their useable lifetime. Based on the literature, a range of three to five years is typical for improved biomass cookstoves (Johnson et al. 2008; Joseph 2009; Qadir and Kandpal 1995). The baseline scenario assumes a stove lifetime of four years. Stove Transport It is assumed that the stove is produced at the market center. A farmer would typically walk from home to the village center and then take a bus from the vil- lage center to the market center. The distance from the village to the market center is 10 kilometers each way. The cost of the bus for one passenger is 30 Kenyan shillings each way, or $0.36. The GHG emissions and cost of the round trip bus transport for the farmer to get the stove and bring it back to the farm are included. Emissions data from buses in Kenya were not available, therefore emissions from an urban diesel bus in the United States are used from Sheehan et al. 1998. It is possible that the emissions from a bus in Kenya are higher than from a U.S. bus; however, the overall contribution of the bus emissions to the life cycle are less than 1 percent of the total GHG balance, below the cutoff requirement. Pyrolysis and Cooking The amount of feedstock consumed throughout the year by the pyrolysis cook- stove is presented in table 5.1 based on data available for in-field fuel consump- tion during household cooking. Two different types of tests were utilized for measuring fuel consumption. Table 5.1 presents one method, assessing energy consumed during daily cooking tests in a sample of 20 households (Torres et al. 2011), which is used as the baseline scenario. Fuelwood, biomass, wood char resi- dues, and biochar were measured during daily cooking activities on a per house- hold basis. To determine the energy used per capita, the amount of fuelwood used is multiplied by the energy content and divided by the total amount of people in the household (average household size is 6.7 people). The resulting energy consumption per capita serves as a baseline to compare the current energy consumption of the household and the consumption when a pyrolysis stove is introduced. The result is the fuel use value in table 5.1 used for the base- line scenario. The second method for measuring fuel consumption used a kitchen perfor- mance test in 17 homes (Whitman, Scholz, and Lehmann 2010), where the mass of fuel in a pile before cooking and the mass of fuel remaining in the pile after a predetermined amount of time for a traditional three-stone cookstove was Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 82 Life-Cycle Assessment of Existing Biochar Systems measured and determined to be 1.95 kilograms of dry fuel per capita per day. Subsequently, a ratio from the first method for primary to secondary fuel use for the pyrolysis stove was multiplied by the daily wood use, yielding the high fuel use value as discussed in the sensitivity analysis. Both fuel consumption measure- ment methods have strengths and weaknesses, and thus data from both methods are presented. The yield of biochar is calculated to be 0.52 tonnes per household per year (Torres et al. 2011), which is a 17.2 percent yield of the total feedstock consump- tion on a dry mass basis, or a 27.8 percent yield for the secondary feedstock only. The yearly biochar yield with this cookstove is higher than the 0.19 tonnes per household per year estimated by Iliffe (2009) for the Anila cookstove. Emissions Data Although emissions data specific to the pyrolysis cookstoves is not available, the sensitivity analysis shows that within the tested range the results are reasonable and the same conclusions can be drawn. The emissions are calculated based on data from a gasifier cookstove from MacCarty et al. 2008 and comparing emis- sions to ratios of carbon dioxide and products of incomplete combustion, using the same methodology as in Whitman et al. 2011. The carbon emitted is calcu- lated from the 0.52 tonnes per household per year biochar yield and a biochar carbon content of 65.89 percent (Torres 2011), at 1.07 tonnes per household per year for the pyrolysis stove (as in table 5.2), and indicates that 24 percent of the carbon is retained in the biochar during pyrolysis and 76 percent is emitted (based on the total carbon in both the primary and secondary feedstocks). If calculated based on the carbon in the secondary feedstock only, then 40 percent of the carbon is retained in the biochar during pyrolysis. The amount of carbon dioxide emitted is calculated from equation (5.1): CO2 = Ce / [XCO + [(CO:CO2)*XCO + (CH4:CO)*XCH *(CO:CO2) + 2 4 (EC:CO)*XEC*(CO:CO2) + (OC:CO)*XOC*(CO:CO2)]]  (5.1) where Ce is carbon emitted, XY is the molar mass ratio of carbon to compound Y, CO:CO2 is the mass ratio of carbon monoxide to carbon dioxide, EC is ele- mental carbon, OC is organic carbon, and CH4 is methane, after Whitman et al. (2011). However, it is important to emphasize that the carbon dioxide emissions from renewable feedstock are cancelled out by uptake of carbon dioxide during regrowth. For the baseline scenario, all feedstock is sourced sustainably on-farm and thus carbon dioxide emissions during pyrolysis of these feedstocks are not included. Avoided Traditional Cooking The fuel use for traditional cooking is based on the same biomass assessment by Torres et al. (2011). The total primary feedstock required for traditional cooking is 3.2 tonnes of dry matter per household per year. The available on-farm primary fuel remains at 1.62 tonnes of dry matter per household per year, while the remainder of wood required (1.54 tonnes) is collected off-farm. Off-farm wood Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 83 Table 5.2  Calculated Air Emissions from Pyrolysis Cookstove and Avoided Emissions from Three-Stone Fire, per Household per Year Three-stone Pyrolysis (avoided) Carbon emitted (tonnes per household per year) 1.07 1.51 CO:CO2 0.0252 0.0513 CH4:CO 0.063 0.063 EC:CO 0.00011 0.00011 OC:CO 0.042 0.042 CO2 (tonnes per household per year) 3.8 2.0 CO (tonnes per household per year) 0.095 0.259 CH4 (tonnes per household per year) 0.006 0.016 EC (tonnes per household per year) 1.04E-05 2.85E-05 OC (tonnes per household per year) 0.004 0.011 Source: World Bank. Note: For abbreviations see text accompanying equation (5.1). can be partitioned into a sustainable or renewable fraction and an unsustainable or nonrenewable fraction. The LCA assumes a nonrenewable fraction of 0.8 for off-farm wood, based on estimates for the high deforestation rates in this region (Müller and Mburu 2009; Whitman et al. 2011). The sensitivity analysis com- pares varying the fraction of nonrenewable biomass for off-farm wood. The off- farm wood collection requires 117 hours per household per year. The emissions from the three-stone fire are calculated by the same method as for the pyrolysis stove, as described in the last column of table 5.2. However, in contrast to the pyrolysis cookstove, traditional cooking on a three-stone fire requires more feedstock than can be sourced sustainably (where 80 percent of off-farm wood is nonrenewable), thus the carbon dioxide emissions from the fraction of nonrenewable biomass are counted toward the net GHG impact. Biochar Soil Application The 0.52 tonnes of biochar produced annually on the farm is assumed to be applied to maize fields at a relatively high application rate of 18 tonnes of carbon per hectare, as yield data from multiyear field experiments are only available for this application rate in the project. With a carbon content of 65.89 percent in the stover biochar (Torres 2011), this translates to an application rate of 27 tonnes of biochar per hectare. It is assumed that the biochar available is applied at this rate to a small area (0.019 hectares) rather than being spread out over a larger area at a lower application rate. Thus, the effects of biochar on crops and soils are applicable only to this small area of 0.019 hectares per year. Each year sufficient biochar would be produced to apply it at the rate of 18 tonnes of carbon per hectare to an additional 0.019 hectares of cropland. As the average size of the maize plots of farms in the study region is 0.43 hectares (Torres et al. 2011), Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 84 Life-Cycle Assessment of Existing Biochar Systems it would take almost 23 years to apply biochar to the entire maize plot at the rate of 18 tonnes of carbon per hectare. Judging from data of other experiments in acid tropical soil (Lehmann and Rondon 2006; van Zwieten, Kimber, Downie et al. 2010) it is possible that an application rate of less than 18 tonnes of carbon per hectare would be sufficient. Indeed, preliminary results from greenhouse pot trials (Torres 2011) in this region comparing maize growth and nutrient uptake with fresh biomass, biochar, and ash amendments found significant increases in dry matter production (289 percent) at a biochar application rate of around 2.6 tonnes per hectare. However, the crop yield data from the field trials available were based on the 18 tonnes of carbon per hectare application rate, thus that is used as the baseline, and the sensitivity analysis considers lower application rates. Ideally, future research will determine the minimal application rate at which agronomic improvements can be achieved. Another possibility is that the biochar could be applied to kitchen gardens instead of or in addition to maize plots. However, the LCA assumes all biochar is applied to maize because the crop yield data from this region have focused on maize production. The time to apply bio- char to the field is based on in-field experience and is estimated at 3.4 hours per tonne of biochar.6 Carbon in the Biochar For 1 tonne of the stover biochar, 658.9 kilograms is carbon. Of this carbon, the majority is in a highly stable state and has a mean residence time of 1,000 years or longer at 10°C mean annual temperature (Cheng et al. 2008; Kuzyakov et al. 2009; Lehmann 2007; Lehmann et al. 2009; Lehmann et al. 2008; Liang et al. 2008; Sombroek et al. 2003; Spokas 2010; Zimmerman 2010). A very conserva- tive estimate is an average half-life of 59 years, as measured across seven sites in the United States using incubation experiments at 30°C (Cheng et al. 2008). The stability of the biochar varies with feedstock type, processing, and environmental conditions. For the baseline analysis, a conservative estimate of 80 percent recal- citrant carbon has been assumed (Baldock and Smernik 2002; Lehmann et al. 2009), and the remaining 20 percent of the carbon is labile and emitted as car- bon dioxide in the short term. Biochar Effect on Maize Yield Maize crops are grown twice per year in the study region. The maize grain yield data with and without biochar additions are from on-farm field trials from 2005 through 2010 across a chronosequence of years since converting forest to farmland in the same study region and on similar soils, providing the most extensive dataset available. The biochar applied to fields in this dataset is, how- ever, not from pyrolysis cookstoves. The biochar feedstock was Eucalyptus saligna Sm. trees, and a traditional kiln method was used with a pyrolysis tem- perature between 400°C and 500°C. After pyrolysis, the biochar was put into sacks and pounded into small pieces (between 1 and 20 millimeters diameter). The biochar was then spread evenly over the plots and incorporated using a hand hoe (Kimetu et al. 2008). Much recent research has shown that biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 85 produced from different feedstock and pyrolysis conditions will exhibit differ- ent properties (Zimmerman 2010). Thus, it is a legitimate concern that apply- ing crop residue biochar produced in pyrolysis cookstoves instead of the ­ biochar used in the field trials (from eucalyptus trees via a traditional kiln) may result in different soil and crop response. However, the field trial data are the best available at this stage, and the sensitivity analysis will explore this aspect further. Unpublished data from Lehmann (2011) show that stover biochar improves crop yield in the short term more than wood biochar, thus the crop yield data from wood biochar may be a conservative estimate for the period covered in this study. For this dataset, the biochar was applied at 6 tonnes of carbon per hectare three times over 2005–06 for a total application of 18 tonnes of carbon per hect- are, as described by Kimetu et al. (2008). It is important to note that no further biochar applications were made; therefore a total of 18 tonnes of carbon per hectare was applied over the total timeframe of 2005–10. There are two maize crops per year, one each during the long rain and short rain seasons. The long rain yield data for 2005, 2006, and 2008 are based on plots having received the bio- char plus full phosphorus and potassium fertilization but no nitrogen fertiliza- tion, and controls receiving no biochar but full phosphorus and potassium fertil- ization (data from 2007 were unavailable). The yield data from 2009 and 2010 were for biochar plots with no fertilization as compared to control plots receiving no fertilization. The motivation behind using plots with minimal or no fertiliza- tion is that many smallholder farmers in the region cannot afford to fertilize their plots at the full rate as would be used on research plots. Thus, the best data avail- able with minimal or no fertilization were selected to calculate the baseline. With these data, the average maize grain yield across all farms on control plots is 2.6 tonnes per hectare for the long rain season. Data for the short rain season were only available for 2004, therefore the mean yield across the farms is used at 2.4 tonnes per hectare. The total grain yield per year (long rain plus short rain) is 5 tonnes per hectare. The baseline scenario assumes a 29 percent maize yield increase on the plot area receiving the 18 tonnes of carbon per hectare biochar application. For a 5 tonnes per hectare yield for the control, a 29 percent increase results in a yield rate of 6.5 tonnes per hectare with biochar additions. The actual measured yield increases varied significantly with changes in soil fertility (Kimetu et al. 2008) and ranged from –18 percent to +97 percent compared to the con- trol for the same period. The sensitivity analysis considers a range in crop yield effect from –50 percent to +97 percent, which allows for exploring the variabil- ity in the extent of the preexisting soil degradation, time since forest conversion, farmer practices, weather conditions, and fertilization rates. The maximum value of +97 percent increase is based on the Kimetu et al. (2008) study for full nitro- gen, phosphorus, and potassium fertilization on control plots in highly degraded sites (80–105 years after forest conversion). Reviews of biochar applications rates and plant responses have shown a wide variation, from –29 percent to +324 percent (Glaser, Lehmann, and Zech 2002), or –60 percent to +100 percent (Verheijen et al. 2010). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 86 Life-Cycle Assessment of Existing Biochar Systems The increased grain yields would result in an increase in food available for the family. In the case of subsistence farming (as applies for farmers in this region), any surplus grain is used to feed the family. It is unusual for a surplus to be sold at markets, as the primary concern is providing enough food for self-sufficiency of the household. In the rare case where there is excess beyond what the family needs, farmers may not be able to sell at market prices due to the role played by intermediaries.7 Therefore the baseline scenario assumes no revenues from increased maize yields. However, the economic analysis and discussion also con- siders a scenario where this surplus in maize is monetized using the August 2010 price, whereby farmers receive 2,000 Kenyan shillings (about $24) for one 90-kilogram sack of air-dried, shelled maize grain. The sensitivity analysis consid- ers a range in maize prices, as the price of maize grain is extremely fluid depend- ing on the time of year (increased price during the dry season) and the general success of the harvest.8 Duration of Biochar’s Agronomic Effect For the soils in this region of Kenya, biochar’s effect on crop productivity was found to be due mainly to increased soil organic carbon (Kimetu et al. 2008), and thus would be expected to last for the lifetime of the biochar in the soil. The baseline scenario assumes a 50-year agronomic effect for the applied biochar, which is a very conservative assumption based on the expected mean residence times of biochar as cited above. The sensitivity analysis investigates this aspect. Soil Organic Carbon from Residue Removal When crop residues such as maize stover are removed from the field, there is the potential to decrease soil organic carbon as compared to fields without stover removal (Moebius-Clune et al. 2008). Kapkiyai et al. (1999) in Kenya report that for plots receiving no other inputs, after 18 years the soil organic carbon is 23.8 tonnes of carbon per hectare with stover removal and 24.6 tonnes with stover remaining. The difference is 0.8 tonnes of carbon per hectare loss over 18 years, or 0.04 tonnes of carbon annual average for complete stover removal. Thus, with 42 percent of total residue collection for pyrolysis, 0.02 tonnes of carbon per year is lost. This corresponds to 4 kilograms of CO2e per tonne of dry stover removed, based on an average stover yield of 17.4 tonnes per hectare for the long and short rain seasons across all sites. The issue of erosion protection with crop residue removal is discussed under the “Feedstock” subsection above. Soil Organic Carbon from Increased Productivity As crop productivity increases with biochar application, the amount of aboveg- round and belowground biomass increases. Because aboveground biomass may be collected for pyrolysis or other on-farm needs, the LCA model assumes only the increase in belowground biomass contributes to an increase in soil organic carbon levels. Shoot to root ratio measurements of stover biochar-amended maize plants are around 0.9 (Torres et al. 2011). The amount of soil organic carbon from the incremental belowground biomass is estimated to be 0.04 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 87 tonnes of carbon per hectare per year, as discussed in the preceding paragraph. The average long rain stover yield (2005–09) of 4.6 tonnes per hectare and the 0.9 shoot to root ratio is used to calculate a soil organic carbon accumulation of 0.008 tonnes of carbon per tonne of belowground biomass. For a 29 percent crop yield increase and an average stover to grain ratio of 2.7 across all sites for 2005–09,9 the increase in stover per year is 2.1 tonnes per hectare, and thus the increase in belowground biomass per year is 2.3 tonnes per hectare. At this level, the incre- mental soil organic carbon increase due to increased belowground biomass pro- ductivity with biochar additions is 0.02 tonnes of carbon per hectare per year. This corresponds to 2.7 kilograms of CO2e per tonne of biochar per year, or 134 kilograms of CO2e per tonne of biochar for a 50-year biochar effect. Soil Organic Carbon from Priming Effects The LCA does not include positive or negative priming effects. This is due to the fact that the controlling mechanisms are not yet fully known, and both short-term positive and long-term negative priming have been found. More detailed discus- sion on priming effects can be found under “Soil Organic Matter” in the section titled “Impacts on Soil Health and Agricultural Productivity” in chapter 3.2. The Role of Nitrogen and Biochar Nitrogen plays a critical role in agriculture and the role of biochar application and its effect on nitrogen must be discussed. The changes in nitrogen dynamics relevant to crop productivity are included implicitly as the crop yields are an aggregate result of the intervention. Three aspects are of concern: (a) the nitro- gen changes in the biochar; (b) the nitrogen emissions during pyrolysis; and (c) the nitrogen changes in the soil after biochar application. When crop residues are removed from the field, the nitrogen they contain is also removed. Research in the Lehmann group at Cornell continues to investi- gate the nitrogen dynamics in these systems in Kenya (Torres et al. 2011). In this study, the fresh stover biomass was found to have a nitrogen content of 0.58 percent. For the annual supply of secondary feedstock (1.87 tonnes) for the household pyrolysis cookstove, about 11 kilograms of nitrogen are removed with the residue. During pyrolysis, approximately half of the nitrogen is retained in the biochar, and the relative nitrogen content of the biochar actually increases to 1.22 percent while the C:N ratio decreases from 80 to 54 (Torres 2011). Thus, when the 0.52 tonnes of biochar are applied back to the soil annually, 6 kilo- grams of nitrogen are returned with it. Second, the nitrogen species emitted during pyrolysis are assumed to be in the form of nitrogen oxides, as nitrous oxide is typically associated with high- temperature combustion, and has been demonstrated to be a small fraction of biomass stove GHG emissions in other studies (Johnson et al. 2008; MacCarty et al. 2008; Zhang et al. 2000). The nitrogen oxide emissions data for this stove are calculated to be 0.0036 kilograms of nitrogen oxides per household per year, or 0.00065 grams per kilogram of fuel. This is significantly lower than the range of 0.4 to 1.1 grams per kilogram of fuel found for a series of cookstoves Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 88 Life-Cycle Assessment of Existing Biochar Systems in China (Wang 2007). Although nitrogen oxides are presently assumed to be greenhouse neutral, it is a precursor to ozone and can result in acid rain (MacCarty et al. 2008). Because of the high C:N ratio of biochar made from wood as in this project (C:N of 387), another important consideration is the potential for nitrogen immobilization with biochar application. The process of pyrolysis forms hetero- cyclic nitrogen compounds, meaning that the nitrogen is largely unavailable despite the decrease in C:N ratio with pyrolysis. In addition, soil microbial com- munities require nitrogen in order to utilize carbon. If there is not sufficient nitrogen in the biomass (or biochar), then the microbes take nitrogen from the soil, making it unavailable to the plant. The nitrogen immobilization with bio- char application would be expected to be a short-term or immediate effect that would potentially decrease crop yields. However, it is likely that the crop yield data incorporate this effect, thus any reduced nitrogen availability is assumed to be taken into account. (Torres [2011] actually found that there was an increase in crop uptake of nitrogen with biochar addition compared to fresh biomass addition. It is hypothesized that the increased nitrogen uptake signaled a lower nitrogen immobilization, not due to improved nitrogen availability, but rather due to reduced carbon availability because of the highly recalcitrant nature of carbon in the biochar.) Another consideration is the role of biochar on fertilizer use efficiency. Studies have suggested an increase in nitrogen fertilizer use efficiency with biochar addi- tions (Chan et al. 2007; Steiner et al. 2008; van Zwieten, Kimber, Downie et al. 2010). This effect would potentially increase crop yields and is assumed to be incorporated into the effect of biochar on crop yields. The effect could decrease the amount of nitrogen fertilizer applied to soils. However, because fertilizer inputs on these farms are generally low, it is likely that the amount applied would not change but rather their effectiveness would be improved. The nitrogen immobilization and nitrogen fertilizer use efficiency may potentially be counter- acting the effects of biochar on crop production. Although crop yield data are available only in the shorter term (five years), it is possible that in the longer term the effects of one effect may become more pronounced. As longer-term field tri- als continue, these interactions will become better understood. Soil Nitrous Oxide and Methane Emissions The baseline scenario of this analysis assumes that there are no changes in soil nitrous oxide emissions with biochar application for the following reasons: (a) lack of site-specific data for fertilizer-related nitrous oxide emissions; and (b) variability in fertilizer application rates on smallholder farms in Kenya. However, biochar reportedly reduces nitrous oxide soil emissions in many situations that result from nitrogen fertilizer application (see the section titled “Impacts on Climate Change” in chapter 3). The sensitivity analysis considers a range of +50 percent to –50 per- cent for the effect of biochar application on soil nitrous oxide emissions. The current estimate for the conversion of fertilizer nitrogen to nitrous oxide emissions of 1.325 percent for U.S. corn production (Wang 2007) is used in the sensitivity analysis. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 89 This analysis does not assume any effect of biochar on methane emissions from soil. Experiments have indicated that not all biochars will affect nitrous oxide or methane emissions equally (see the section titled “Impacts on Climate Change” in chapter 3 for further detail). Avoided Nitrous Oxide and Methane Emissions from Biomass This analysis assumes no additional emissions of non-carbon dioxide GHGs as a result of biomass additions to soil. Results and Discussion Table 5.3 lists the results for the Kenya pyrolysis cookstove system. The net GHG balance is −1.8 tonnes of CO2e per tonne of dry matter, as illustrated fur- ther in figure 5.3. The amount of time saved with the pyrolysis cookstove is 62 hours per tonne of dry matter, and the net economic balance is −$1.43 per tonne of dry matter. The majority of both the GHG emissions and reductions are from carbon dioxide, with much smaller contributions from methane and nitrous oxide (table 5.3). The surplus maize from biochar additions is 0.74 tonnes of grain per tonne of dry matter over the 50 years of biochar’s effect on crop yields. Looking at the contribution analysis in figure 5.3a, the largest source of reduced GHG emissions is the avoided traditional cooking, at −1.3 tonnes of CO2e per tonne of dry matter, or 69 percent of the total GHG reductions. This large contribution is due mainly to the fact that 49 percent of the traditional cook- ing fuelwood is collected off-farm, of which 80 percent is from a nonrenewable source. Meanwhile, all of the primary and secondary feedstock for the pyrolysis cookstove is able to be supplied on-farm, and is thus considered renewable. Table 5.3  Result Vector for Pyrolysis Cookstove in Kenya Baseline Scenario per Tonne of Dry Feedstock Input/output Value Unit Off-farm wood fuel 0.93 tonne Time  61.5 hour Methane – 5.55 kg Nitrous oxide 7.82E-07 kg Carbon dioxide –1,628 kg Stable carbon   147 kg Net CO2e –1,767 kg Revenue  0 $ Cost –1.43 $ Net $ –1.43 $ Surplus maize  0.74 tonne Source: World Bank. Note: For methane, nitrous oxide, and carbon dioxide, a negative sign corresponds to avoided emissions or sequestration, and a positive value indicates emissions. Negative $ are costs, and positive $ are net revenues. Positive time corresponds to time savings. The bold type indicates the net GHG and economic balances. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 90 Life-Cycle Assessment of Existing Biochar Systems Figure 5.3  Sources of GHG Reductions and Emissions, and Carbon Balance for Secondary Feedstock a. – Emissions/Reductions Net = –1.8 + 0 0.5 1 1.5 2 GHG (t CO2e t–1DM) Avoid trad. cooking Stable C in biochar SOC accumulation Pyrolysis cooking SOC depletion Bus transport b. 1500 Secondary feedstock carbon (t CO2e t–1 DM) 1000 –538 kg CO2e 500 Net 0 –500 Balance of secondary feedstock carbon –1,000 CO2e uptake from atmosphere to biomass: –1696 t CO2e release in pyrolysis emissions: 1024 t –1,500 CO2e release in labile C fraction of biochar: 134.5 kg Result — CO2e stabilized in biochar: –538 kg –2,000 Secondary Pyrolysis Labile C in Stable C in feedstock emissions biochar biochar Source: World Bank. Note: 5.3a. Figure shows contribution analysis for the net climate change impact per tonne of dry secondary feedstock for a pyrolysis cookstove biochar system in Kenya. The upper bar (–) represents the GHG reductions, the lower bar (+) is GHG emissions, and the difference represents the net GHG balance of the system. C = carbon; SOC = soil organic compound; CO2e = carbon dioxide equivalent. 5.3b. Figure shows carbon balance for secondary feedstock. The pyrolysis carbon dioxide emissions associated with the secondary feedstock and the labile carbon in the biochar are subtracted from the quantity of CO2e taken up by the renewable, secondary feedstock. The net result is the CO2e from the stable carbon in the biochar. This schematic demonstrates how the pyrolysis CO2e emissions from the secondary feedstock are accounted for. Thus, in 5.3a, the pyrolysis emissions are the non-carbon dioxide GHG emissions only. C = carbon; CO2e = carbon dioxide equivalent. . Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 91 Therefore, the carbon dioxide emissions from the pyrolysis cookstove are can- celled out by the uptake of carbon dioxide of the renewable feedstocks, highlight- ing the important role that the renewability of the feedstock plays in the GHG balance. Only non-carbon dioxide GHG emissions are included in the pyrolysis emissions, as these are assumed to not otherwise occur. The carbon balance for the secondary feedstock (crop residues) is illustrated in figure 5.3b. The stable carbon in the biochar is responsible for the sequestration of an additional −0.5 tonnes of CO2e per tonne of dry matter (29 percent of total reductions). The greatest amount of GHG emissions occurs during pyrolysis cooking (+0.8 tonnes of CO2e per tonne of dry matter, or 95 percent of total emissions). The 95 percent of emissions seems high, but it is actually quite small, as the total emissions are negligible in comparison to the total reductions. The soil organic carbon accu- mulation (due to increased crop productivity) and soil organic carbon depletion (due to crop residue removal) contribute only minor amounts to the balance, at 2 percent of the GHG reductions and 5 percent of the GHG emissions, respectively. Finally, transportation has the smallest impact, at less than 0.01 percent. From the GHG contribution analysis it is clear that the avoided traditional cooking is the primary source of net GHG reductions. However, as mentioned above, the sustainable harvest of both primary and secondary feedstocks are critical to ensure carbon dioxide uptake with regrowth. To compare the GHG balance of −1.8 tonnes of CO2e per tonne of dry matter to other studies, a different func- tional unit is used in the following, which is the amount of cooking energy required for one family for a year. This results in the following GHG balance: −3.3 tonnes of CO2e per household per year.10 It is possible that comparable GHG reductions could be achieved with nonpyrolytic improved cookstoves. For example, 2.3–3.9 tonnes of CO2e per household per year of emission reductions could be achieved for improved cookstoves in Mexico (Johnson et al. 2009). However, within the emission reductions of the pyrolysis cookstove system, atmospheric carbon dioxide is converted to the stable carbon in the biochar. On the other hand, energy effi- ciency of the pyrolysis stove is lower (Whitman et al. 2011). The pyrolysis cook- stove has the benefit of utilizing secondary fuel, which reduces fuelwood con- sumption, fuelwood collection time, and deforestation pressures even further than an improved cookstove that still requires only primary feedstock. In addition to the monetary inputs and outputs, the LCA also calculates the net time savings, which is 115 hours per household per year, or 65 hours per tonne of dry matter. The net time savings estimate takes into account the reduced fuel collection due to decreased primary fuel consumption and the increased time to apply biochar to the fields. The time saved could be utilized for other family, farming, or commu- nity activities. In 2008, the lower agricultural minimum wage was 2,536 Kenya shillings ($35) per month for Kenya (U.S. Department of State 2009). Assuming a workweek of 52 hours, this translates to $0.16 per hour, which corresponds well with the $1.25 per day rate for agricultural workers in Kenya.11 The 115 hours saved per year would then correspond to an additional $18.40 per year for a net revenue of +$16 per household, or $8 per tonne of dry matter, compared to the baseline −$1 per tonne of dry matter without valuing the time saved (figure 5.4). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 92 Life-Cycle Assessment of Existing Biochar Systems Figure 5.4   Contribution Analysis for Net Revenues per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya 300 250 Net = $245 Net revenue ($ t–1DM) 200 150 100 50 Net = $32 Net = –$1 Net = $8 Net = $9 Net = $1 0 Baseline Time saved biochar GHG reductions 1-crop e ect 50-yr e ect Stable C in Life cycle Maize $, Maize $, –50 Stove cost Bus transport Labor savings C credits Increased productivity Source: World Bank. Note: The six scenarios are as follows: “baseline” includes only the monetary inputs and outputs of the baseline scenario; “time saved” is the baseline plus a monetary value assigned to the time saved in fuelwood collection; “stable carbon in biochar” values GHG offsets for the carbon dioxide sequestered directly by stable carbon in biochar; “life-cycle GHG reductions” values the net GHG reductions, which includes avoided emissions; “maize $, 1-crop effect” is where the surplus maize produced is monetized for a one-crop biochar effect; and “maize $, 50-yr effect” is where the surplus maize produced is monetized for a 50-year biochar effect. The pyrolysis cookstove system also offers the advantage of improved soil fertility over nonbiochar cookstove scenarios. The baseline scenario does not capture the monetary value of this improved fertility because of the reality of subsistence farming—surplus grain feeds the family but does not usually generate any income. However, the two scenarios, “maize $, 1-crop effect” and “maize $, 50-yr effect” of figure 5.4 explore this, where a monetary value is assigned to the surplus maize. The baseline LCA assumes the 50-year biochar effect, which would translate to a gain of $246 per tonne of dry matter from surplus maize sales, for a net of $245 over the 50 years of biochar’s effect. Assigning a maize value for a one-crop biochar effect results in a net of $1. A biochar payback period provides an estimate of the number of years it would take biochar used as a soil amendment to pay for itself. If the surplus maize, labor savings, or carbon offsets are not monetized, then the payback will never take place in monetary terms (that is, the net revenue will always be nega- tive). However, this would not be an accurate assessment of the improved liveli- hoods of these smallholder farmers. For this reason, the payback period is calcu- lated assuming the base price of $24 per 90-kilogram bag of maize grain. When monetizing the surplus maize, the biochar would pay for itself in the first year. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 93 Finally, the possibility of pyrolysis cookstove programs receiving carbon cred- its would further improve the livelihoods of smallholder farms, as demonstrated in figure 5.4. For a carbon dioxide price of $14,12 or $19, assuming an exchange rate of $1.36 to the euro, the revenues could be an additional $33 per tonne of dry matter (for a net of $32) when valuing the net GHG reductions, or an addi- tional $10 (for a total of $9) if only the stable carbon in the biochar were eligible for carbon credits. The 3.3 tonnes of CO2e per household per year net GHG reductions is within the range of values calculated in the Stove Impact on Climate Change Tool (SImpaCCT) systems dynamics model from Whitman et al. 2011, where between 2.6 and 5.8 tonnes of CO2e per household per year of GHG reductions were modeled. The lower end of this range (2.6–4.7 tonnes) from SImpaCCT is based on a prototype pyrolysis stove, and the upper range (3.3–5.8 tonnes) is for a refined pyrolysis cookstove. The data for the present LCA utilizes the proto- type cookstove data, which sit centered in this lower range. The 4.7 tonnes of CO2e per household per year calculated in SImpaCCT assumes that 50 percent of on-farm available residues are collected and all off-farm biomass collected is nonrenewable. However, one of the primary differences is that SImpaCCT uti- lizes a higher fuel consumption rate than the present LCA (discussed above in the “Pyrolysis and Cooking” subsection). With the lower fuel consumption rate used in the LCA, all of the biomass needs are met on the farm, thus no off-farm fuel is collected for pyrolysis cooking in the baseline scenario (but avoided tradi- tional cooking requires 49 percent of fuel needs to be met with off-farm fuel- wood, of which 80 percent is nonrenewable). In addition, although the present LCA assumes biochar is agronomically effective for 50 years (which contributes –0.04 tonnes of CO2e from increased soil organic carbon), LCA is a static model- ing tool that does not incorporate temporal dynamics and feedback mechanisms. Meanwhile, SImpaCCT is a dynamic model that considers changes in stocks and flows of carbon over time. Alternative Functional Units Another viewpoint for thinking about the long-term effect of biochar on crop productivity would use 1 tonne of biochar as the functional unit. This allows the costs and benefits to be assigned on a per biochar basis and still accumulate long- term effects for the duration of biochar’s effectiveness, without using a functional unit with a temporal basis that may potentially confuse the issue. With this in mind and utilizing a 50-year effect of biochar on soil properties, the net impact of 1 tonne of biochar for the Kenya cookstove system results in GHG reductions of –6.3 tonnes of CO2e and 2.7 tonnes of surplus maize per tonne of biochar. If the surplus maize is not monetized, the net economic balance is –$5, whereas if the surplus maize is valued at $24 per bag, then the balance is $879 per tonne of biochar. Again, these results are for a 50-year biochar effect on crop productiv- ity. It is not assumed within the lifetime of this project that more biochar is applied than the specified application rate, or that crop yields decrease with increasing biochar application rates, as the maximum tested is not exceeded. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 94 Life-Cycle Assessment of Existing Biochar Systems Table 5.4 Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Primary feedstock (tonnes of dry matter per household per year) 1.15 1.15–3.02 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) +29 –50 to +97 Maize prices ($ per 90-kg bag) 0 18–36 Duration of biochar’s effect (years) 50 1–100 Pyrolysis methane emissions (kg per tonne of dry matter) 1.98 1.64–6.4 Three-stone fire methane emissions (kg per tonne of dry matter) 5.17 0.60–6.4 Fraction of nonrenewable biomass for off-farm wood 0.8 0–1.0 Biochar application rate (tonnes per hectare) 27 2.7–27 Soil nitrous oxide emissions (%) 0 –50% to +50% Fraction of secondary feedstock collected off-farm 0 0–1.0 Source: World Bank. Sensitivity Analysis A sensitivity analysis was conducted in order to measure the variability in the LCA results as a function of varying key input parameters (table 5.4). The input parameters that were tested were the primary feedstock consumption, the fraction of recalcitrant carbon in the biochar, the yield response of maize crops with biochar additions, the price the farmer receives for maize, methane emissions of the pyrolysis cookstove, methane emissions of the traditional three-stone cookstove, the duration of biochar’s agronomic effectiveness, soil organic carbon accumulation, the fraction of nonrenewable biomass for off- farm wood, the biochar application rate, soil nitrous oxide emissions, and the fraction of secondary feedstock collected off-farm. The detailed sensitivity Figure 5.5  Sensitivity Analysis for Net GHG per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya a. Cook stove CH4 emissions (% change from baseline) b. Soil N2O emissions (% change from baseline) 0.0 1.0 2.0 3.0 4.0 5.0 6.0 7.0 –60% –40% –20% 0% 20% 40% 60% 10 60 GHG (% change from baseline) GHG (% change from baseline) 40 0 20 –10 0 –20 –20 –40 –30 –60 –40 –80 0 20 40 60 80 100 0 0.2 0.4 0.6 0.8 1 1.2 Stable carbon fraction, % fNRB Stability Pyro stove CH4 emissions fNRB Soil N2O emissions Source: World Bank. Note: Figure 5.5a compares the fraction of stable carbon in the biochar to the pyrolysis cookstove methane emissions, and 5.5b illustrates the variation in fraction of nonrenewable biomass and soil nitrous oxide emissions (nitrous oxide emissions range chosen according to extreme values available in the literature, see text). CH4 = methane; N2O = nitrous oxide; GHG = greenhouse gas; fNRB = fraction of nonrenewable biomass. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 95 Figure 5.6  Sensitivity Analysis for Net Economic Balance per Tonne of Dry Secondary Feedstock for Pyrolysis Cookstove Biochar System in Kenya a. Maize price ($ per 90 kg bag) b. Biochar application rate (t ha–2) $0 $10 $20 $30 $40 0 5 10 15 20 25 30 Net revenue (% change from baseline) 600 1,200 (% change from baseline) 1,000 400 800 Net revenue 200 600 0 400 200 –200 0 –400 –200 –100 –50 0 50 100 150 0 20 40 60 80 100 120 Crop yield (% change from control) Duration of biochar e ect, year Crop yield Maize prices Biochar e ect Biochar application rate Source: World Bank. Source: World Bank. Note: Figure 5.6a compares the crop yield to maize prices, and 5.6b illustrates the variation in the duration of biochar’s agronomic effect and the biochar application rate. analysis is presented in appendix B, while a summary of the sensitivity analysis results is described here. The GHG balance is relatively insensitive (less than around 10 percent vari- ability) to the pyrolysis methane emissions, the avoided traditional cooking methane emissions, the duration of biochar’s agronomic effect, and the crop yield response to biochar additions. The fraction of the stable carbon in the biochar within the realistic range of 50–90 percent influences the net GHG balance by only 11 percent, and thus also has a relatively small influence on the net results. Meanwhile, the GHG balance is more sensitive to the primary feedstock con- sumption rate (100 percent), the fraction of nonrenewable biomass for off-farm wood (60 percent), the biochar application rate (20 percent), and soil nitrous oxide emissions (±44 percent) (figure 5.5). Significant effects on the net economic balance are found within the range tested for the duration of biochar’s agronomic effect (100 percent), crop yield response (274 percent), biochar application rate (956 percent), and how the surplus maize crop is monetized (369 percent). Figure 5.6 illustrates this vari- ability, where it is evident that the biochar application rate has the largest impact on the net economics, followed by the crop yield response due to biochar addi- tions. The duration of biochar’s effect appears small next to the biochar applica- tion rate, but still results in up to 100 percent change in the net economics, while the variability in maize prices affects the results by up to 369 percent. More details on the sensitivity analysis can be found in appendix B. Additional Considerations There are specific issues unique to biochar systems that are not incorporated into the LCA because they are outside the system boundaries or scope of the analysis or not quantifiable in a traditional sense. However, they are important to include as a discussion item. One challenge is in handling biochar. The high volume to weight ratio means there is a potential for biochar to be blown or washed away, Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 96 Life-Cycle Assessment of Existing Biochar Systems and the application to soils can be difficult. Inhalation of fine airborne biochar particles is also an important concern. If not quenched or cooled sufficiently, bio- char is highly flammable and could present a fire hazard (section titled “Impacts on Climate Change” in chapter 3). The families operating the stoves would need to be aware of these issues to ensure that the biochar is completely cooled or quenched prior to removing from the cookstoves. Another concern is storing the biochar. Because small quantities are produced at a time, the family may choose to store the biochar until sufficient amounts are collected and it is the best time for application. However, if the biochar is applied right away, the need to store the biochar would be eliminated. Another valid concern, as discussed by Iliffe (2009), is that the quantity of biochar produced is limited by the amount of cooking. Even if the family wanted to produce more biochar, the cookstove remains hot for a few hours after use and cannot be handled to remove the biochar until it is cooled. Thus, the number of meals cooked per day limits the amount of biochar available to the family. However, due to renewable feedstock limitations, this may be the most sustainable scenario until other feedstock sources are identified. Box 5.2 Summary of Kenya Case Study The Kenya household pyrolysis cookstove system with biochar returned to soil has the poten- tial for climate change mitigation through carbon sequestration and GHG emission reductions, while also being economically viable for the smallholder farmer. Using the pyrolysis cookstove for household cooking and producing biochar, the net GHG reductions are –1.8 tonnes CO2e per tonne of dry pyrolysis (secondary) feedstock. The net economic balance is –$1 per tonne of dry matter where no monetary value is assigned to surplus grain, labor savings, or potential carbon credits. If the 62 hours saved in fuelwood collection are monetized, the net return would be $8 per year. If carbon credits were received (at $19 per tonne of CO2e), the household could return from $27 to $50 per tonne of dry matter, depending on whether avoided emis- sions are valued the same as carbon sequestered directly in the biochar. If the surplus maize is valued, the net return would be $1 per cropping season of biochar’s effectiveness, or $245 for a biochar effectiveness of 50 years. Synergistic benefits of the pyrolysis cookstove project may include decreased indoor air pollution and related illnesses (section titled “Social Impacts” in chapter 3), reduced fuelwood consumption and thereby decreased deforestation pressures (section titled “Impacts on Climate Change” in chapter 3), and improved long-term soil fertility (section titled “Impacts on Soil Health and Agricultural Productivity” in chapter 3). The contribution analysis reveals that the net GHG balance is largely driven by the avoid- ed emissions from the traditional three-stone fire and the sustainability of the primary and secondary cookstove feedstock. If the feedstock is unsustainably harvested and does not regrow, then emissions during cooking would not be offset by the biomass regrowth. Mean- while, the amount of stable carbon in the biochar contributes 29 percent of the net GHG reductions. Soil nitrous oxide emissions can also play an important role in the GHG balance, thus more data are required to quantify this effect. The sensitivity analysis reveals that the net GHG balance is relatively insensitive to chang- es in methane emissions during traditional or pyrolysis cooking, the crop yield response with box continues next page Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 97 Box 5.2 Summary of Kenya Case Study (continued) biochar additions, and the duration of biochar’s agronomic effect, within the realistic range tested for these parameters. The surplus maize is most sensitive to the crop yield response and the biochar application rate. Meanwhile, the net revenues are very sensitive to the crop yield response and the price of maize. This Kenya pyrolysis cookstove system presents itself as a low-risk biochar project with climate change adaptation and economic benefits for the smallholder farmers implementing these stoves and utilizing the biochar. Vietnam Case Study Life-Cycle Assessment System Overview The biochar project described here is a component of a larger development project related to institutional capacity building, irrigation water management, and soil nutrient management. The title of the project is “Improving the utilization of soil and water resources for tree crop production in coastal areas of Vietnam and New South Wales,” and it is funded by the Australian Centre for International Agricultural Research and implemented by the Agricultural Science Institute for Southern Central Coastal Vietnam in collaboration with the Department of Primary Industries, New South Wales, Australia. The project started in 2007 and aims to improve incomes of low-income farmers in central coastal Vietnam, where large areas of sandy soils occur. Charcoal, or biochar, is produced as a by-product of spring roll rice wafer cottage industries in the Ninh Thuan province in the central coast region. The feedstock for the rice wafer stoves is rice husks, which would otherwise be burned as a means of waste management. The biochar by-product is purchased from local families by the project working with three different farmers in the area, and is applied to peanut and cashew fields. The case study uses data from peanut farms, as the project contacts indicate that there is a trend of farmers transitioning to growing more peanuts than cashews because of higher potential revenues, and the peanut data are more mature than the cashew data at the time of writing. The biochar is applied wet, at 20 tonnes per hectare, or 12 tonnes of dry biochar per hectare. Methodology Function, Functional Unit, and Reference Flows For the Vietnam case study, biochar production is a multioutput system with up to four coproducts: biomass management, soil amendment, carbon sequestration, and bioenergy production. The functional unit of the system is 1 tonne of dry rice husk, which is used as a rice wafer stove feedstock. The subsequent biochar is applied to peanut fields on a farm in Vietnam. System Boundaries A flow diagram of the biochar system is illustrated in figure 5.7. The system is organized into four modules: rice husk feedstock, cooking, biochar, and crop response, each of which has multiple subprocesses. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 98 Life-Cycle Assessment of Existing Biochar Systems Figure 5.7 Schematic Flow Diagram for Vietnam Biochar System Rice wafer production 99% Air emissions Rice husk, at mill Soil application Recalcitrant carbon Rice husk Peanut Cooking yield feedstock 1% Labile carbon Cook stove Avoided rice Biochar Crop response production husk burning Avoided soil Reduced nitrous oxide SOC Wetting fertilizer emissions accumulation biochar input Duration of Reduced biochar’s effect labor input Overall system boundary Rice husk and rice wafer cooking Subprocess included only in the upstream processes sensitivity analysis Process module Subprocess within module Subprocess including monetary or labor inputs Source: World Bank. Note: SOC = soil organic compound. Because in this case study the biochar production is a by-product of an ­ stablished rice wafer cooking business, economic allocation is used to separate the e impacts associated with cooking and the rice husk feedstock of the biochar produc- tion from the rice wafer production. The allocation is done by taking the relative percentage of biochar to the total products (biochar + rice wafers) on an economic basis, then including that percentage impact for the upstream p ­ rocesses, as illus- trated in the process flow diagram. This affects both “positive” (avoided emissions from rice husk burning) and “negative” (emissions from c ­ ooking) upstream impacts equally, and the relative allocation is tested via the sensitivity analysis. All other processes in this LCA are included via the system expansion method. Life-Cycle Inventory Rice Husk Feedstock The project contacts state that local reports indicate about 50 percent of rice hulls at mills are used for a range of downstream purposes (such as for fuel in rice mills, in homes, and in brick kilns), and about 50 percent represent a waste problem (and are thus burnt for disposal) (Slavich et al. 2010). The rice husks are typically piled up at rice mills and eventually burned if not used for other purposes. Hence, utilizing the rice husk as a fuel is also a waste management strategy. Thus, this LCA assumes that if the rice wafer stoves were not using the rice husks, then the rice husks would be burned, as in the “avoided rice husk burning” subprocess. The rice husk feedstock is available in 200-liter bags. Using an average rice husk density of 90 kilograms per cubic meter,13 each bag contains 18 kilograms Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 99 of rice husk. One 200-liter bag of rice husk costs 6,000 Vietnamese dong (VND) ($0.27), which includes the cost of the bag (3,000 VND) and filling the bag. If farmers were to bring their own bag and fill it themselves, the cost would be reduced to only 500 VND per bag. Avoided Rice Husk Burning Rice husks not utilized are piled up at rice mills and ultimately burned in piles as a waste management strategy. Emission factors were taken from data for smolder- ing rice husk mounds used in charcoal production in Thailand. These mounds have layers of rice husks covered by a layer of soil over a charge of approximately 200 kilograms of wood (Smith et al. 1999). The rice husk piles are the most rep- resentative data of in-field rice husk burning available, and these emission factors will be explored in the sensitivity analysis. The carbon dioxide, carbon monoxide, methane, and nitrous oxide emission factors from the Smith et al. study are 443, 30.9, 3.71, and 0.0232 kilograms per tonne of dry feedstock, respectively. In addi- tion to the GHG emissions from residue burning, a value of 3 percent of the carbon in the residue is estimated to be converted to char during open residue burning (Forbes, Raison, and Skjemstad 2006; Glaser, Lehmann, and Zech 2002). Rice Wafer Stove Construction The rice wafer stove is a slanting grate updraft gasifier stove with a chimney. There are few data on the construction of the rice wafer stove beyond what is evident from qualitative descriptions and photographs (figure 5.8). These are Figure 5.8  Rice Wafer Stove in Vietnam Source: P. Slavich (2010). Note: Figure 5.3a shows a top view of the rice husk feedstock input compartment and rice wafer cooking area; 5.3b is a side view where biochar is raked out; 5.3c is an outdoor view of smokeless chimney. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 100 Life-Cycle Assessment of Existing Biochar Systems traditional stoves that have been in use for at least 100 years. There are more than 100 households with similar stoves in the village, and this would be the same for villages throughout the region.14 The stove is indoors and located against an exte- rior wall. The indoor section consists of the cooking and feedstock input areas (figure 5.8a), and the chimney is outdoors (figure 5.8c). The materials for con- structing the stove are estimated from the number of bricks, where approxi- mately 622 kilograms of brick are required per stove. The amount of mortar is estimated from the approximate mortar required of 1,300 kilograms per 1,000 bricks with ½-inch joint spacing,15 which comes to 810 kilograms of mortar per stove. The mortar is assumed to be a clay-based material. The stove lifetime is estimated at 20 years for the baseline scenario. With these parameters and the economic allocation (discussed below), the input materials required per functional unit are only 5 kilograms of brick and 7 kilograms of mortar. These are below the cutoff requirements of input materials (5 percent of the mass of the functional unit), thus for this reason it is conserva- tive to assume that the processes further upstream can be excluded from the LCA (that is, brick or mortar production or transportation). A baseline of $100 is used for the cost of the stove. The equivalent annual capital cost of the stove is calculated based on the 20-year lifetime and a 10 percent discount rate. The stove is built on-site, and thus transportation of the stove is not required. Cooking: Biochar and Rice Wafer Production The rice husk feedstock is purchased by the rice wafer-producing family in 200- liter mesh bags and is transported approximately 5 kilometers via bullock cart from the rice mill to the home. The rice wafer stove is operated continuously over a 10–12-hour period. The rice husk feedstock is poured into a hopper, and the biochar is manually raked out approximately every hour. The biochar is wet by the stove user to prevent autoignition and then bagged. After the biochar is wet, it is put into the same bags it came in. One 200-liter bag of rice husk lasts about three hours, thus approximately four bags of rice husk are consumed per day, or 26 tonnes per year. About one 200-liter bag of biochar is produced from five to six bags of rice husks. The biochar yield is 35 percent by dry weight.16 Rice husk biochar has very low density, at 0.15 grams per cubic centimeter (Haefele et al. 2009). The moisture content of the wet biochar is approximately 40 percent on a wet basis,17 and 0.7 liters of water is used to wet 1 kilogram of dry biochar. Thus, a 200-liter bag of wet biochar weighs about 50 kilograms. The rice wafer-producing family sells the bag of biochar for 4,000 VND ($0.18). This corresponds to $3.64 per wet tonne of biochar, or $6.06 per dry tonne of biochar. Emissions Data Emissions measurements for the rice wafer stove have not been conducted at this stage. Project contacts and photographs indicate that the stove is flued outside the building and exhibits smokeless operation. Because of the lack of stove-spe- cific data, emissions are calculated based on experimental data from a Mayon Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 101 Figure 5.9 Mayon Turbo Rice Hull Stove Source: MacCarty et al. 2007. Turbo rice hull stove (MacCarty et al. 2007), as in figure 5.9. This stove does not have a flue, and is of quite different construction from the Vietnamese rice wafer stove. MacCarty et al. (2007) compared six stoves, and found a correlation in emission ratios and species with feedstock type. For this reason rice hull-specific data are used. The stove emissions are assessed in the sensitivity analysis. The emissions calculations utilize the MacCarty et al. 2007 emission ratios of carbon dioxide and products of incomplete combustion, similar to the methodology in Whitman et al. 2011 and for the Kenya cookstove case study. Because the biochar and cooking energy yields of the rice wafer stove are likely different than the Mayon Turbo stove, the amount of carbon emitted to the atmosphere is also likely different. Therefore, the amount of carbon diox- ide emitted is calculated as in equation (5.2), from a modified version of equation (5.1): CO2 = Ce / [XCO + [(CO:CO2)*XCO + (CH4:CO2)*XCH + (EC:CO2)*XEC + 2 4 (OC:CO2)*XOC + (NMHC:CO2)*XNMHC + (CH2O:CO2)*XCH2O]](5.2) Where Ce is carbon emitted, XY is the molar mass ratio of carbon to com- pound Y, CO:CO2 is the mass ratio of CO to carbon dioxide, EC is elemental carbon, OC is organic carbon, NMHC is nonmethane hydrocarbons, and CH2O is formaldehyde. As 40 percent of the biochar is carbon by weight, then for each tonne of rice husk feedstock 121 kilograms of carbon is in the biochar and 279 kilograms of carbon is emitted, meaning that 30 percent of the carbon is retained in the biochar during cooking. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 102 Life-Cycle Assessment of Existing Biochar Systems Table 5.5  Calculated Air Emissions from Rice Wafer Stove per Tonne of Biochar Produced Emissions (kg per tonne of biochar) Carbon dioxide 2.59 Carbon monoxide 0.28 Methane 0.0068 Elemental carbon 0.0010 Organic carbon 0.0018 Nonmethane hydrocarbons 0.0105 Formaldehyde 0.0018 Nitrous oxide 0.0003 Nitrogen oxides 0.0022 Source: World Bank. Unfortunately, the MacCarty et al. (2007) study was unable to measure the elemental carbon and organic carbon emissions for the Mayon Turbo stove, but provides emission factors for elemental and organic carbon for five other stoves (three-stone fire, rocket stove, Karve gasifier, Philips prototype fan stove, and jiko charcoal stove). The average emissions of elemental and organic carbon from these other stoves are used. From equation (5.2) and the emission ratios from MacCarty et al. 2007, the baseline emissions data are calculated as in table 5.5. Economic Allocation of Impacts Associated with Cooking vs. Biochar Production In order to differentiate between the impacts associated with biochar production and those from rice wafer production, economic allocation is used to weight the appropriate upstream impacts, calculated in the following manner. Each rice wafer takes approximately 30 seconds to cook. Cooking for 12 hours per day at 80 percent capacity, approximately 1,152 wafers per day are made. The value of each rice wafer is 500 VND,18 or $0.02. Thus, the value of rice wafers produced is about $26.18 per day. The biochar value per day is $0.13, using a biochar price of 4,000 VND per bag, or $3.64 per tonne of wet biochar and assuming the biochar is sold by wet weight. The total income per day per stove is $26.31. The value of the biochar is 0.6 percent of the total value, while the rice wafers are 99.4 percent of the total. Therefore, less than 1 percent of the economic and GHG impacts of the following upstream processes are included in the LCA: cooking, stove construction, rice husk feedstock, and avoided rice husk burning. Transport The approximate cost to transport goods (the rice husk mesh bags or the bagged biochar) by bullock cart is 40,000–50,000 VND per tonne per kilometer.19 A median value of $2.05 per tonne-kilometer is used. No environmental impacts are associated with using the bullock cart. Biochar Soil Application On the peanut farms, the biochar was applied two times, at a rate of 10 tonnes of wet biochar per hectare, for a total application of 20 tonnes of wet biochar per Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 103 hectare.20 Assuming a 40 percent moisture content (wet basis),21 this corresponds to 12 tonnes of dry biochar per hectare. Using an average carbon content of rice husk biochar of 40 percent (Haefele et al. 2009; Slavich et al. 2010), the applica- tion rate is equivalent to 4.8 tonnes of carbon per hectare. The biochar is applied by hand, as no machinery is available for this purpose. The difference in labor costs between the biochar-amended plots and the nonbiochar-amended plots is calculated based on the difference in labor required for weeding, irrigating, and fertilizing.22 For the biochar-amended plots, less labor is required for weeding and irrigation (savings of $19 and $13 per hectare, respectively), while more labor is required for fertilizing (cost of $3 per hectare to apply the biochar). The labor is estimated at 60,000 VND per hour, or $2.72 per hour. Thus, the net labor comes to −$30 per hectare, or −$1 per tonne of dry feedstock. Carbon in the Biochar The rice husk biochar has an average carbon content of 40 percent by weight (Haefele et al. 2009). Similar to the Kenya cookstove case study, the baseline analysis uses a conservative estimate of 80 percent recalcitrant carbon (Baldock and Smernik 2002; Lehmann et al. 2009), and the remaining 20 percent of the carbon is emitted as carbon dioxide in the short term. Biochar Effect on Peanut Productivity Peanut crops are grown twice per year in the study region. There have been three biochar trials on peanut crops, and the fourth crop trial is in progress. The experi- ment is laid out in a random complete block design with three replicates, a plot size of 10 square meters (2 meters × 5 meters), and plant density of 40 plants per square meter. Yield data for two of these crops (the two crops from 2009) are available for the project. The eight treatments were: no amendments, manure, NPK (nitrogen, phosphorus, and potassium) fertilizer, manure + NPK, biochar only, biochar + manure, biochar + NPK, and biochar + manure + NPK. The yield data provided by Slavich et al. (2010)23 are presented in table 5.6. The manure application rate is 5 tonnes per hectare and the biochar application rate is 20 tonnes of wet biochar per hectare. These were not varied either in combination or individual applications. The fertilizer is applied at 30 kilograms of nitrogen per hectare, 26 kilograms of phosphorus per hectare, and 75 kilograms of potassium per hectare, in the form of urea, superphosphate, and potassium chloride, respec- tively (Slavich et al. 2010).24 According to the data available thus far and correspondence with the project contacts, the highest yield treatment is with the biochar + manure + NPK, with almost as much benefit from biochar + NPK.25 The value of manure is being questioned as it is very expensive, and the results indicate that the biochar could substitute for the manure. According to Tam,26 farmers can afford the full fertil- ization (see table 5.9 for prices). Thus, in deciding which treatments to utilize for the baseline scenario, correspondence with the project contacts has indicated that farmers would continue the NPK fertilization and potentially replace the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 104 Life-Cycle Assessment of Existing Biochar Systems Table 5.6  Peanut Yield Data for Different Treatments Peanut yield (tonnes per hectare) Treatment Crop 1 Crop 2 Average None 1.17 0.99 1.08 Biochar 1.51 1.66 1.59 NPK 1.68 1.53 1.61 Biochar + NPK 2.21 1.88 2.05 Manure 1.38 1.58 1.48 Biochar + manure 1.79 1.66 1.73 Manure + NPK 1.93 1.60 1.77 Biochar + NPK + manure 2.57 2.00 2.29 Sources: Slavich et al. 2010; P. Slavich, survey response, 2010. Note: NPK = nitrogen, phosphorus, and potassium (fertilizer). manure with biochar, which is less expensive and results thus far show it to be longer lasting.27 Thus, the control yield for the LCA is the manure + NPK treat- ment (1.77 tonnes per hectare), and the baseline yield used is the biochar + NPK treatment (2.05 tonnes per hectare), highlighted grey in table 5.6. The difference between the manure + NPK control treatment and the biochar + NPK baseline treatment is statistically significant, where this difference is 0.28 tonnes per hect- are, or a 16% yield increase. The sensitivity analysis considers a range in crop yield effect from −50% to +47%, which allows for exploring the variability in the extent of the preexisting soil degradation, farmer practices, weather conditions, and fertilization rates. The maximum value of +47% increase is based on the statistically significant difference between the no amendment and biochar only treatments. The surplus peanuts would likely be sold on the market. The price of peanuts is between 15,000 and 18,000 VND per tonne.28 The median value of 16,500 VND, or $750 per tonne, is used for the baseline, and the sensitivity analysis explores this range. Duration of Biochar’s Agronomic Effect The interior floodplains and the coastal zone have very sandy soils, which result in poor nutrient and water retention. The heavy rains in the wet season leach nutrients, while in the dry season the sand does not hold sufficient water and nutrient uptake is also restricted by a lack of adequate water. Preliminary results have found that biochar’s water-holding capacity is 2 grams per gram, while the sandy soil alone is only 0.1 grams per gram.29 Although data are not yet available, correspondence with project contacts has indicated that the soil constraints that the biochar addresses are the water- and nutrient-holding capacities, both of which are expected to be long-term effects and last for the lifetime of the biochar in the soil. As discussed for the Kenya case study, the duration of biochar’s effect on soil properties and crop productivity is an important parameter in quantifying Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 105 the life-cycle impacts of biochar production and use. The baseline scenario esti- mates a 50-year agronomic effect for the applied biochar, while a “per crop” effect is also considered. The sensitivity analysis investigates this aspect further. Soil Organic Carbon from Residue Removal Although the removal of crop residues such as corn stover, rice straw, and rice husks would decrease soil organic carbon on the field from which they were removed, this soil organic carbon depletion is not included in this case study because of the nature of the feedstock. Even without rice wafer cooking or biochar production, the rice husks would be removed from the field with the rice grain. Soil Organic Carbon from Increased Productivity No data were available on changes in soil organic carbon from peanut crop resi- dues. For this reason, the soil organic carbon to crop residue ratio for corn stover is used (as described in the Kenya case study). This estimate of the annual increase in soil organic carbon with stover left on the field is 0.01 tonnes of car- bon per tonne of residue. Field measurements from the project demonstrate the difference in aboveground biomass with the different treatments (table 5.7).30 It is common practice in the project region to remove the aboveground residues after the peanut harvest and use these for animal feed. For this reason, changes in soil organic carbon are assumed to come only from increases in belowground biomass. An average root to shoot ratio of 0.52 for Virginia-type peanuts (Huang and Ketring 1987) is used to estimate the change in belowground biomass. Similar to the change in crop productivity, the baseline scenario assumes the biochar + NPK treatment, as compared to the manure + NPK treatment (both highlighted grey in table 5.7). From the calculated belowground biomass, the increase in belowground residue yield between these two treatments is +0.23 tonnes per hectare per peanut crop. Using the 0.01 tonnes of carbon per tonne of residue rate, then it is estimated that +0.0023 tonnes of carbon per hectare is accumulated as soil organic carbon per peanut crop with the biochar + NPK Table 5.7  Aboveground Biomass Residue Yield per Peanut Crop Total aboveground biomass ­ Treatment (tonnes dry matter/hectare) None 2.46 Biochar 3.56 NPK 3.33 Biochar + NPK 4.00 Manure 3.18 Biochar + manure 3.63 Manure + NPK 3.56 Biochar + NPK + manure 4.59 Source: Data from H.M. Tam, personal communication, 2011. Note: The total is the sum of the pod and aboveground biomass. NPK = nitrogen, phosphorus, and potassium (fertilizer). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 106 Life-Cycle Assessment of Existing Biochar Systems scenario. For two peanut crops per year and a 50-year biochar effect, the soil organic carbon contributes −70 kilograms of CO2e per tonne of dry biochar in GHG reductions. Avoided Manure The GHG impacts of manure production are not included because the manure is produced regardless of biochar application. However, the avoided cost of the manure is included, as well as the avoided transportation costs of the manure. The price of manure in the region is around $18–23 per tonne, where the median value in this range is used. The avoided manure transportation is assumed to be 5 kilometers. Fertilizer Use Efficiency Measurements have been made on the nitrogen, phosphorus, and potassium uptake for all eight treatments. Results from the biochar + NPK and NPK only treatments are shown in table 5.8. Differences in NPK and biochar treatments are statistically significant for phosphorus and potassium uptake (p = 0.029 and 0.001, respectively), but not for nitrogen uptake. Therefore, the LCA considers the effect of improved fertilizer use efficiency with biochar additions for phos- phorus and potassium only, where the uptake increases by 17.2 percent and 22.0 percent, respectively, for the biochar + NPK treatment as compared to the appli- cation of fertilizer alone. Literature values for improved fertilizer uptake are dependent on the crop, soil type, fertilizer application rate, and biochar applica- tion rate, but improved uptake values of up to 74 percent have been found for nitrogen when biochar was applied (Chan et al. 2007; van Zwieten, Kimber, Downie et al. 2010). As the farmers use full fertilization, it is assumed that the improved nutrient uptake and fertilizer use efficiency means less chemical Table 5.8  Nitrogen, Phosphorus, and Potassium Uptake of Peanuts as Result of Mineral Fertilizer Applications of NPK Nutrient uptake (kilograms per hectare) Difference NPK + biochar NPK only (%) Nitrogen 22.8 20.1 9.0 Phosphorus 15.1 10.6 17.2 Potassium 38.8 22.4 22.0 Nutrient recovery (%) Nitrogen 76.0 67.0 Phosphorus 57.7 40.5 Potassium 51.9 30.0 Source: H.M. Tam, personal communication and unpublished data, 2011. Note: Table shows nitrogen, phosphorus, and potassium uptake of peanuts as a result of mineral fertilizer applications of NPK at 30, 26, and 75 kilograms per hectare, respectively; recovery is calculated on a mass base in comparison to no additions of NPK. Differences in NPK and biochar treatments are statistically significant for phosphorus and potassium uptake. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 107 Table 5.9  Fertilizer Prices in Vietnam Fertilizer Price (VND per kg) Price Unit Urea 9,500 0.43 $ per kg urea 46-0-0 0.94 $ per kg nitrogen Superphosphate 2,500 0.11 $ per kg superphosphate 0-18-0 0.63 $ per kg phosphorus Potassium chloride (KCl) 11,000 0.50 $ per kg KCl 0-0-60 0.83 $ per kg potassium Source: H.M. Tam, personal communication and unpublished data, 2011. Note: VND = Vietnamese dong. fertilizer need be applied to obtain the same yields. Thus, with biochar applica- tion, there are 17.2 percent and 22.0 percent savings in phosphorus and potas- sium, respectively. Soil Nitrous Oxide and Methane Emissions Similar to the Kenya case study, the baseline scenario of this analysis assumes that there are no changes in soil nitrous oxide or methane emissions with biochar application, because of the lack of site-specific data. However, the sensitivity analysis considers a range of +50% to –50% for the effect of biochar application on soil nitrous oxide emissions. (See the Kenya case study and the section titled “Impacts on Climate Change” in chapter 3 for further discussion on soil nitrous oxide emissions.) NPK Fertilizer The NPK fertilizer application rates are as in table 5.8. Data on the production of NPK fertilizers used in Vietnam were not available. Therefore, as a baseline, U.S. data are used, taken from the Greenhouse Gases, Regulated Emissions, and Energy Use in Transportation (GREET) 1.8b model (Wang 2007). However, due to lack of data, the transportation of these fertilizers to the field is not included. The fertilizer prices are as listed in table 5.9. If transportation of the fertilizers was included, the GHG reductions and monetary savings would be further increased. Results and Discussion Table 5.10 lists the result vector for the Vietnam rice husk biochar system. The net GHG balance is –0.5 tonnes of CO2e per tonne of dry rice husk, as illustrated in figure 5.10. The net economic balance is +$948 per tonne of dry matter for the 50-year biochar effect. The majority of both the GHG emissions and reduc- tions are from carbon dioxide, with much smaller contributions from methane and nitrous oxide (table 5.10). The surplus peanuts from biochar additions are 0.82 tonnes of peanuts per tonne of dry matter over the 50 years of biochar’s effect on crop yields, or 16 kilograms of surplus peanuts per year. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 108 Life-Cycle Assessment of Existing Biochar Systems Table 5.10  Result Vector for Vietnam Rice Husk Biochar System Baseline Scenario, per Tonne of Dry Rice Husk Feedstock Input/output Value Unit Methane –0.13 kg Nitrous oxide –0.01 kg Carbon dioxide –509 kg Stable carbon 113 kg Net CO2e –512 kg Revenue +957 $ Cost –9 $ Net $ +948 $ Surplus peanuts 0.82 tonne Source: World Bank. Note: For methane, nitrous oxide, and carbon dioxide, a negative sign corresponds to avoided emissions or sequestration, while a positive value indicates emissions. Negative $ are costs, and positive $ are net revenues. The bold type indicates the net GHG and economic balances. CO2e = carbon dioxide equivalent. Looking at the contribution analysis in figure 5.10, the largest source of reduced GHG emissions is the stable carbon in the biochar, at –0.4 tonnes of CO2e per tonne of dry matter, or 81 percent of the total GHG reductions. The next largest amount of GHG reductions is from the avoided phosphorus and potassium fertilizer production, at 0.07 tonnes of CO2e per tonne of dry matter, or 14 percent of GHG reductions. Soil organic carbon accumulation from increased belowground biomass contributes 5 percent to the GHG reductions, followed by the avoided rice husk burning at less than 1 percent. The only GHG emissions occur during rice wafer cooking and biochar production, which are very small compared to the net GHG balance (less than 1 percent). Another important aspect included in the analysis but not represented in figure 5.10 is that all of the rice husk feedstock is assumed to be renewable. Thus, only non- carbon dioxide GHG emissions are included in the stove emissions as these are assumed to not otherwise occur, whereas the carbon dioxide emissions are can- celled out by the uptake of carbon dioxide by the renewable feedstock carbon dioxide. If the feedstock were nonrenewable, then both carbon dioxide and non- carbon dioxide GHG would be included. The contributions of the avoided rice husk burning and stove emissions to the net GHG balance are determined by the percentage allocation of these upstream processes. If the allocation for upstream processes is increased from 0.5 percent to 100 percent, the contribution analysis is as in figure 5.11. The GHG reduc- tions increase to a net balance of –0.6 tonnes of CO2e per tonne of dry matter. The contribution of the avoided burning is raised from –0.6 kilograms to –104 kilograms of CO2e per tonne of dry matter, while the stove emissions increase from 0.5 kilograms to 9 kilograms of CO2e per tonne of dry matter. The –0.5 tonnes of CO2e per tonne of dry matter obtained for the Vietnam rice husk biochar system is on the lower end compared to other life-cycle studies of different biochar systems in both developed and developing countries. Hammond Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 109 Figure 5.10  Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam – Emissions/reductions Net = –0.5 + 0 0.1 0.2 0.3 0.4 0.5 0.6 GHG (t CO2e t–1 DM) Stable C in biochar SOC NPK fertilizer Avoided burning Stove emissions Source: World Bank. Note: The upper bar (–) represents the GHG reductions, the lower bar (+) is GHG emissions, and the difference represents the net GHG balance of the system. C = carbon; SOC = soil organic compound; NPK = nitrogen, phosphorus, and potassium (fertilizer); GHG = greenhouse gas; CO2e = carbon dioxide equivalent. et al. (2011) obtained 0.7–1.3 tonnes of CO2e per oven dry tonne of feedstock for slow pyrolysis biochar systems in the United Kingdom for small-, medium-, and large-scale process chains and 10 different feedstocks. Karve et al. (2011) found 0.9 tonnes of CO2e per tonne of feedstock when assessing carbonized rice husks through gasification systems in Cambodia. Meanwhile, 0.8–0.9 tonnes of CO2e per tonne of dry matter was found for crop residue and yard waste feedstocks for a large-scale pyrolysis system in the United States (Roberts et al. 2010). The economic contribution analysis is presented in figure 5.12a for the base- line scenario of a 50-year biochar effect. The dry tonne of rice husk feedstock for biochar production and soil application results in $948 over the 50 years of biochar’s agronomic effect. The majority of the revenue (75 percent) is from sales of surplus peanuts, while avoided manure use also contributes a significant portion (19 percent). Reduced phosphorus and potassium fertilizer needs, avoided transportation costs, and the biochar value contribute 5 percent, 1 per- cent, and 0.2 percent, respectively. In the figure, the transportation costs of the feedstock, biochar, and manure are aggregated, so that only the net transportation cost is represented, which is a revenue, because the avoided manure Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 110 Life-Cycle Assessment of Existing Biochar Systems Figure 5.11 Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam with 100 Percent Allocation for Rice Wafer Stove and Upstream Impacts – Emissions / reductions Net = –0.6 + 0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 GHG (t CO2e t–1 DM) Stable C in biochar SOC NPK fertilizer Avoided burning Stove emissions Source: World Bank. Note: The upper bar (–) represents the GHG reductions, the lower bar (+) is GHG emissions, and the difference represents the net GHG balance of the system. C = carbon; SOC = soil organic compound; NPK = nitrogen, phosphorus, and potassium (fertilizer); GHG = greenhouse gas; CO2e = carbon dioxide equivalent. transportation revenue is higher than the feedstock and biochar transportation costs. The costs of the rice wafer feedstock and stove are small, again because of the economic allocation. If these impacts were allocated at 100 percent of bio- char production, then the rice husk cost increases from $0.09 to $17 per tonne of dry matter and the stove from $0.002 to $0.40 per tonne of dry matter, for a net balance of $918 per tonne of dry matter. A biochar “payback period” provides an estimate of the number of years it would take biochar used as a soil amendment to pay for itself. The payback period is calculated assuming the baseline price of peanuts, and is achieved in the first cropping season. For a one-crop biochar effect, the results are presented in figure 5.12b. With the peanut surplus per crop only $7 per tonne of dry matter, the scale on the x-axis is greatly reduced. The transportation cost of the biochar becomes more apparent (–$6 per tonne of dry matter), and the avoided manure transport cost is minimal. The revenues from avoided manure and fertilizer are also decreased. There is a distinction between the net revenue per functional unit and the net revenue for the farmer (table 5.11). For the farmer, the cost of the biochar incor- porates the cost of the feedstock, the stove construction, and the biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 111 Figure 5.12  Contribution Analysis for Net Economic Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Vietnam + Cost / revenue 50-yr biochar effect Net = +$948 – 0 200 400 600 800 1,000 $ t–1 DM + Cost / revenue 1- crop biochar effect Net = $7 – 0 2 4 6 8 10 12 14 $ t–1 DM Rice husk cost Stove construction Surplus peanuts Avoided manure NPK fertilizer Transport Biochar price Source: World Bank. Note: Figure 5.12a represents the baseline scenario, where biochar is assumed to have a 50-year agronomic effect; 5.12b is a scenario where biochar has only a one-crop effect. The upper bar (–) represents the revenues, the lower bar (+) is costs, and the difference represents the net economic balance of the system. NPK = nitrogen, phosphorus, and potassium (fertilizer). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 112 Life-Cycle Assessment of Existing Biochar Systems Table 5.11  Comparison of Net Revenue between LCA Functional Unit and Farmer Costs and revenues ($ per tonne of dry matter) Functional unit Farmer Feedstock –0.09 Stove construction –0.002 Biochar 2.14 –2.14 Surplus crops 704.72 704.72 Avoided manure 180.58 180.58 Rice husk transport –0.06 –0.06 Biochar transport –6.01 –6.01 Avoided manure transport 18.02 18.02 Avoided fertilizer 48.47 48.47 Total 947.75 943.59 Source: World Bank. production, whereas for the functional unit, the biochar product is actually a revenue that offsets the cost of the stove, feedstock, and production. The other revenues from surplus crop sales, avoided manure and fertilizer inputs, and avoided transportation are the same per functional unit and per farmer. The dif- ference in this case study is small ($4) because of the low cost of the biochar. However, in the case with a higher cost for biochar (and dependent on the specif- ics of the system under study), the economic balance per functional unit would be that much higher than for the farmer. In this project, carbon credits are not received, but the farmer could poten- tially return an additional $13–15 per tonne of feedstock for a one-crop or 50-year effect and depending on whether only the stable carbon in the biochar or the life-cycle emission reductions receives offset credits. There is only a small difference in carbon credits between these scenarios because the GHG balance is dominated by the stable carbon in the biochar. The $948 per tonne of dry matter achieved for the Vietnam rice husk biochar system is significantly higher than results from Roberts et al. (2010), where the most economically promising large-scale U.S.-based biochar system calculated in the analysis was yard waste at $69 per tonne of dry matter, which includes car- bon offsets of $80 per tonne of CO2e. However, the U.S. example assumed no increased crop productivity with biochar amendments, and only a one-crop bio- char effect on maize yield. If there is no effect of biochar on the crop yields, then there are no surplus peanuts and thus no revenues are made from the sales of surplus peanuts. However, benefits from avoided manure and reduced fertilizer inputs could still be realized. Sensitivity Analysis A sensitivity analysis was conducted in order to measure the variability in the LCA results as a function of varying key input parameters (table 5.12). The input Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 113 Table 5.12  Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Biomass throughput (tonnes of dry matter per year) 26 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) +16 –50 to +47 Peanut prices ($ per tonne) 750 682–818 Rice wafer stove methane emissions (kilograms per 2.24 1.64–6.4 tonne of dry matter) Avoided rice husk burning methane emissions 3.71 3.71–25.7 (kg per tonne of dry matter) Duration of biochar’s effect (years) 50 1–100 Biochar transportation distance (km) 5 1–25 Soil nitrous oxide emissions (%) 0 –50 to +50 Source: World Bank. parameters that were tested were the fraction of recalcitrant carbon in the bio- char, the yield response of peanut crops with biochar additions, the price the farmer receives for peanuts, methane emissions of the rice wafer stove, methane emissions from avoided rice husk burning, the duration of biochar’s agronomic emissions. effectiveness, the biochar transportation distance, and soil nitrous oxide ­ The detailed sensitivity analysis is presented in appendix B, while a summary of the sensitivity analysis results is presented below. The GHG balance is relatively insensitive (less than about 1 percent vari- ability) to the rice wafer stove methane emissions, the rice husk-burning methane emissions, and the crop yield response with biochar additions. Within the realistic range of 50–90 percent, the fraction of the stable carbon Figure 5.13  Sensitivity Analysis for Net GHG per Tonne of Dry Feedstock for Biochar System in Vietnam a. Stove CH4 emissions (kg CH4 t–2 fuel) b. Soil N2O emissions (% change from baseline) 0.0 1.0 2.0 3.0 4.0 5.0 6.0 7.0 –60 –40 –20 0 20 40 60 150 GHG (% change from baseline) GHG (% change from baseline) 10 100 –10 50 –30 0 –50 –50 –70 –100 –90 –150 0 20 40 60 80 100 0 20 40 60 80 100 120 Stable carbon fraction, % Duration of biochar effect, years Stability Stove CH4 emissions Biochar effect Soil N2O emissions Source: World Bank. Note: Figure 5.13a compares the fraction of stable carbon in the biochar to the rice wafer stove methane emissions; 5.13b illustrates the duration of biochar’s agronomic effect and soil nitrous oxide emissions (nitrous oxide emissions range chosen according to extreme values available in the literature, see text). CH4 = methane; N2O = nitrous oxide; GHG = greenhouse gas. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 114 Life-Cycle Assessment of Existing Biochar Systems Figure 5.14  Sensitivity Analysis for Net Economic Balance per Tonne of Dry Feedstock for Biochar System in Vietnam a. Peanut price ($ t–1) b. Duration of biochar effect, year $640 $680 $720 $760 $800 $840 0 20 40 60 80 100 120 Net revenue (% change from baseline) Net revenue (% change from baseline) 8 150 6 100 50 4 0 2 50 0 100 –2 150 –4 200 –6 250 –8 300 0 5 10 15 20 25 30 –60 –40 –20 0 20 40 60 Biochar transport distance, km Crop yield (% change from control) Biochar transport Peanut price Crop yield Biochar effect Source: World Bank. Note: Figure 5.14a compares the biochar transportation distance to peanut prices; 5.14b illustrates the variation in the crop yield and the duration of biochar’s agronomic effect. in the biochar influences the net GHG balance by up to a 29 percent change from the baseline. Meanwhile, the GHG balance is most sensitive to the dura- tion of biochar’s effect (40 percent), and soil nitrous oxide emissions (100 percent). Figure 5.13 demonstrates that the net GHG balance for the Vietnam case study is most sensitive to the soil nitrous oxide emissions, fol- lowed by fraction of stable carbon in the biochar and the duration of bio- char’s effect, while the methane emissions during cooking have very little impact on the GHG balance. Significant effects on the net economic balance are found within the range tested for the duration of biochar’s agronomic effect (100 percent) and the crop yield response (260 percent), while the peanut price (6 percent) and biochar transportation distance (3 percent) have relatively small impacts. Figure 5.14 illustrates this variability, where it is evident that the crop yield response due to biochar additions, followed by the duration of biochar’s effect, have the largest impact on the net economics. Meanwhile, the peanut price and the biochar transportation distance play only a small role in the economics of the system. More details on the sensitivity analysis can be found in appendix B. Additional Considerations Rice husk charcoal is currently used in traditional farming methods in some regions of Vietnam, thus there appears to be minimal cultural barriers to adop- tion of using biochar as a soil amendment. In addition, although quantitative data are not yet available, there is evidence of reduced irrigation needs on bio- char-amended peanut plots as well. Reducing watering requirements is very important in this region of Vietnam, and is one of the primary goals of the over- arching project. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 115 Box 5.3 Summary of Vietnam Case Study The Vietnam rice husk biochar system has potential for climate change adaptation and miti- gation through carbon sequestration and GHG emission reductions, while also being eco- nomically viable for the smallholder farmer. The net GHG reductions are −0.5 tonnes of CO2e per tonne of dry rice husk feedstock. The net economic balance is +$948 per tonne of dry matter over the 50 years of biochar’s agronomic effect, or +$7 for a one-crop effect. In this project, carbon credits are not received, but the farmer could potentially return an additional $15 per tonne of feedstock with emissions trading at a price of $19 per tonne of CO2e. The contribution analysis reveals that the net GHG balance is largely (81 percent) driven by the stable carbon in the biochar, assuming that the rice husk remains a sustainable feed- stock. Reduced fertilizer needs and soil carbon accumulation play lesser roles in the GHG balance. Soil nitrous oxide emissions could also play an important role in the GHG balance, thus more data are required to quantify this effect. The sensitivity analysis reveals that the net GHG balance is relatively insensitive to chang- es in methane emissions during rice wafer cooking and avoided rice husk burning, the crop yield response with biochar additions, and the duration of biochar’s agronomic effect, within the realistic range tested for these parameters. The net revenues are very sensitive to the crop yield response and the duration of biochar’s agronomic effect, while the relative impact of the transportation distance of the biochar is less. This Vietnam rice husk biochar system presents itself as a low-risk biochar project with climate change adaptation and economic benefits for the smallholder farmers incorporating biochar into their practices. Senegal Case Study Life-Cycle Assessment System Overview The project is implemented by Pro-Natura International in Ross Bethio, Senegal. Charcoal and biochar are produced by a village-scale pyrolysis unit, the Pyro-6F, a continuous operation system. The original intent of the Pyro-6F was to produce “green charcoal,” a renewable and cleanly produced fuel for household cooking. However, a growing interest in biochar as a soil amendment has increased the ratio of biochar to green charcoal production. The feedstock is rice husks obtained from a nearby rice mill, which would otherwise decay in piles. The biochar is purchased by farmers, and applied to onion, rice, and maize crops at a rate of 10 tonnes per hectare on farms in the area. The case study uses data from onions, as the onion data are the most mature at this time. Methodology Function, Functional Unit, and Reference Flows For the Senegal case study, biochar production is a multioutput system with up to three coproducts: biomass management, soil amendment, and carbon seques- tration. The functional unit of the system is 1 tonne of dry rice husk that is used as a feedstock at the pyrolysis unit, and the subsequent biochar is applied to onion fields on a farm in Senegal. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 116 Life-Cycle Assessment of Existing Biochar Systems Figure 5.15  Schematic Flow Diagram for Rice Husk Biochar to Onion Production System in Senegal Soil application Recalcitrant carbon Air emissions Onion Rice husk, at mill yield Labile carbon Rice husk Pyrolysis Biochar Crop response feedstock Avoided soil Pyro unit Avoided rice nitrous oxide Duration of SOC construction, husk decay emissions biochar’seffect accumulation transportation, and operation Overall system boundary Process module Subprocess including monetary or labor inputs Subprocess within module Subprocess included only in the sensitivity analysis Source: World Bank. Note: SOC = soilorganic compound. System Boundaries A flow diagram of the biochar system is illustrated in figure 5.15. The system is organized into four modules: feedstock, pyrolysis, biochar, and crop response, each of which has multiple subprocesses. Because the rice husk feedstock is a residue from the operation of an estab- lished rice mill, the production of the feedstock is considered a by-product and therefore no environmental burdens are associated with its generation (except for those impacts that would not otherwise occur in conventional management). However, if not utilized, the rice husk is piled up and left to decay. Thus, the avoided rice husk decay is included. Under the pyrolysis module, the production and transportation of the unit are accounted for. During the operation of the unit, pyrolysis, labor and input requirements, and air emissions are included. The biochar is transported and applied to soils by hand. The behavior of biochar in soils is described by the sta- bility of the carbon in the biochar. The recalcitrant and labile carbon fractions are included in the biochar module. The crop response upon biochar application is compared to yields for control crops. The effect of biochar on soil nitrous oxide emissions illustrated in the flow diagram is not in the baseline scenario but included in the sensitivity analysis. The system expansion method is used for modeling avoided rice husk decay. Status of the Project The Pyro-6F is an established system in Senegal and has been in operation by Pro-Natura since 2008, primarily making green charcoal. That same year, Pro- Natura launched a pilot project that provides biochar, training, and financial incentives to local farmers to facilitate the adoption of new sustainable agricul- tural practices based on biochar and organic fertilizers. The first biochar trials on vegetables showed encouraging results, and Pro-Natura has begun expanding tri- als to maize and rice on a larger scale. In addition, Pro-Natura has been working Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 117 with Air France, through the intermediary of the Action Carbone program of the nongovernmental organization (NGO) GoodPlanet, to offer Air France passen- gers the option to compensate their carbon dioxide emissions with carbon credits generated primarily by the Pro-Natura green charcoal project in Senegal. Life-Cycle Inventory Rice Husk Feedstock The project contacts state that rice hulls at mills are piled up outside the mill and left to decay. This allows a year-round supply of feedstock at no cost.31 Thus, this LCA assumes that if the pyrolysis unit were not using the rice husks, then the rice husks would decay. Utilizing the rice husk as a fuel is also a waste manage- ment strategy. Avoided Rice Husk Decay Rice husks not utilized are piled up at rice mills and ultimately left to decay as a waste management strategy. The avoided methane emissions due to rice husk decay are calculated based on the Clean Development Mechanism (CDM) approved methodology for small-scale CDM project activities, category AMS- III.E, “Avoidance of methane production from decay of biomass through con- trolled combustion, gasification or mechanical/thermal treatment” (UNFCCC 2010). Because the rice husk is a waste stockpile, equation (5.3) in the CDM “Tool to determine methane emissions avoided from disposal of waste at a solid waste disposal site” is adjusted. The equation is as follows: BE = φ · (1 – f  ) · GWP · (1 – OX  ) · CF · F · DOCf · MCF · W · DOC · e– k(y – x) · (1– e – k) (5.3) Where φ is the model correction factor to account for model uncertainties (0.9), f is the fraction of methane captured and flared, combusted, or used in another manner (0), GWP is the global warming potential of methane (25), OX is the oxidation factor for the amount of methane oxidized in the soil or material covering the waste (0), CF is the molecular weight of methane rela- tive to carbon (16/12), F is the fraction of methane in the gas (0.5), DOCf is the fraction of degradable organic carbon than can decompose (0.5), W is the amount of organic waste prevented from disposal in the pile in the year x (1,388 tonnes), DOC is the fraction of degradable organic carbon by weight in the waste (0.4), k is the decay rate for the waste (0.01), x is the year during the crediting period (1), and y is the year for which methane emissions are calculated (2). Values from chapter 3, volume 5 of the 2006 IPCC Guidelines for National Greenhouse Gas Inventories (IPCC 2006) and the CDM III.E methodology are used for φ, f, OX, F, and DOCf. Both MCF and k are adapted for stockpiles of homogeneous wastes, at 0.284 and 0.01, respectively. W is calculated based on the approximate quantity of rice husk feedstock utilized by the Pyro-6F for biochar production per year. The result is that BE is cal- culated to be 11.5 tonnes of CO2e per year, or 8.3 kilograms of CO2e per tonne dry rice husk. Thus, the emission factor is 0.33 kilograms of methane per tonne of dry matter. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 118 Life-Cycle Assessment of Existing Biochar Systems Figure 5.16  Photo and Diagram of Pyro-6F Unit Biomass Chimney Hopper Heat Biochar Green Charcoal Sources: Figure 5.16a: Image of Pyro-6F in operation in Senegal (Pro-Natura International). Figure 5.16b: Schematic of Pyro-6F (Green Charcoal International). Pyrolysis Unit Construction The Pyro-6F unit (figure 5.16) is assembled in France and shipped via truck and barge to Senegal. The construction materials are estimated to be 3 tonnes of steel.32 The GHG emissions associated with the steel production and transport are taken from the GREET 1.8b model (Wang 2007). The Pyro-6F is estimated to be in operation approximately 50 percent of the time.33 The cost of the unit is $250,630, or $361,660. The capital cost is amortized over the life of the unit, where the equivalent annual capital cost is calculated based upon a 10-year life- time and a 10 percent discount rate. The truck transportation is estimated as the distances from Paris to Le Havre, France, at 196 kilometers, and from Dakar to Ross Bethio, Senegal, at 300 kilometers. The port-to-port distance from Le Havre to Dakar is approxi- mately 4,360 kilometers.34 The cost of transporting the unit is $10,000, or $14,430.35 Biochar Production The Pyro-6F is a continuous pyrolysis furnace where the rice husk is heated to high temperature in a low-oxygen environment. The biomass is pyrolyzed into a carbon-rich material (biochar) and the gases are captured and combusted at high temperature to minimize products of incomplete combustion. The energy from combusting these gases is used to fuel the pyrolysis process.36 Once running, the pyrolysis process is self-sustaining. However, 30–40 liters of gasoil is required at the start-up of the unit, and 7 kilowatts of electricity is consumed per hour for the continuous operation of the system. The biochar is cooled without coming in direct contact with water. It is then removed from the unit and bagged in 25-kilo- gram bags. Approximately 120 kilograms of biochar are produced per hour, with a biochar yield of 38 percent. Operating at 50 percent capacity, roughly 526 tonnes of biochar are produced per year, using 1,388 tonnes dry matter of rice husks per year. The rice husk feedstock is available at no cost from a nearby rice mill (200 meters away) and is transported by donkey cart. The biochar is sold to farmers for $200 per tonne.37 Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 119 The operating cost of the Pyro-6F is estimated at $167 per year (assuming 50 percent operating capacity). This cost includes management, supervisor, opera- tors, administration, fuel, electricity, packaging, and maintenance.38 Emissions Data Emissions measurements for the Pyro-6F are not available at this stage. Because of the lack of pyrolyzer-specific data, emissions data from Brown 2009 are used for a controlled continuous charcoal kiln (table 5.13). As a conservative estimate the highest emission factors reported are used, at 8.9, 2.9, and 3.0 grams per kilogram of fuel for carbon monoxide, methane, and nonmethane hydrocarbons, respectively. As data on nitrous oxide emissions from the continuous kiln are lacking, a baseline value of 0.086 grams per kilogram of fuel is used, as calculated for the rice husk stove in the Vietnam case study. Variability in the emissions will be explored in the sensitivity analysis. Transport, Donkey Cart The cost to transport goods (the rice husk or the biochar) by donkey cart is esti- mated at $30 per tonne, from the difference in price of the biochar without transport ($200 per tonne) and biochar with transport ($230 per tonne).39 Assuming an average transportation distance from the Pyro-6F to the farm of 10 kilometers, then cost of transporting is about $3 per tonne-kilometer. No envi- ronmental impacts are associated with using the donkey cart. Biochar Soil Application The biochar was applied at a rate of 10 tonnes per hectare to onion fields.40 Using an average carbon content of rice husk biochar of 40 percent (Haefele et al. 2009), the application rate is equivalent to 4 tonnes of carbon per hectare. The biochar is applied by hand and takes the same amount of time as to prepare the field in the control, thus no additional labor requirements are included. Carbon in the Biochar The rice husk biochar has an average carbon content of 40 percent by weight (Haefele et al. 2009). The baseline analysis uses a conservative estimate of 80 percent recalcitrant carbon (Baldock and Smernik 2002; Lehmann et al. 2009), and the remaining 20 percent of the carbon is labile and emitted as carbon diox- ide in the short term. Table 5.13  Air Emissions Estimated for Pyro-6F per Tonne of Biochar Produced Emissions (kilograms per tonne of biochar) Carbon monoxide 23.5 Methane 7.7 Nonmethane hydrocarbons 7.9 Nitrous oxide 0.0003 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 120 Life-Cycle Assessment of Existing Biochar Systems Biochar Effect on Onion Productivity Onion crops are grown twice per year in the study region. There has been only one biochar trial on onion crops, while other trials for maize and rice are in devel- opment. The experiment is laid out with three replicates and a plot size of 1 meter × 5 meters. The different treatments were: • No amendments • Compost (10 tonnes per hectare) • NPK fertilizer • Compost (10 tonnes per hectare) + NPK • Biochar (5 tonnes per hectare) • Biochar (5 tonnes per hectare) + compost (10 tonnes per hectare) • Biochar (5 tonnes per hectare) + NPK • Biochar (5 tonnes per hectare) + compost (10 tonnes per hectare) + NPK • Biochar (10 tonnes per hectare) • Biochar (10 tonnes per hectare) + compost (10 tonnes per hectare) • Biochar (10 tonnes per hectare) + NPK • Biochar (10 tonnes per hectare) + compost (10 tonnes per hectare) + NPK. However, only the yield data for the biochar (10 tonnes per hectare) + com- post (10 tonnes per hectare) + NPK, and its control of compost + NPK, are available. The biochar + compost + NPK results in 18.2 tonnes of onion per hectare (fresh weight), whereas the control is 12 tonnes per hectare, which is a yield increase of 52 percent. The sensitivity analysis considers a range in crop yield effect from –50 percent to +233 percent, which allows for exploring the variability in the extent of the preexisting soil degradation, farmer practices, weather conditions, and fertiliza- tion rates. The maximum value of +233 percent increase is based on the differ- ence between the biochar + compost + NPK versus compost + NPK for maize crop trials, but only relative yield data were available and not absolute values. The surplus onions would likely be sold on the market. Few data are available for the local onion price. The estimated price the farmer receives is $287 per tonne, calculated based on a retail price of $552 per tonne in Senegal in 2002 (David-Benz, Wade, and Egg 2005) and a profit margin of 48 percent from farmer to retail (Weinberger and Pichop 2009) for African indigenous vegetables in Senegal. The sensitivity analysis explores the onion price and its impact on the net revenues of the system. Duration of Biochar’s Agronomic Effect Although data are not yet available, the LCA assumes the constraints that the biochar addresses of these sandy soils in the project region are the water- and nutrient-holding capacity, both of which are expected to be long-term effects and last for the lifetime of the biochar in the soil. As discussed in the other case studies, the duration of biochar’s effect on soil properties and crop productivity is an important parameter in quantifying the life-cycle impacts of biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 121 production and use. The baseline scenario estimates a 50-year agronomic effect for the applied biochar, while a “per crop” effect is also considered. The sensitivity analysis investigates this aspect further. Soil Organic Carbon from Residue Removal Although the removal of crop residues such as corn stover, rice straw, and rice husks would decrease soil organic carbon on the field from which they were removed, this soil organic carbon depletion is not included in the case study because of the nature of the feedstock. Even without biochar production the rice husks would be removed from the field with the rice grain. Soil Organic Carbon from Increased Productivity Data on changes in soil organic carbon from onion crop residues are unavailable at this time. For this reason, the soil organic carbon to crop residue ratio for corn stover is used (as described in the Kenya case study). This estimates that the annual increase in soil organic carbon with stover left on the field is 0.01 tonnes of carbon per tonne of residue. The LCA assumes that the aboveground residues are removed with the onion harvest, and thus changes in soil organic carbon are assumed to come only from increases in belowground biomass. An average bulb moisture content of 13 percent wet basis (Abhayawick et al. 2002), top to bulb ratio of 0.39 (Khan and Iortsuun 1989), and a shoot to root ratio of 2.81 (Azcón and Tobar 1998) are used to estimate the belowground biomass from the differ- ence in onion bulb yields with and without biochar. From this method, the increase in belowground biomass is approximately 0.40 tonnes per hectare per onion crop. Using the 0.01 tonnes of carbon per tonne of residue rate, then it is estimated that an excess of +0.0041 tonnes of carbon per hectare is accumulated as soil organic carbon per onion crop with the biochar. For two onion crops per year and a 50-year biochar effect, the soil organic carbon contributes –146 kilo- grams of CO2e per tonne of dry biochar in GHG reductions. Fossil Fuel Production and Combustion The emissions from fossil fuel production and combustion associated with truck and barge transportation, and residual oil production and combustion, are taken from the GREET 1.8b database due to lack of site-specific data (Wang 2007). The LCA assumes that the gasoil used for the Pyro-6F start-up is equivalent to residual oil from the GREET model and is combusted with similar emission factors to a utility boiler. The truck is assumed to be a class 8B diesel truck, and the barge con- sumes residual oil fuel. A gasoline generator provides the electricity consumed by the Pyro-6F. Emissions are based on a gasoline reciprocating engine from the GREET model, assuming a gasoline to electric generation efficiency of 35 percent. Avoided Agricultural Inputs Although some case studies have data on improved fertilizer use efficiency (Steiner et al. 2008; van Zwieten, Kimber, Downie et al. 2010) or reduced input needs, due to the lack of data for the Senegal case study the baseline scenario does not include any of these effects. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 122 Life-Cycle Assessment of Existing Biochar Systems Soil Nitrous Oxide and Methane Emissions Similar to the Kenya case study, the baseline scenario of this analysis assumes that there are no changes in soil nitrous oxide or methane emissions with biochar application, due to lack of site-specific data. However, the sensitivity analysis considers a range of +50 percent to −50 percent for the effect of biochar applica- tion on soil nitrous oxide emissions. (See Kenya case study and the section titled “Impacts on Climate Change” in chapter 3 for further discussion on soil nitrous oxide and methane emissions.) Results and Discussion Table 5.14 lists the result vector for the Senegal biochar system. The net GHG balance is −0.4 tonnes of CO2e per tonne of dry rice husk, as illustrated in figure 5.17. The net economic balance is +$6,696 per tonne of dry matter for the 50-year biochar effect. The majority of both the GHG emissions and reductions are from carbon dioxide, with much smaller contributions from methane and nitrous oxide (table 5.14). The surplus onion from biochar additions is 23 tonnes over the 50 years of biochar’s effect on crop yields. Looking at the contribution analysis in figure 5.17, the largest source of reduced GHG emissions is the stable carbon in the biochar, at −0.4 tonnes of CO2e per tonne of dry matter, or 87 percent of the total GHG reductions. The next largest amount of GHG reductions is from the soil organic carbon accumu- lation from increased belowground biomass, at –0.06 tonnes of CO2e per tonne of dry matter, or 11 percent of GHG reductions. The avoided rice husk decay contributes 2 percent. The only GHG emissions are during the pyrolysis unit operation and transportation. Another important aspect included in the analysis but not represented in figure 5.17 is that all of the rice husk feedstock is assumed to be renewable, Table 5.14  Result Vector for Senegal Biochar System Baseline Scenario, per Tonne of Dry Rice Husk Feedstock Input/output Value Unit Methane 2.53 kg Nitrous oxide 0.01 kg Carbon dioxide −480 kg Stable carbon 121 kg Net CO2e −414 kg Revenue 6,815 $ Cost −119 $ Net $ 6,696 $ Surplus onion 23 tonne Source: World Bank. Note: For methane, nitrous oxide, and carbon dioxide, a negative sign corresponds to avoided emissions or sequestration, while a positive value indicates emissions. Negative $ are costs, and positive $ are net revenues. The bold type indicates the net GHG and economic balances. CO2e = carbon dioxide equivalent Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 123 Figure 5.17  Contribution Analysis for Net Climate Change Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Senegal – Emissions/reductions Net = –0.4 + 0 0.1 0.2 0.3 0.4 0.5 0.6 GHG (t CO2e t–1 DM) Stable C in biochar SOC Avoided RH decay Pyro emissions Pyro construction Pyro transport Source: World Bank. Note: The upper bar (–) represents the GHG reductions, the lower bar (+) is GHG emissions, and the difference represents the net GHG balance of the system. C = carbon; GHG = greenhouse gas; SOC = soil organic compound; CO2e = carbon dioxide equivalent. similar to the Vietnam rice husk case study. Thus, only non-carbon dioxide GHG emissions are included in the pyrolysis unit emissions as these are assumed to not otherwise occur, whereas the carbon dioxide emissions are offset by the uptake of carbon dioxide by the renewable feedstock. If the feedstock were nonrenew- able, then both carbon dioxide and non-carbon dioxide GHG would be included. The 0.4 tonnes of CO2e per tonne of dry matter obtained for the Senegal case study is lower than other life-cycle studies in both developed and develop- ing countries, which range from 0.7 to 1.3 (Hammond et al. 2011; Karve et al. 2011; Roberts et al. 2010). However, this lower value is expected, as the energy is not captured and emissions from avoided fossil fuel combustion are not included. The economic contribution analysis is presented in figure 5.18a and 5.18b for a 50-year and one-crop biochar effect, respectively. The dry tonne of rice husk feedstock for biochar production and soil application results in $6,696 per tonne of dry matter over the 50 years of biochar’s agronomic effect, or $24 per tonne of dry matter for a one-crop effect. The revenue comprises almost entirely (99 percent) the surplus onion sales, while biochar price adds a small amount. In the figure, the transportation costs of the biochar and pyrolysis unit are aggregated so that only the net transportation cost is represented. The capital and operating costs of the pyrolysis unit are small in comparison to the revenues for the 50-year effect, but can be seen in 5.18b and are significant compared to other case studies (−$89 vs. −$1). Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 124 Life-Cycle Assessment of Existing Biochar Systems Figure 5.18  Contribution Analysis for Net Economic Impact per Tonne of Dry Feedstock for Rice Husk Biochar System in Senegal + Cost/revenue 50-yr biochar effect Net = +$6696 – 0 2,000 4,000 6,000 8,000 Revenue ($ t–1DM) + Cost/revenue 1-crop biochar effect Net = $24 – 0 50 100 150 200 Revenue ($ t–1DM) Surplus onions Biochar price Pyro operation Pyro construction Biochar transport Pyro transport Source: World Bank. Note: 5.18a represents the baseline scenario, where biochar is assumed to have a 50-year agronomic effect; 5.18b is a scenario where biochar has a one-crop effect. The upper bar (–) represents the revenues, the lower bar (+) is costs, and the difference represents the net economic balance of the system (note the different scales of both graphs). There is a distinction between the net revenue per functional unit and the net revenue for the farmer (table 5.15). For the farmer, the cost of the biochar incor- porates the cost of the feedstock, the pyrolysis unit capital, and operating costs, whereas per functional unit, the biochar product is actually a revenue that offsets the capital and operating expenses. The revenues from surplus crop sales are the same per functional unit and per farmer. The difference in net revenue per func- tional unit and per farmer is −$46. The economics can also be considered from the viewpoint of the NGO operating the Pyro-6F, as seen in the third column of table 5.15. Under the current parameters, the net economic balance results in a cost of −$30 per tonne of dry matter for the NGO. This comparison illustrates that despite the high potential for economic success for the farmer, the NGO Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 125 Table 5.15  Comparison of Net Revenue between LCA Functional Unit, Farmer, and NGO Costs and revenues ($ per tonne of dry matter) Functional unit Farmer NGO Kiln capital −42 0 −42 Kiln operations –63 0 −63 Kiln transport −1 0 −1 Biochar 76 −76 76 Surplus crops 6,740 6,740 0 Biochar transport −12 −12 0 Total 6,698 6,652 −30 Source: World Bank. Note: NGO = nongovernmental organization. might be operating at a loss. Depending on the funding scheme of the project, this could be problematic. The NGO might need to decrease operating costs (by increasing production time) or increase the price of biochar to the extent that farmers can still afford it. In this project, carbon credits are not received, but the farmer could poten- tially return an additional $8 per tonne of feedstock if the stable carbon in the biochar receives offset credits for a carbon price of $19 per tonne of CO2e. The $6,696 per tonne of dry matter achieved for the Senegal biochar system is significantly higher than results from Roberts et al. (2010), where the most economically promising large-scale U.S.-based biochar system calculated in the analysis was yard waste at $69 per tonne of dry matter, which includes carbon offsets of $80 per tonne of CO2e. However, the U.S. example assumed no increased crop productivity with biochar amendments, and only a one-crop bio- char effect. If there is no crop productivity increase, there are no surplus crops, and thus no revenues from the sale of surplus crops. Sensitivity Analysis A sensitivity analysis was conducted in order to measure the variability in the LCA results as a function of varying key input parameters (table 5.16). The input parameters that were tested are the fraction of recalcitrant carbon in the biochar, the yield response of onion crops with biochar additions, the price the farmer receives for onions, methane emissions from the pyrolysis unit, methane emis- sions from avoided rice husk decay, the duration of biochar’s agronomic effec- tiveness, the price of the biochar, the production time for the pyrolysis unit, the biochar transportation distance, and soil nitrous oxide emissions. The detailed sensitivity analysis is presented in appendix B, while a summary of the sensitivity analysis results is presented below. The GHG balance is relatively insensitive to the Pyro-6F production time (less than about 1 percent variability) and the pyrolysis methane emissions (5 percent within the realistic range tested), and moderately sensitive to the Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 126 Life-Cycle Assessment of Existing Biochar Systems Table 5.16  Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Biomass throughput (tonnes of dry matter per year) 1,388 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) 52 –50 to +233 Onion price ($ per tonne) 287 70–552 Pyro-6F methane emissions (kg per tonne of dry matter) 2.9 2.2–6.4 Avoided rice husk decay methane emissions (kg per tonne 0.33 0.33–2.46 of dry matter) Duration of biochar’s effect (years) 50 1–100 Biochar price ($ per tonne) 200 100–300 Pyro-6F production time (% of capacity) 50 25–100 Biochar transportation distance (km) 10 1–25 Soil nitrous oxide emissions (%) 0 –50% to +50 Source: World Bank. duration of biochar’s agronomic effect (15 percent) and rice husk decay methane emissions (15 percent). Meanwhile, the stable carbon content (15–40 percent) and soil nitrous oxide emissions (170 percent) could play the largest role in vari- ability of the GHG balance. Figure 5.19 demonstrates that the net GHG balance for the Senegal case study may be most sensitive to the soil nitrous oxide emis- sions, followed by the fraction of stable carbon in the biochar and the duration of biochar’s effect, while the methane emissions during pyrolysis have less impact on the GHG balance. Significant effects on the net economic balance are found within the range tested for the crop yield response (up to 350 percent), the duration of biochar’s agronomic effect (100 percent), and the onion price (up to 90 percent), while Figure 5.19 Sensitivity Analysis for Net GHG per Tonne of Dry Feedstock for Biochar System in Senegal a. Pyrolysis CH4 emissions (kg CH4 t–2 fuel) b. Soil N2O emissions (% change from baseline) 0.0 1.0 2.0 3.0 4.0 5.0 6.0 7.0 –60 –40 –20 0 20 40 60 40 200 GHG (% change from baseline) GHG (% change from baseline) 20 150 0 100 –20 50 –40 0 –60 –50 –80 –100 –100 –150 –120 –200 0 20 40 60 80 100 0 20 40 60 80 100 120 Stable C fraction, % Duration of biochar effect, years Stability Pyro CH4 emissions Biochar effect Soil N2O emissions Source: World Bank. Note: Figure 5.19a compares the fraction of stable carbon in the biochar to the Pyro-6F methane emissions, and 5.19b illustrates the duration of biochar’s agronomic effect and soil nitrous oxide emissions (nitrous oxide emissions range chosen according to extreme values available in the literature, see text). CH4 = methane; N2O = nitrous oxide; GHG = greenhouse gas. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 127 Figure 5.20  Sensitivity Analysis for Net Economic Balance per Tonne of Dry Feedstock for Biochar System in Senegal a. Onion price ($ t–1) b. Duration of biochar effect, year $0 $100 $200 $300 $400 $500 $600 0 20 40 60 80 100 120 100 400 80 (% change from baseline) (% change from baseline) 300 60 40 200 Net revenue Net revenue 20 100 0 –20 0 –40 –100 –60 –200 –80 –100 –300 0 20 40 60 80 100 –60 –40 –20 0 20 40 60 Pyro-6F production time (% capacity) Crop yield (% change from control) Pyro-6F production time Onion price Crop yield Biochar effect Source: World Bank. Note: Figure 5.20a compares the onion price to the Pyro-6F production time; 5.20b illustrates the variation in the crop yield and the duration of biochar’s agronomic effect. the biochar price (3 percent), biochar transportation distance (less than 1 per- cent), and the Pyro-6F production time (2 percent) have relatively small impacts from the perspective of the functional unit. The price of surplus crops for the Kenya and Vietnam case studies had less impact on the net economics than for the Senegal study, though this was due to the high yield of onion crops with biochar additions and the resulting high revenues from surplus crops, leading to a stronger impact on the overall balance. Figure 5.20 illustrates this variability, where it is evident that the crop yield response due to biochar additions followed by the duration of bio- char’s effect and the onion price have the largest impact on the net econom- ics. Meanwhile, the Pyro-6F production time has only a small impact on the economics of the system, which is due to the fact that the net revenues are calculated per functional unit (1 tonne of dry feedstock). If the economic analysis were conducted from the viewpoint of the NGO operating the pyrolysis unit, the results would be different. From the NGO viewpoint, at 25 percent operating capacity the net revenues would decrease by around 350 percent, whereas increasing production to 100 percent would result in a net positive economic balance for the NGO (+$22 per tonne of dry mat- ter) with an increase of around 170 percent. More details on the sensitivity analysis can be found in appendix B. Box 5.4 Summary of Senegal Case Study The Senegal biochar system has potential for climate change adaptation and mitigation through carbon sequestration and GHG emission reductions, while also being economically viable for the smallholder farmer. The net GHG reductions are –0.4 tonnes of CO2e per tonne of feedstock. The net economic balance is +$6,696 per tonne of dry matter over the 50 years box continues next page Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 128 Life-Cycle Assessment of Existing Biochar Systems Box 5.4 Summary of Senegal Case Study (continued) of biochar’s agronomic effect, or +$24 for a one-crop effect. In this project, carbon credits are not received, but the farmer could potentially return an additional $8 per tonne of feedstock with emissions trading at a price of $19 per tonne of CO2e. The contribution analysis reveals that the net GHG balance is largely (87 percent) driven by the stable carbon in the biochar, assuming that the feedstock remains a sustainable source. Soil nitrous oxide emissions could also play an important role in the GHG balance, thus more data are required to quantify this effect. The sensitivity analysis reveals that the net GHG balance is relatively insensitive to chang- es in methane emissions during pyrolysis and avoided rice husk decay, the crop yield re- sponse with biochar additions, and the duration of biochar’s agronomic effect, within the re- alistic range tested for these parameters. Soil carbon accumulation and transportation of the pyrolysis unit also play small roles in the GHG balance. The net revenues are extremely sensi- tive to the crop yield response, the duration of biochar’s agronomic effect, and the price of onions, while the relative impact of the biochar transportation distance, the biochar price, and the pyrolysis unit production time is less. This Senegal biochar system presents itself as a low-risk biochar project with climate change adaptation and potentially high economic benefits for smallholder farmers incorpo- rating biochar into their practices. Case Study Comparison and Conclusions The net GHG balance of three biochar case studies in developing countries (Kenya, Vietnam, and Senegal) ranges from −0.4 to −1.8 tonnes of CO2e per tonne of dry matter (figure 5.21). The Kenya cookstove project has the highest amount of GHG reductions due to the avoided emissions from traditional cook- ing (contributing −1.3 tonnes of CO2e per tonne of dry matter), where 48 percent of the feedstock for traditional cooking would come from off-farm woody bio- mass, of which 80 percent is nonrenewable. The stable carbon in the biochar is the largest contributor to the GHG balance for the Vietnam and Senegal studies, and contributes about −0.4 to + 0.5 tonnes of CO2e per tonne of dry matter for all three studies. The Vietnam case study highlights the role of reduced agricultural inputs (manure and phosphorus and potassium fertilizers) with biochar, further reducing GHG emissions. All systems analyzed demonstrate that the emissions from biochar production (whether cookstove or village-scale unit), transportation, and stove or kiln construction are minimal compared to the net balance of the system. Depending on the crop and increase in belowground biomass, increased soil organic carbon accumulation can also play a role, although small, in the net GHG of the system. Although not included in the baseline scenarios, the effect of biochar on soil nitrous oxide emissions can play a significant role in the net GHG of the system, emphasizing the need for improved data in this area. In comparing the net revenues of the case studies, both the 50-year and one- crop biochar effect are discussed (figure 5.22). In figure 5.22, the surplus maize due to biochar additions in the Kenya study has been monetized for the discus- sion. The three case studies are presented in the chart side by side, but it is Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 129 Figure 5.21  Comparison of Net GHG Balance of Three Case Studies: Kenya, Vietnam, and Senegal 0.5 Net = –1.8 Net = –0.5 Net = –0.4 0 Net GHG (t CO2e t–1 DM) –0.5 –1.0 –1.5 –2.0 Kenya Vietnam Senegal Avoided cooking/decay/burning Stable C in biochar SOC accumulation Stove/kiln emissions and operation Avoided ag inputs SOC depletion Transportation Stove/kiln construction Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent; SOC = soil organic compound. important to note that the comparison is not meant to select one project as bet- ter than another, as each project is unique with its own set of challenges and successes. Rather, the goal is to highlight strengths and weaknesses within each individual project, and the results are plotted alongside each other for conve- nience only. The most important result regarding the economics is that each project has a very short payback period—within one year when surplus crops are monetized. The Kenya case study demonstrates the added complexity of subsis- tence farming and valuing nonmonetary benefits such as increased food security for the household and labor savings. The yield of the crops to which the biochar is applied plays the largest roles in determining the economic balance, implying that the farmer’s choice of crops can be as important as the type of soil to which the biochar is applied. If biochar does not address local soil constraints, then crop productivity may not improve sufficiently (or at all) for farmers to realize an increase in revenues from sales of the surplus crops. For Senegal, the biochar is applied to a relatively high-yielding crop of onions. Although the price of onions is comparable to maize, the higher yield increase results in higher revenues for the farmer. Of course, the farmer’s crop options may not be flexible, particularly in the short term. Another important factor in the economic balance is the capital and operating costs of the biochar production technology. In the case of cookstoves, the capital Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 130 Life-Cycle Assessment of Existing Biochar Systems Figure 5.22 Comparison of Net Revenues of Three Case Studies: Kenya, Vietnam, and Senegal 7,800 Net = +$6696 6,800 5,800 Net revenue ($ t–1 DM) 4,800 3,800 2,800 1,800 Net = +$948 800 Net = +$245  –200 Kenya, 50 yr Vietnam, 50 yr Senegal 50 yr 150 100 50 Net revenue ($ t–1 DM) Net = +$7 Net = +$1 0 –50 –100 Net = +$24 –150 Kenya, 1 crop Vietnam, 1 crop Senegal, 1 crop Surplus crops Avoided ag inputs Biochar price Transport Stove/kiln cost and operation Feedstock cost Source: World Bank. Note: Figure 5.22a compares net revenues of the three case studies – Kenya, Vietnam, and Senegal – for a 50-year biochar effect; 5.22b compares net revenues for a one-crop biochar effect. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 131 cost over the lifetime of the stove is small and the operating costs are minimal (cost of feedstock only). Meanwhile, the Senegal village-scale pyrolysis unit has significant costs, which are only offset by the large revenues from the surplus onion sales. If the biochar in Senegal were applied to maize, the same revenues might not be achieved because of the potentially lower yield increase of maize. The price the farmer receives for the surplus crop is also important for determining the eco- nomic balance, although less so than the crop yield response to biochar. In addition, the price of the biochar affects projects where the biochar is produced ­ off-farm (Senegal and Vietnam). Avoided agricultural inputs and avoided transpor- tation of those inputs are another source of revenue, as demonstrated by the Vietnam case study. For the LCA, the biochar price is considered a revenue per functional unit, which offsets the cost of the feedstock, capital, and operating costs, whereas the biochar is considered a cost to the farmer. Defining the success of the economic balance is dependent on the perspective, where the same costs and rev- enues may result in an economically favorable situation for the farmer but not for the NGO operating the pyrolysis facility, as in the case of the Senegal system. The duration of biochar’s agronomic effect plays a significant role in the eco- nomics of biochar systems in developing countries. On the high extreme, the Senegal study is calculated to generate +$6,696 per tonne of dry matter, assum- ing biochar has a 50-year effect, compared to +$24 per tonne of dry matter for a one-crop effect. However, it is important to note that even though a project may net +$948 per tonne of dry matter (as in the Vietnam case study, for example), this sum is distributed over the 50 years of biochar’s effect. The farmer would achieve the surplus peanut revenue of $7 per tonne of dry matter each cropping cycle, in addition to reduced inputs and transportation costs each cropping cycle. Finally, the biochar application rate is also critical, where up to 950 percent vari- ability in the net revenues of the system is found by decreasing the application rate an order of magnitude (Kenya case study). Determining the minimum bio- char application rate that still achieves the desired agronomic response will enable farmers to make best use of limited biomass and economic resources. Biochar projects in developing countries have the potential to reduce GHG emissions and be economically viable, as demonstrated by the life-cycle assess- ment case studies in Kenya, Vietnam, and Senegal. Ensuring the sustainability of the feedstock for biochar production is the first and most important step in achieving GHG reductions. With the feedstock sustainability in line, the recalci- trant carbon in the biochar is the largest source of direct carbon sequestration by removing atmospheric carbon dioxide and stabilizing it in the biochar. Avoided emissions from traditional biomass management practices such as traditional cooking can also play an important role where the feedstock is from a nonrenew- able source, while avoided rice husk burning or decay are less influential because of the renewability of the resource. Emissions during pyrolysis (biochar produc- tion) have only a small impact on the net GHG balance for these systems. Meanwhile, the economics of these projects is largely dependent on the effective- ness of biochar to address soil fertility constraints, the duration of biochar’s agro- nomic effect, the biochar application rate, and the value of the crops to which Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 132 Life-Cycle Assessment of Existing Biochar Systems biochar is applied. Research and development efforts should focus on creating knowledge and understanding of these critical and interdependent parameters so that biochar projects in developing countries can be implemented with the high- est probability for improving the livelihoods of smallholder farmers while also mitigating and adapting to climate change. Notes   1. “The goal of the biochar energy, greenhouse gases, and economic (BEGGE) LCA is to quantify the energy, greenhouse gas, and economic flows associated with biochar pro- duction for a range of feedstocks” (Roberts et al. 2010).   2. D. Torres, unpublished data. It is possible that fuelwood gathering could be conducted at the same time as other chores, thus if multitasking were a common practice, the actual amount of time to collect fuelwood might be less.   3. J. Recha, personal communication, 2010.   4. Ibid.   5. Ibid.   6. J. Recha, personal communication, 2010.   7. J. Recha, personal communication, 2011.   8. D. Guerena, personal communication, 2010.   9. J. Lehmann, unpublished data, 2011. 10. Although this supplies the family with cooking energy for one year, the biochar effect is still assumed to be 50 years, as in the baseline scenario. 11. J. Recha, personal communication, 2011. 12. ICE website:Emissions https://www.theice.com/productguide/ProductGroupHierarchy. shtml?groupDetail=&group.groupId=19. 13. International Rice Research Institute website: Rice knowledge bank: rice husk http:// www.knowledgebank.irri.org/rkb/index.php/rice-milling/byproducts-and-their-utili- zation/rice-husk. 14. P. Slavich, personal communication, 2011. 15. The Engineering Toolbox website: Estimating brick quantity and mortar consumption http://www.engineeringtoolbox.com/brick-mortar-consumption-d_1549.html. 16. P. Slavich, personal communication, 2011. 17. H. M. Tam, personal communication and unpublished data, 2011. 18. H. M. Tam, personal communication, 2011. 19. Ibid. 20. P. Slavich, survey response, 2010. 21. H. M. Tam, personal communication, 2011. 22. H. M. Tam, personal communication, 2011; P. Slavich, personal communication, 2011. 23. Also, P. Slavich, survey response, 2010. 24. H. M. Tam, personal communication, 2011. 25. P. Slavich, personal communication, 2011. 26. H. M. Tam, personal communication, 2011. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Life-Cycle Assessment of Existing Biochar Systems 133 27. P. Slavich and H. M. Tam, personal communication, 2011. 28. H. M. Tam, personal communication, 2011. 29. P. Slavich, personal communication, 2011. 30. H. M. Tam, personal communication, 2011. 31. C. Braun, personal communication, 2011. 32. C. Braun and G. Reinauld, personal communication, 2011. 33. Ibid. 34. Data from Portworld http://www.portworld.com/map/. 35. C. Braun and G. Reinauld, personal communication, 2011. 36. Green Charcoal International website: Technology http://www.green-charcoal.com/ pyrolyser. 37. C. Braun and G. Reinauld, personal communication, 2011. 38. Ibid. 39. C. Braun and G. Reinauld, personal communication, 2011. 40. Ibid. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 6 Aspects of Technology Adoption Economics of Biochar The results of the life-cycle assessment (LCA) case studies in chapter 5 and other biochar analyses (Gaunt and Cowie 2009; Gaunt and Lehmann 2008; Hammond et al. 2011; Roberts et al. 2010) demonstrate that biochar systems can offer potential greenhouse gas (GHG) reductions in the range of 0.4–2.0 tonne of carbon dioxide equivalent (CO2e) per tonne of dry feedstock. However, the implementation and sustainability of all biochar systems, but particularly those in developing countries where start-up capital and other funds are lacking or severely limited, are dependent on the economics of these projects. If the economics of the projects are favorable to smallholder farmers, the adoption of ­ biochar systems in smallholder agricultural systems will be facilitated and GHG emissions will be further reduced, while also allowing for adaptability and resilience to climate change. ­ The economics of biochar systems in developing countries are dependent on multiple factors that are specific to the project, and are further complicated in these systems by the fact that many benefits to the smallholder are not traditionally monetized. Examples of parameters that are more easily quantified ­ include the cost of the feedstock (if any), the capital and operating costs of the stove or kiln, transportation of feedstocks and biochar, the price of biochar, the price (if any) of surplus crop yields, and the savings from reduced agricultural inputs and waste management. Meanwhile, parameters such as decreased labor, improved indoor air quality, and increased food for the household directly benefit the project participants but are not generally valued monetarily, particu- ­ larly in developing-country settings. Furthermore, additional benefits may potentially arise due to decreased deforestation pressures, improved water use ­ efficiency, and climate change adaptation. Finally, although none of the biochar projects to date receives carbon credits, this contribution may increase revenues as projects progress. Overall, the economics of biochar projects analyzed in the case studies are largely determined by the price farmers receive (or lack thereof) for surplus crops due to biochar additions. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   135 136 Aspects of Technology Adoption Few economic analyses of biochar projects in developing countries have been published to date; the only publication at this time is Joseph 2009. Joseph estimates that for a hypothetical biochar project in a developing country using a ­ combination of cookstoves and kilns, the net present value of a five-year project is $55,943, with 292 tonnes of biochar produced over the five years. Assuming a biochar yield of 22 percent as in this analysis, the net economic balance is +$42 per tonne of dry feedstock. This analysis includes aspects of implementing a development project not included in the LCA, such as extension and external consultants and compliance monitoring and evaluation, but also assumes carbon credits are received by the project (which the LCA in chapter 5 does not). The Kenya, Vietnam, and Senegal case studies calculate balances of –$1, +$955, and +$6,700 per tonne of dry feedstock, respectively. The wide range in economic balances is indicative of the unique, case-by-case nature of these types of projects. For example, subsistence farmers in Kenya may not see any economic return for increased maize sales, but the food supply for the family will be improved. If these supplies are valued monetarily, then the balance could be estimated at +$127 per tonne of feedstock. Comparing the economic balances of the developing-country projects to biochar systems in industrialized countries, it is possible that the potential ­ benefits for smallholder farmers may be greatest. For example, all the feedstocks ­ analyzed by Roberts et al. (2010)—stover, yard waste, and switchgrass—required carbon credits in order to be profitable. On the other hand, the onion and peanut farmers in Senegal and Vietnam would potentially realize increased revenues within the first year of the project. Pratt and Moran (2010) also observe that small-scale, slow-pyrolysis biochar systems, such as those relying on cookstoves, are often more cost-effective for GHG reductions than the fast-pyrolysis systems favored by large biochar plants. One of the main causes of this is that biochar offers the most agronomic benefits on poor-quality soils, which is frequently the case for smallholder farmers in developing countries, as is exemplified by the case studies. The economics of biochar projects in developing countries may therefore be largely driven by the potential revenues from sales of surplus crops due to biochar additions to the soil. Engagement with Carbon Markets Criteria for a Successful Project There are many factors that contribute to the success of a project designed to mitigate climate change by generating emission reductions, be it for the volun- tary or compliance-based carbon markets. In a market scenario, the emission reductions generated by a project can be sold when their price is lower than the marginal cost of emission abatement the buyer faces. In a compliance market, these emission reductions are used directly as credits to allow an entity to emit a given amount of GHGs while remaining under the limit (cap) they have been allotted. In a voluntary market, carbon offsets are sold to companies, organiza- tions, or individuals with the desire, but not the obligation, to reduce their carbon footprint. Thus, one can see why a more stringent level of assurance that emission Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Aspects of Technology Adoption 137 reductions truly reduce GHG emissions as much as they are supposed to is needed for those sold within compliance-based markets. A number of basic guidelines are required for a successful biochar project to reduce GHG emissions and to generate emission reductions. Whitman, Scholz, and Lehmann (2010) discuss these issues for biochar projects in greater detail, but here the following will be considered: additionality and baselines; perma- nence; leakage and system drivers; and measurement, reporting, and verification. Additionality and Baselines The principle of additionality requires that a project would not have taken place under a business as usual scenario and without the incentive provided by the price of carbon. The most prevalent tool used to determine additionality is the “additionality tool” used under the Kyoto Protocol’s Clean Development Mechanism for generating carbon offsets (UNFCCC 2008). In order to success- fully demonstrate additionality, the baseline scenario—what would have hap- pened without the project in place—is critical. With biochar projects, the differ- ence between the impact of creating biochar from biomass that would have been burned, grasses that decompose very quickly, slow-decomposing woody biomass, or a living tree is substantial and must be taken into account. If the baseline sce- nario was that the tree was going to continue growing, drawing carbon dioxide from the atmosphere, charring it would release so much carbon that, despite increased stability, the net carbon budget would register a carbon release to the atmosphere for decades, if not hundreds of years. Permanence The issue of permanence is discussed extensively in the section titled “Impacts on Climate Change” in chapter 3. While it is critical to establish what fraction of biochar will be relatively stable, the challenges associated with establishing and maintaining carbon storage with biochar are drastically different from those asso- ciated with nonbiochar soil carbon or forests. Carbon storage through nonbiochar soil carbon or forest management tends to be much more easily reversible, through changes in management practices. Once biochar is applied to soils, its impact depends more on its physical and chemical properties than on continua- tion of specific management practices. Leakage and System Drivers Leakage occurs when emission reductions within a project boundary result in increased emissions elsewhere (that is, outside the project boundary). For example, if forest conservation in one area resulted in increased logging in adjacent forests, this would constitute leakage. One robust way to try to prevent leakage is by taking a systems view, as is done in the LCA section of this report. Two examples of potential effects that may be overlooked in biochar projects include the potential for black carbon emissions to the atmosphere and biochar’s effects on GHG emis- sions from soils. As discussed in the section titled “Impacts on Climate Change” in chapter 3, these effects are currently being studied. A second important source of Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 138 Aspects of Technology Adoption leakage can come from “rebound effects.” For example, if a family begins using a more efficient cookstove, if wood availability was a limiting factor before, they may cook more with the efficient stove. Thus, the predicted energy, carbon, and fuel savings may easily be overestimated. Some systems are more prone to this effect than others. The use of a cookstove is constrained somewhat by how much people eat, while the use of a system that provides energy for other uses would be less likely to be limited. Considering system drivers in combination with “true wastes” for feedstocks can help to create a “safer” biochar-producing system. Measurement, Reporting, and Verification In order to understand the climate effects of a project, it is essential to be able to quantify and verify its impact. The measurement of the impacts due to changes in energy use and production within a biochar system should not differ greatly from extant energy-based offset projects, nor should it necessarily produce many new challenges. The new challenge is in measuring the impact of the biochar. There are two ways one might think of its measurement—direct and indirect. Direct measurement—for example through repeated soil sampling and quantifi- cation—is attractive in some ways, such as its clear tangibility, but is challenging in others. Measuring biochar contents in soils would raise similar challenges to measuring nonbiochar soil carbon—its heterogeneity makes it difficult and expensive to measure. Furthermore, it would not be possible to capture biochar lost due to erosion from runoff, which has been found to provide a substantial proportion of the losses of biochar and fire-generated char from soils (Guggenberger et al. 2008; Major et al. 2010; Rumpel et al. 2006). Assuming any biochar removed from the system through runoff is equivalent to its return to the atmosphere would likely result in overly conservative estimates of its impact (Whitman, Scholz, and Lehmann 2010). An alternative to direct measurement might be to monitor its production, and, combined with decomposition studies, predict the persistence of biochar in soils, combined with minimal sampling to establish that the biochar is being applied to soils and not used in other ways. Such targeted verification measurements could use techniques to specifically test for biochar-type carbon forms (Manning and Lopez-Capel 2009), which would unambiguously prove the source of the soil carbon change. Developing confi- dence in this approach may be critical to enable biochar projects to include biochar-based emission reductions in their carbon accounting. Future of Biochar in Carbon Markets There are currently no approved methodologies under the Clean Development Mechanism (CDM) that include biochar. A submission of a methodology for a large-scale biochar production system has been made to the Verified Carbon Standard (formerly Voluntary Carbon Standard) (Carbon Gold 2009), but has not yet been approved. With regard to (nonbiochar) cookstoves, relevant methodolo- gies already exist (ClimateCare 2010; UNFCCC 2009). Table 6.1 summarizes the state of existing protocols for measuring the various potential impacts of biochar systems (summarized earlier in table 3.2). Notably, what remains to be developed is a robust protocol for measuring the impact of the biochar itself. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Aspects of Technology Adoption 139 Table 6.1  State of Protocols for Measuring GHG Impacts of Biochar Systems Source Protocols Notes Carbon Carbon Gold The current submission is likely insufficient and is not based stabilization submission to on strong scientific reasoning. Developing such a proto- Verified ­Carbon col is very important if biochar projects are to succeed ­Standard in measuring their full climate change impact, as carbon ­currently ­under stabilization in biochar comprises a substantial portion of review emission reductions. Renewable Numerous CDM CDM protocols cover many aspects of the replacement of energy protocols; fossil fuel energy with renewable energy. There is no rea- Gold Standard son why adapting protocols for energy-related impacts to protocol for biochar projects would be particularly challenging. cookstoves Waste diversion CDM methane The CDM has a protocol for avoiding methane production avoidance of biomass through pyrolysis, limited to projects that produce less than 60,000 tonnes of CO2e per year. Further development of similar protocols would be necessary, but must be synchronized with those that would count carbon stabilization in biochar to avoid double-counting of emission reductions. Reduction in soil None No protocol currently exists, and soil GHG emissions are emissions notoriously challenging to measure due to high spatial and temporal variability. Reduction in None quantification No protocol is currently known to exist, but its ­ fertilizer should not be particularly challenging for biochar manufacturing ­ projects as compared to others. Increased non- None While the sign of the impact of BC on soil carbon (posi- BCa soil carbon tive/negative) should become predictable, its precise ­ quantification would be extremely challenging and it is not likely to provide a major fraction of GHG reductions. Source: World Bank. Note: CDM = Clean Development Mechanism; CO2e = carbon dioxide equivalent; GHG = greenhouse gas. a. BC = black carbon. The cost per tonne of CO2e reductions predicted for an improved cookstove project in Mexico by Johnson et al. (2009) was around $8, which was in part due to the high installation costs of the stove itself (around $100). More recent expe- rience in the field of improved cookstove projects shows that these costs can be brought down dramatically using economies of scale and by structuring the sale of the stoves accordingly.1 With a stove cost of roughly between $4 and $30 per stove the cost per tonne of CO2e reduction becomes much more attractive and in many instances might be very competitive to other abatement options. If a biochar cookstove in western Kenya were improved to produce emission reduc- tions per stove of the same order of magnitude (Whitman et al. 2011), one might predict that the marginal cost of abatement might be similar to other improved cookstove projects. However, measurement and verification of the biochar pro- duction and application as potentially required by any future biochar methodo­ logy for climate change mitigation would likely add an additional cost. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 140 Aspects of Technology Adoption Sociocultural Barriers to Adoption No matter what the technical potential benefits of biochar are, their realization depends on whether and how people implement biochar systems. Understanding sociocultural barriers to adoption is essential for a successful project, but can be challenging and often requires highly location-specific understanding of people and their needs, values, and expectations. FAO (2010) provides an in-depth dis- cussion of barriers and incentives to implementation common to food-energy systems. It notes that barriers to the implementation and wide-scale dissemina- tion of such systems concern various aspects at both farm and beyond-farm lev- els. Key considerations include the following: • The complexity of systems requires high levels of knowledge and skills. • The technology used needs to be reliable and economical. • Financing is mostly related to the investment required for the energy conver- sion equipment. • The increased workload makes the systems less attractive to farmers. • Competition between different uses of residues must be addressed. • Access to markets for agricultural and energy products is often a key factor to ensure economic viability. • Access to information, communication, and learning mechanisms is as impor- tant a production factor as “classic” land, labor, and capital. • Few government policies encourage all aspects of systems. Each item on this list could apply to biochar systems and the challenges of implementing them. This list could serve as a useful checklist for project devel- opers and implementers. Sociocultural factors can influence project success in both positive and nega- tive ways. Potential impacts from the adoption of biochar systems were discussed in the section titled “Social Impacts” in chapter 3. These include, on the negative side, health impacts from biochar dust; increased labor to produce and apply biochar; increased cost to purchase or apply biochar; potential gender impacts; and competition for feedstocks needed for soil protection, fodder, fuel, or income. On the positive side, potential impacts include improvement to health through better nutrition from increased crop yields and substitution by clean cookstoves and kilns of less efficient, high-emission units; increased access to household energy, both thermal energy and, in some cases, electricity; and reduced labor and increased income through increased crop yields and reduced inputs of fertilizer and water. Which of these effects are the most important in a given scenario and region would likely influence the success of a given project. To better understand the importance of some of these factors in current proj- ects, a second survey was conducted, as described in the section titled “Survey” in chapter 4. This follow-up survey to the original survey asked respondents ques- tions about barriers, traditional indigenous biochar use, how projects coped with limited supplies of biochar, the top perceived benefits, and project reliance on carbon financing. The survey included many open-ended questions, which allowed respondents to provide detailed responses. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Aspects of Technology Adoption 141 The first set of questions asked directly about sociocultural barriers and ideas for overcoming them. Overwhelmingly, respondents cited a lack of awareness of biochar and the need for education and demonstration projects to show farmers that making and using biochar would be worth their time (see appendix A for documentation of results). Gender issues were perceived to be a minor barrier, making up 10 percent of the cited reasons for barriers, and one respondent thought biochar would help women by adding to their household income. Labor barriers were mentioned for slash-and-char systems, where biochar was in com- petition with slash-and-burn practices, which required less labor and gave a quicker result. The labor required to gather dispersed feedstocks was also cited as an obstacle. The availability of biochar production technology was a related barrier. Very few projects had yet developed an adequate supply of biochar or possessed reliable technology for producing it, and so had to restrict their biochar trials to smaller plot sizes. Others noted environmental issues as a concern, with one project respondent reporting that farmers were concerned about environ- mental safety (China) and another about the potential for deforestation (Africa). This survey also investigated the prevalence of biochar as a traditional farming practice. Farmers are often conservative in their practices and it can be challeng- ing to introduce new agricultural techniques, even when they are clearly benefi- cial. Intriguingly, in many regions, some form of biochar application was a tradi- tional practice that was swept away by the advent of chemical fertilizers and other twentieth-century methods. The survey found that 35 percent of those who responded to this question reported a traditional indigenous use of biochar- like practices. Many felt that the existence of the traditional practice made their job of communicating the benefits of biochar much easier (appendix A). In order to understand what drives the adoption of biochar systems, the final set of questions (appendix A) examined what the most important benefits were to project participants, including the potential benefit of carbon offset payments. As expected, soil improvement and crop yield increase topped the list, with many respondents specifically citing decreased fertilizer use and improved water use efficiency as important benefits. Clean cookstoves were next, followed by the hope of carbon payments. Projected income from selling biochar was somewhat important, and improved sanitation using biochar was also important to some projects. Several respondents also mentioned environmental hygiene from clean- ing up waste in fields and in towns. Regarding the importance of carbon offset payments to project viability, respondents were split. Almost exactly half said that carbon payments would be nice but that they were not counting on them. Then, one remaining quarter said their project could not do without carbon pay- ments and the other quarter replied they were not going to pursue them at all. Note 1. E. Ferreira, personal communication, 2012. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 CHAPTER 7 Potential Future Involvement of Development Institutions, Including the World Bank Biochar: Knowns and Unknowns This report has provided a current review of opportunities and risks of biochar systems, particularly in developing-country settings and for smallholders. By compiling a state of the art overview of current knowledge regarding biochar science, the report offers a reconciling view on different scientific opinions about biochar and biochar systems and offers an overall picture of the various advanta- geous perspectives of its science and application. In thoroughly reviewing the science around the soil and agricultural impacts of biochar application, the report shows the crucial importance of context, implying that no ready-made solutions exist as to what would constitute the ideal combination of feedstock waste, biochar pyrolysis unit, and biochar-to-soil application. However, through an in-depth survey of biochar systems currently in use around the world, the report contextualizes the current state of scientific knowledge on biochar. It also contributes new findings through the ISO-based life-cycle analyses of three dif- ferent biochar systems in various contexts. In this chapter, some forward-looking suggestions are derived from the findings of previous chapters. The aim here is also to show how development institutions, including the World Bank, could support continued research and beneficial application of biochar in development. Biochar and biochar systems, particularly on smaller scales and in developing- country settings, are a rather new proposition that might well prove to have posi- tive impacts on the development–climate nexus under certain conditions. Potential areas of intervention could be manifold. Biochar systems can poten- tially link different sectors that are responsible for the promotion of green growth and development. Examples include situations where true waste streams can be successfully targeted and pyrolyzed with adequate technology, and the resulting biochar can then be applied to agricultural production systems. For example, a biochar system can offer a green waste management solution, which in addition leads to increased soil productivity, higher yields, and hence increased overall agricultural climate resilience. In fact, the life-cycle assessments con- ducted for this report show that a biochar system must include soil benefits to Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   143 144 Potential Future Involvement of Development Institutions, Including the World Bank have greater emission reductions than bioenergy based on full combustion of biomass, and improved crop growth may provide in many cases greater financial returns to farmers than potential carbon markets. These gains in agricultural production in certain areas can be critical to reduce pressures on land. In this perspective, biochar can help address one of the most complex drivers of deforestation and improved use of biochar cookstoves could lead to lowered ­ settlements of BC in the cryosphere. ­ However, as the previous chapters have shown, there are a number of ­ uncertainties that need to be addressed in order to be able to proactively identify “no-regret” biochar interventions. In addition, it is important that decision tools are available to choose the appropriate biochar system technologies by recognizing the variability in design that will be required to respond to local ­ environmental, agronomic, and social constraints and opportunities. Further Research Needs In general, the amount of funds that go into research and experimentation has not reached the level needed to scale up specific biochar systems comfortably. Life-cycle assessments (such as those described in this report) that indicate very practical directions for low-risk biochar opportunities are only beginning to appear in developing-country contexts, and in particular for small-scale systems. Issues regarding data quality and availability (especially time series data) for this kind of exercise nonetheless call for a fully monitored approach with replication of promising systems. Among the areas that deserve further research and assess- ment are the effective targeting of feedstocks that can be considered “true wastes,” that is, they do not lead to a change in land use patterns with undesired leakage effects elsewhere, among other criteria. Furthermore, the development of pyrolysis units with technological specifications appropriate for developing countries is an area of further work. The biochar-to-soil application process, and the resulting effects on soil quality and yields, deserves further attention. A­ categorization of different biochars and their biochemical properties (resulting from different feedstocks and pyrolysis conditions) is a priority area for future work. This, in turn, would allow for better prediction of fertility effects, ­ depending on the soil types and crops to which these biochars are applied. This knowledge will need to be made accessible to farmers either directly or via developing-country extension services and similar institutions. The above clearly shows that further research is needed on many aspects of biochar systems, such as biochar characterization and soil health and productiv- ity, but also on social aspects of biochar systems related to technology adoption. For instance, research is lacking on the increased workload that can come with certain biochar systems, which in turn could make them unattractive to farmers and women in particular. The life-cycle assessment in this report looked prelimi- narily at the impact on labor and suggests great variations between different biochar systems in terms of labor savings and increases. Another much-needed investigation would examine the viability of systems relying on small quantities Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Potential Future Involvement of Development Institutions, Including the World Bank 145 of biochar. Proof-of-concept experiments to date have tended to use rather large quantities of biochar (in many cases over 10 tonnes per hectare), on small areas, to increase the likelihood of clear and publishable results. However, this does not always reflect well the actual limitations of smallholders in developing countries, who often have both limited available true waste feedstock for pyrolysis and limited production technology capacity, as is the case typically with stoves. Low application rate studies are needed to identify the impact of quantities of biochar as low as half a tonne per hectare or less on agricultural systems. Such studies would particularly benefit from a time series perspective. The above suggests that it would be counterproductive to solely see these research needs as a purely academic effort. Scientific findings based on experi- ments conducted largely isolated from real-world developing-country conditions do only help to a limited extent in explaining many crucial aspects that relate to the introduction and ultimately successful adoption of a new technology such as biochar systems in a development context. There is a need to take a broader perspective in biochar studies, taking into account the trade-offs in the use of limited resources such as biomass and nutrients at the local level. While there may be accumulating evidence that specific biochar systems can deliver on the “triple win promise” (energy, climate, and food), all evidence indicates that no such specific biochar system can work as a silver bullet over large areas without considering local conditions. Applied and long-term oriented research at scale of implementation thus seems to be an essential requirement. Here, institutions like the World Bank, particularly through its technical advisory and convening services, could help to forge effective alliances between the research community and development practitioners on the ground. A concrete example could include the establishment of an inventory of ongoing biochar studies in developing countries with a view to setting up long-term biochar study sites. One of the most critical gaps in knowledge regarding the value of modern biochars for agriculture and climate change mitigation precisely relates to the temporal brevity of most experiments. The Global Inventory of Long-Term Soil-Ecosystem Experiments, established by the Duke’s Nicholas School of the Environment and Earth Sciences, is a good example of how such an applied scientific approach could work.1 To date, only one developed-country biochar study is part of this network. The setting up and implementation of such a network across several different developing countries could be a concrete item for multilateral and bilateral donor support. As this body of experiences expands, it will be possible to refine the criteria of desirable biochar interventions. The definition of these criteria could progres- sively lead to the establishment of biochar sustainability standards, which could then serve as a basis for policy regulation or certification schemes. Sustainability standards that take into account the multiple risks along the biochar chain (from biomass sourcing to production and soil application) are key to create consumer confidence, attract finance, and catalyze it toward sustainable biochar applica- tions. Preliminary standards could be developed early, despite the gaps in knowl- edge, before an extensive period of testing throughout very different biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 146 Potential Future Involvement of Development Institutions, Including the World Bank experiences. Such standards are needed to provide guidance to project develop- ers on low-risk and viable biochar routes, also providing them with an alternative to thorough and costly life-cycle assessments. Supporting the Early Adoption of Biochar Systems To assist in the uptake of biochar projects, development institutions such as the World Bank could engage in knowledge- and technology-oriented services, as well as financing services for biochar projects or programs. Knowledge services could, for example, target the development of carbon finance-related method- ologies for different biochar systems, which would ultimately provide a public good allowing for different developing-country stakeholders to create carbon assets based on biochar systems. Fully capturing and monetizing the climate change mitigation-related potential of biochar systems may initially be impor- tant, given the challenge to adapt (some of the) smallholder-driven biochar sys- tems into a financially sustainable proposition. If, fundamentally, the viability of biochar systems for smallholders depends first and foremost on visible and sus- tained gains in soil quality and agricultural production, reaping potential carbon benefits could improve the overall economics of a given biochar system during periods of transition. At present, access to carbon markets is restricted, as was shown in the section titled “Engagement with Carbon Markets” in chapter 6. This is mainly due to the fact that no appropriate methodologies exist that would be able to quantify and convert the multiple climate change mitigation benefits of biochar systems along the entire value chain into a carbon asset. Returning to the example of a cookstove-based biochar system, it would seem to be of interest to build on currently existing Clean Development Mechanism (CDM) as well as voluntary carbon market methodologies for cookstoves and to broaden their scope to include the specifics of cookstove biochar systems. Today, there are four methodologies approved under the CDM that projects and pro- grams targeting improved cookstoves and reduction of nonrenewable biomass can apply.2 In addition, the Gold Standard has approved one voluntary carbon market methodology applicable to improved cookstoves (ClimateCare 2010). Both CDM and voluntary carbon markets are starting to include a growing num- ber of nonbiochar cookstove-related projects and programs. This shows that even without the added carbon value stemming from biochar, cookstove-based carbon finance operations and, particularly, programs do seem viable in certain develop- ing-country settings. A comprehensive review of these methodologies to identify elements that lend themselves to a biochar cookstove system might be a first concrete step toward the development of a more comprehensive biochar metho­ dology or methodology modules. Such technical work could, for example, be undertaken through knowledge and capacity-building instruments attached to some of the World Bank’s carbon funds. The BioCarbon Fund and the Community Development Carbon Fund have a grant-making capacity-building facility attached to them (called BioCF plus and CDCF plus, respectively). Work funded through those facilities could start with a comprehensive review of Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Potential Future Involvement of Development Institutions, Including the World Bank 147 existing methodology elements and the development of new elements or mod- ules along the value chain of a biochar system. The focus of such new methodo- logy elements might not necessarily be the compliance-based carbon markets in the first place but, rather, the voluntary market, which shows a growing demand for agricultural and land-based carbon assets. After over 10 years of practice in the area of carbon finance it is evident that significant opportunities exist for rural populations to participate in the emerging global carbon market. Biochar application to soil can become one such option once methodologically fully cov- ered by rewarding carbon management. As mentioned before, the World Bank’s carbon funds, administered by the Carbon Finance Unit of the World Bank and the International Finance Corporation, could finance the mitigation potential of biochar systems in parallel with the development of applicable methodologies. The rationale for engage- ment is a clear market failure to reward smallholder-based climate change miti- gation benefits. In addition to climate- and carbon-related finance, the global environment facility (GEF) runs several grant mechanisms that could be used for promoting biochar cookstoves, for example, while improving the sustainability of household biomass use. These grants include the Earth Fund3 (and other private sector development funds), the Sustainable Forest Management Program, and the Small Grants Program (GEF 2003, 2007, 2010). Within the recently approved GEF-5 envelope, one focal area identifies improved biomass cook- stoves as a priority related to energy efficiency and sustainable forest manage- ment (GEF 2009). In addition, the GEF Small Grants Program, which supports the projects of nongovernmental organizations (NGOs) and community-based organizations, can also support cookstove projects (for a full review of potential cookstove-related funding that might apply to biochar cookstoves as well, see World Bank 2011). While public resources are certainly needed for the early demonstration and research and development phases of biochar interventions, it will be crucial to also involve the private sector and stimulate opportunities for private investment early on. The step from publicly supported pilots to commercial viability is often the most difficult phase for many technologies and certainly also for biochar sys- tems. Murphy and Edwards (2003) have called this critical transition period the “valley of death” and biochar system technology in a developing-country context will have to deal with this phenomenon. The valley of death is characterized by high investment costs and significant risks so that projects can easily fail. This is where neither technology-push nor market-pull forces have sufficient strength to bring a new technology to market viability. In this situation, neither the public nor the private sector might consider financing commercialization. This funding gap is particularly problematic for technologies with long lead times and a need for considerable applied research and testing between invention and c­ ommercialization, as is the case for many energy technologies (Norberg-Bohm 2002). Therefore, innovative financing solutions such as, for example, trying to front- load potential carbon benefits of biochar systems might help to fill the financing gap in order to bridge the valley of death. Different instruments could be applied Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 148 Potential Future Involvement of Development Institutions, Including the World Bank with the basic idea that the future stream of carbon emission reductions would be commercialized at the financial closure of the project. Thus, the up-front pay- ment can contribute to the financing of the project even though the emission reductions are materialized and delivered at a later date once the project is com- missioned and starts operation. In order to do such front-loading with the idea of attracting private investors early on, the emission reduction seller (that is, the entity operating the biochar system and implementing the project or program) would need to guarantee the investor a portion of the emission reduction deliv- ery through a shortfall agreement, based on which the seller commits to pay for any emission reductions not delivered to the buyer at a pre-agreed price. Such a shortfall agreement is necessary to hedge against project and regulatory risks (that is, the stream of emission reductions does not materialize at all or not to the extent projected, or emission reductions generated are not eligible under an international trading scheme). These are still early ideas, but in principle, institu- tions such as the World Bank, particularly through their private sector-oriented branches, could possibly guarantee the aforementioned payment obligation of the seller based on an indemnity agreement between the seller and the Bank. It becomes clear that a certain level of sophistication is needed for such a setup and that institutions such as the World Bank would most likely not be able to offer such guarantee structures on a project-by-project basis but rather for a project aggregator or related entity working at larger scales (it could even be sovereign governments that bundle a program of biochar systems implemented for devel- opment purposes). There are numerous ways in which biochar and biochar systems may provide “triple win” benefits in developing countries, and many ways that development institutions may help to facilitate and improve them. Direct financing of biochar projects is an important way in which the World Bank and other organizations can provide targeted and essential support to ensure sustainable development of biochar systems. As part of this process, a fund could be set up to convene open- source technology developers to accelerate technology development for small- holders, along the lines of the Global Alliance for Clean Cookstoves. Scaling Up Biochar Systems from Pilot to Program A deeper economic understanding of developing-country biochar systems is emerging. In many instances crop growth benefits for the rural household seem to outweigh the potential financial benefits of carbon markets, at least for the time being. Ultimately however, carbon mitigation-related financial revenues, which at present cannot be fully internalized due to the lack of applicable methodologies, may help to spur adoption rates. Biochar systems are a nascent technology and the private sector is not likely to easily engage on larger scales in developing-country situations due to some of the technical unknowns as well as the (soon to be pre- dictable) variability described earlier. Therefore, institutions such as the World Bank and particularly the private sector arm of the World Bank, the International Finance Corporation, are key players in providing financing services for biochar Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Potential Future Involvement of Development Institutions, Including the World Bank 149 projects in developing countries over the next few years. Publicly funded demon- stration, research, and development will need the engagement of bilateral and multilateral development institutions. Initial guidance on a number of criteria to support decisions on the allocation of funding for biochar projects has been given in previous chapters of this report. In sum, the feasibility of biochar pilots may be rapidly assessed when considering key questions such as the following: 1. Will the biomass be sourced from true waste sources? Possible indicators here include that (a) in the absence of pyrolysis a net cost would arise associated with management of this waste biomass; (b) the waste would otherwise be combusted without energy capture; or (c) the waste would decompose in landfills without contribution to soil nutrients and carbon. 2. Will the feedstock be sourced from safe materials? Possible indicators should assess the toxicity of wastes, in particular from urban origins. ­ 3. Will the quantities of biochar required match the availability of suitable feedstock locally? Possible indicators include (a) quantities of sustainable feedstock available on-farm; and (b) the potential to incorporate biochar in high-value cropping systems, such as vegetable gardens. 4. Will the pyrolysis system meet certain levels of conversion efficiency and ­cleanliness? Possible indicators include (a) methane emissions from the specific pyrolysis technology chosen; (b) a minimum threshold for carbon efficiency as a fraction of biomass input; and (c) emissions of particulates and toxic volatile ­ products of incomplete combustion. 5. Will the appropriate biochar be applied to appropriate soils? Possible indicators here include (a) a modification in soil pH toward the optimum range (for example, 5.5–6.5 for most cereals); and (b) a higher water-holding capacity of biochar particles relative to the soil particles in environments limited by w ­ ater. 6. Will it be practical during monitoring activities to verify carbon storage of biochar through its application to soils? Possible indicators can relate to (a) the v­ ariability of the biochar produced with regard to properties that determine its stability; and (b) difficulty of determining whether biochar is applied to soils rather than combusted for energy. 7. Will local farmers likely adopt the technology after the demonstration phase? Pos- sible indicators include (a) whether access to land is constrained and whether gains in agricultural productivity is a social priority; (b) estimates of increased or reduced workload for women; and (c) generation of new and valuable en- ergy services. Apart from the fact that biochar systems are an area for public climate financ- ing due to their mitigation potential, their major cobenefits do clearly qualify for additional funding sources related to themes such as energy access for the poor, improved rural health, and other environmental, agricultural, social, health, and economic benefits. Facilitating the necessary applied and long-term research, and providing knowledge services such as carbon finance methodologies, are other key ways Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 150 Potential Future Involvement of Development Institutions, Including the World Bank that organizations such as the World Bank could assist in building the knowl- edge base required by these nascent technologies. A feedstock survey to iden- tify geographic regions with waste disposal problems could assist in indicating where initial deployment efforts can concentrate, serving as a roadmap for future development. Research and development programs should be integrated with other initiatives, given the wide-ranging potential of biochar systems. For example, ­ research on integrated food-energy systems (FAO 2010) could include ­ biochar, building on the typology effort outlined in this report. Having a variety of production techniques available in a community could maximize the benefits of biochar to that community. Biochar-making stoves have many great advantages, but they may not produce enough biochar in the short term for large-scale row crops. There is potential for synergy through introducing biochar technology into communities at a range of scales, from stoves to make biochar for household uses (kitchen gardens, water filtration, s ­ anitation), to larger units to make biochar commercially, with possibilities for electricity production or heat generation for crop drying or commercial cooking, brewing, and other activities. ­ Expanding on the theme of coordination with other efforts, ways should be found to integrate biochar into existing charcoal economies and clean charcoal efforts. Charcoal is in widespread use in much of the developing world as a fuel. In many cases the charcoal made as fuel would be perfectly suitable as biochar. Such an approach could help address the current unsustainability of charcoal production by using residues rather than forests, and using cleaner technology that is far more efficient than traditional methods. The Pro-Natura process is one example, the Adam retort kiln is another. Both of these were designed initially for better fuel charcoal, not biochar, but both are now being used to make bio- char. From the standpoint of risk and investment, then, clean charcoal making is a low-risk investment, because even if the market for charcoal as biochar does not materialize, it is still a valuable product that can be sold as fuel or used for other purposes such as water filtration and sanitation. This helps avoid the “valley of death” in commercialization. From the standpoint of climate mitigation, clean charcoal is also a low-risk strategy. It is best if most of the charcoal produced gets used in agriculture, but even if it is used as fuel, if it substitutes for traditionally made charcoal, it has a positive climate benefit. Finally, it is clear that detailed analyses of current projects need to be carried out across their life cycle in order to assess the costs and benefits, particularly with regard to climate, energy production, and food security. The LCA projects described in this report should be followed up over time, and new ones added. A project catalog should be maintained, and data collection should continue for all biochar projects. Lessons learned will be extremely valuable for future projects and programs, and systematic and robust systems should be set up for collecting Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Potential Future Involvement of Development Institutions, Including the World Bank 151 data that can be of scientific value in demonstrating the implications of biochar systems for crops, climate, and human well-being. Notes 1. Global Inventory of Long-Term Soil-Ecosystem Experiments: http://www.nicholas. duke.edu/ltse/. 2. (a) AMS I.C, version 18; (b) AMS I.E, version 4; (c) AMS II.G, version 4; and (d) AMS I.I, version 1. 3. Global Environment Facility website: The GEF Earth Fund http://www.thegef.org/ gef/node/1293. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 APPENDIX A Survey Results Part I The survey had a number of open-ended questions and a space for general com- ments. This open-ended feedback was useful for identifying previously unknown applications and techniques. Open-ended questions also allowed for the capture of a list of crops grown with biochar and a list of feedstocks used to make bio- char. A question about project goals highlighted that people are interested in biochar for many different purposes, including scientific research, development outcomes, climate impact, and commercial results. The results included here are those not shown directly in chapter 4. Figures A.1 to A.4 present some introduc- tory data about the characteristics of the projects. The sample size of n=149 represents 149 complete survey responses. Figure A.1  Project Phase (n = 149) Phase 4 the project is mature: it has Phase 5 the mature become integrated into project has begun to the local economy, 6 seed other projects, 3 Phase 3 the project has its first measurable results, 30 Phase 1 still putting together new ideas, partnerships, and funding, 63 Phase 2 a pilot project is on the ground, 47 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   153 154 Survey Results Figure A.2  Project Location (n = 149) City, 21 Small town or peri-urban area, 33 Rural area, 95 Source: World Bank. Figure A.3 Utilization of Biochar Product (n = 442) Sanitation, For sale as soil 17 amendment, 62 Land Remediation, 73 For sale as fuel, 20 Fuel, 22 Other, 32 Field crop for Home kitchen market, 67 garden, 54 Field crop subsistence, 95 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey Results 155 Figure A.4 Biochar Pretreatments and Added Amendments (n = 359) Minerals Chemical fertilizer such as lime (NPK) added, 54 added, 17 Other, 21 Manure added along with Biochar used biochar, 40 by itself, 72 Human urine is added, 14 Inoculated with beneficial micro-organisms, 26 Composted Composted with with human similar plant waste, 8 Composted material, 58 with manure, 49 Source: World Bank. Note: NPK = nitrogen, phosphorus, and potassium (fertilizer). Part II Figures A.5 to A.10, and tables A.1 to A.6, present data on factors surrounding projects, including social and cultural barriers and means of overcoming them; existence of biochar as a traditional practice; problems accessing biochar sup- plies; benefits foreseen from biochar projects; and the importance of carbon offset payments. Figure A.5 Barriers to Implementing Biochar Systems (n = 39) Social, 11 Other sociocultural barriers, 14 Gender, 4 Cultural, 10 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 156 Survey Results Table A.1  Description of Barriers to Implementing Biochar Systems Open-ended response to question:, “If you checked any of the items in the previous question, please describe the context and impact of the sociocultural barriers you encountered. Were the barriers related to biochar production or to application of biochar to soil?” Number of similar Description of biochar sociocultural barriers responses People resist new approaches for development 3 Not enough biochar available to make a difference 3 Lack of technology for biochar production 3 Education, the farmers/authorities have no idea what biochar can do. Education 3 programs are needed Farmers are skeptical—they don’t believe that the biochar is worth the cost and 2 time Relates to the application of biochar into the soil 1 Only young people are interested in biochar application 1 Language—much biochar information is in English only 1 Labor—slash and burn is more labor effective and gives short fast effect on 1 crop yield It might cause deforestation 1 Feedstock collection—it is difficult to collect feedstocks that are scattered and 1 abundant all over the city in the form of spent coconut shells and husks, construction site leftovers, and garden wastes Farmers are worried about its environmental safety 1 Source: World Bank. Table A.2  Ideas for Overcoming Barriers Open-ended response to question:, “Please describe any solutions you have thought of or tried in order to overcome social or cultural barriers to adoption of biochar systems.” Number of similar Ideas for overcoming barriers responses Lack of information—need to educate and demonstrate via small trials, farm 12 visits, participatory research, agricultural extension Technology access—development of indigenous technology 3 Cost-effectiveness—set up markets and carbon credits 2 Language barrier—working with local NGO and an English-fluent liaison 1 officer Money—get more money 1 Not enough biochar available for field crops—use it for vegetables 1 Biochar application—if funds could be made available for tractors to offer tilling 1 of lands with biochar for selected farms at different locations within this farm- ing district, others will follow suit Source: World Bank. Note: NGO = nongovernmental organization. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey Results 157 Figure A.6  Biochar as a Traditional Practice (n = 44) Yes , 16 No, 28 Source: World Bank. Table A.3  Biochar as a Traditional Practice All answers to the open-ended question:, “If you answered yes to the previous question, please describe the local tradition of adding black carbon char (not ash) to soil. How strong is this tradition? Is it being practiced today? Is the existence of this tradition helpful in facilitating the adoption of new biochar methods?” “It is practiced by a few, although they don’t know the other advantages of application. It has been helpful in some areas, and is now being adopted in other areas.” “This practice is strong in the Mekong delta region but not in central coastal Vietnam. In the Mekong area, there is industrial-scale use of rice husk biochar in agriculture, but not in central Vietnam (except for nurseries).” “Historically added accidentally as part of slash-and-burn system, where larger branches became buried under hot ash and pyrolysis took place, forming charcoal—much of the response of new crops may have resulted from this.” “Within the agroforestry systems practices in the state of Karnataka, India, most farmers practice burning of “waste” materials, including prunings from tree crops, collected weed biomass, and other residues. This typically occurs directly on agroforestry fields. Although most of material is typically reduced to ash, there is likely to be creation of some amount of black carbon residuals that are incorporated into the field. Although not consciously or effectively practiced, black carbon incorporation is, to an extent, occurring.” “Sometimes the farmers get biochar through burning biomass in the field. They randomly apply the biochar in the soils.” “The farmers add the charcoal dust to soils for improving the status of soil fertility. They have experi- ence of the coal production method and the impact of its dust in improving agricultural soils.” “It is a tradition known by the local elders but I have failed to locate any traditional owner doing it. However, I have created strong ties with the up-and-coming traditional owners who are traditional artists and they are getting me access to previously unreleased information.” “In India, older generations used to add cow dung cakes and ash to the soil along with char from wood to the fields to improve the carbon content of soil.” table continues next page Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 158 Survey Results Table A.3  Biochar as a Traditional Practice (continued) “Locally, it is a tradition here to plant ornamented trees in gardens and homes with what we call black soil, but not charcoal or biochar, and this knowledge makes it easier to explain biochar to the people, but the will to change overnight is the problem now, which needs complete orientation and education on radios and so on before we make headway.” “Mango farmers use black soil from an old dump site for nursery of their seedlings and so on, and this practice makes sense to them when NRO preaches the gospel of biochar to them, but what is left is massive adoption by all farmers. Our vegetable farmers and nurseries operators here rely solely on black soil from the old dump site most of the time, so this theory helps them understand the concept.” “Charcoal has been used by hobby gardeners and professionals, including in nurseries for growing orchids. Rural people also add black ash from traditional fire stoves to their garden soil.” “The ancestors of farmers in this area used to put the black carbon char in the land that was used for growing rice, especially in the area that lacked fertile soil. After the government promoted the use of chemicals 60 years ago, the tradition of using black carbon char for farming disap- peared. However, at present, some farmers still see the black carbon char remaining in some areas of the farm that people in the old time period had used. Because of having this old tradition, we expect that the obstacles to the promotion of using the new biochar method will ­ be less.” “Local people use the term kono for agricultural wastes that are piled and then burned; while the coals are lit, farmers spread the coals around the garden using a specific tool called a konot. Until today, the tradition still exists, and we hope that it will become the starting point for biochar production.” Source: World Bank. Figure A.7  How Projects Cope with Limited Supplies of Biochar (n = 67) Incorporating small amounts in fields every year until desired application rate is reached, 13 Other, 21 Coating seeds with biochar to make seed balls, 2 Banding biochar in planting rows, 9 Prioritizing biochar for use in seedling Using small nursery, 10 amounts of biochar in planting holes for seedlings, 12 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey Results 159 Table A.4  Additional Ways to Cope with Limited Biochar Supplies Responses to the open-ended question:, “If you like, please provide additional information about your biochar application rates and your ways of coping with limited supplies of biochar.” Number of similar Other responses to limited biochar supplies responses “Making more biochar—developing new production technology” 9 “Limiting our work to small experimental plots or nurseries” 5 “Using charcoal made for fuel use” 2 “We are banding around the canopy line of tree crops” 1 “Prioritizing use as follows: 1. vegetable plots; 2. rice fields; and 3. the area that 1 we plant trees that can be used for producing energy (called Jatropha curcas)” “Maximizing the multiple functions of biochar such as the bacteria carrier, using 1 it as one of the components for fertilizer” Source: World Bank. Table A.5  Ranking of Benefits Project Developers Believe Will Accrue to Project Participants Responses to the question, "How important are the following benefits to your project participants?" Not Somewhat Very important important important Total n % n % n % n % Soil improvement and soil conservation 1 2.3 5 11.4 38 86.4 44 100 Crop yield increase 2 4.3 3 6.5 41 89.1 46 100 Wages from production or processing of biochar 19 44.2 14 32.6 10 23.3 43 100 Income from sales of biochar 13 31.0 15 35.7 14 33.3 42 100 Improved sanitation using biochar 19 45.2 8 19.0 15 35.7 42 100 Water filtration using biochar 17 42.5 12 30.0 11 27.5 40 100 Cleaner cookstoves or kilns and improved air 17 40.5 8 19.0 17 40.5 42 100 quality Saving of labor or money to acquire fuelwood 18 46.2 10 25.6 11 28.2 39 100 Carbon offset payments for clean cookstoves 17 41.5 13 31.7 11 26.8 41 100 or kilns Carbon offset payments for use of biochar 9 22.0 17 41.5 15 36.6 41 100 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 160 Survey Results Table A.6  Further Description of Project Benefits Responses to the open-ended question: “If you wish, please provide further descriptions of the ben- efits expected from the project.” Number of similar Additional benefits from biochar systems responses Increased sustainability by avoiding chemical fertilizers 7 Increased fertilizer use efficiency 6 Increased water use efficiency 5 Decreased N2O and other GHG emissions 3 Environmental hygiene through waste reduction—fields 2 Environmental hygiene through waste reduction—cities 2 Improved pest resistance 1 Source: World Bank. Note: GHG = greenhouse gas; N2O = nitrous oxide. Figure A.8  Responses to Ranking of Importance of Carbon Offset Payments to Project Finances (n = 46) Very important our project is not Not important we economically feasible have no plans to without carbon pursue carbon payments payments, 12 to help support the project, 11 Somewhat important carbon payments would really help, but we can do without them, 23 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey Results 161 Figure A.9  Responses to the Question of Who Would Receive Carbon Offset Payments from Biochar Projects (n = 35) Farmers will receive payments directly, 12 Other, 12 Biochar producers other than farmers Payments will go to an will receive NGO that is organizing payments, 3 the project, 8 Source: World Bank. Note: NGO = nongovernmental organization. Survey Interpretation Figures A.10, A.11, and A.12 present some analysis and interpretation of the survey results. Figure A.10  Typology of Biochar Systems by Scale and Feedstock Showing Number of Projects with Each Type of Energy Recovery (n = 154) Regional Cooperative/ village Scale Farm Household This circle size indicates n = 2 projects te te te e ds ar r he ur ch as as as ee an Ot w w w W d M an ce d op oo Ri sh Cr W a Sl Feedstock None Cooking Heat Electicity Oil Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 162 Survey Results Figure A.11  Typology of Biochar Systems by Energy Recovery and Feedstock Showing Number of Projects at Scale (n = 154) Oil Electricity Heat Energy Cooking None te te te e ds ar r he ur ch as as as ee an Ot w w w W d M an ce d op oo Ri h Cr W as Sl Feedstock Household Farm Cooperative / Regional village This circle size indicates n = 2 projects Source: World Bank. A dendrogram is generated through the process of hierarchical clustering, where- by each point (in this case, each project) is grouped with similar points, and then these groups are grouped with similar groups, over and over again until there is only one large group, producing a figure that looks like an evolutionary tree. The closer the points are to each other, the more similar they are. The dendrogram was generated using the data on feedstocks, energy use, and scale for each project, and using the “centroid” clustering method. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Survey Results 163 Figure A.12  Project Dendrogram Cooking Electricity Heat Co-op None Cooking Heat None Electricity Farm Other Cooking Heat None Village Electricity Cooking Heat Household None Electricity Heat Region None Oil Source: World Bank. Note: Solid line indicates the level at which branches contain a single project scale, dashed line indicates the level at which branches contain a single energy use, and dotted line indicates the level at which branches contain a single feedstock type. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Biochar Systems Survey: Project Data 164 Table A.7  Summary of Project Data from Survey Project location: Scale of biochar Biochar production ID country Project goals production system technology Energy use Feedstocks used 91 Belize To establish the efficacy of a biochar-based organic fertili­ Cooperative Batch retort kiln No Cacao prunings, zer on the cultivation of cacao and some food crops in shade tree Central America, looking specifically at soil fertility, yield prunings data, soil resilience, and carbon sequestration 118 Burkina Faso The overall objective of the project is the promotion of Cooperative Traditional pit, mound, Cooking—household Peanut and rice renewable energies and environmental protection or brick kiln stalks 35 Cambodia Carbon negative by poor nutrient soil amendment Farm Gasifier Cooking—household, Rice husk food, fuel or crop drying, electricity generation— internal combustion engine 158 Cambodia The main project goal was to characterize the bioenergy/ Farm Gasifier Yes Rice husk biochar system built around the gasifiers installed by SME Cambodia with respect to energy produced, biochar produced, carbon balance, life-cycle assessment of the gasifier, but also the rice product 132 Chile Develop the technology for the production of biochar for Farm Pilot batch reactor No Oat husk, wheat agricultural use and forestry as an amendment to the husk, wheat ground and raw material base for the creation of an straw, and ecofertilizante-controlled release nitrogen compound pine sawdust 31 China The objectives of our project were to investigate biochar Regional Gasifier Yes addition on nutrient cycling (that is N and C) and greenhouse gas emissions from agroecosystems, mainly focusing on rice fields and vegetable ecosystems 70 China The function of biochar addition to soil Village Continuous kiln No 73 China Developing biomass carbon engineering, agricultural ap- Regional Continuous kiln Yes Wheat, corn, and plication of char and related products animal waste 159 China The goal of this project is to develop a policy suggestion on Farm Batch retort kiln No adopting biochar technology to reduce GHG emission to the Chinese government Project location: Scale of biochar Biochar production ID country Project goals production system technology Energy use Feedstocks used 69 Costa Rica Develop production and application standards for com- Farm Batch retort kiln Food, fuel or crop drying, Gmelina mill mercialization electricity genera- waste, bam- tion—thermoelectric boo, oil palm generator bunch waste 95 Costa Rica Primary goal is to test and introduce biochar-producing Household/family Cookstove—top-lit up- Cooking— Coffee prunings clean cookstove to the rural agricultural workers’ popula- draft gasifier (TLUD) household tion in order to address health and deforestation issues; we will also incorporate a biochar demonstration garden in our project design 166 Congo, Dem. The Biochar Fund is in the process of conducting trials Household/family Batch retort kiln No Forest clearing Rep. with farming communities in two selected regions: slash, maize south-west Cameroon and the Equateur province of the stover Democratic Republic of Congo 42 Ghana To prevent burning large quantities of coconut husk, im- Farm Traditional pit, mound, No Coconut husk, prove soil fertility, and remove carbon dioxide to achieve or brick kiln wood from 350 level cleared fields 141 Ghana To use biochar from different feedstocks to improve soil Sawdust productivity 22 India To promote an innovative technology to produce and bury Farm Cookstove—top-lit up- Cooking—household Prosopis juliflora, biochar to sequester carbon and improve soil fertility draft gasifier (TLUD) crop residue, other biomass 125 India To assess the effect of biochar produced from agricul- Cooperative Batch retort kiln No Sugarcane trash, tural waste by ARTI’s charcoaling technology, as a soil maize cobs improvement agent in agriculture. To explore dose dependence of biochar addition on biomass yield. In general, to understand the barriers, if any 155 India To study the long-term (at least five years) impact of biochar Farm Batch retort kiln No Rice, wheat, prepared from the residues of rice, wheat, corn, and corn, and pea pearl millet on productivity in rice-wheat, corn-wheat, crop residues and pearl millet-wheat cropping systems 13 Indonesia Understand the impact of biochar application on growth Farm Batch retort kiln No Rice husk, rice, and yield of crops and soils in lowland farming system straw on Aceh 165 table continues next page Table A.7  Summary of Project Data from Survey (continued) 166 Project location: Scale of biochar Biochar production ID country Project goals production system technology Energy use Feedstocks used 112 Indonesia To get formulation of biochar-based soil conditioner with Farm Batch retort kiln No Rice husk, oil proper composition, shape, and dosage to improve soil palm shell quality 127 Indonesia Evaluating potential and economic feasibility of rice husk Household/family Traditional pit, mound, No Rice husk, small and wood-derived biochars in West Java or brick kiln branches 36 Kenya To improve and sustain our soil fertility for production. We Household/family Traditional pit, mound, Acacia trees also look forward to add human urine in the biochar or brick kiln compost to improve nitrogen in the soil to help in the control effects of striga infections 58 Kenya Remove water hyacinth from Lake Victoria and produce Farm EveryThingNice stoves Cooking—household, Water hyacinth biochar as a by-product of cooking with water hyacinth by WorldStove cooking—institu- from Lake briquettes tional Victoria 131 Kenya This research study provides qualitative and quantitative Household/family Traditional pit, mound, Cooking—household Stalks, sawdust, data collected on the impact of adding charcoal to the or brick kiln dry cow dung soil. It provides preliminary data and information on the effect of charcoal application into the soil; particularly, in improving soil condition 144 Kenya 1. To develop a cheap gasifier stove for rural households. We Household/family Cookstove—top-lit up- Cooking—household Bagasse, wood have four years’ experience with promotion of efficient draft gasifier (TLUD) clay stoves, and we performed successful experiments with metal gasifier stoves. 2. To find appropriate source of biomass for fuel 167 Kenya Cookstove testing and feedstock assessment Household/family Cook stove—Anila, or Cooking— Maize stover annular retort design household 12 Malaysia 1. Production of biochar from rubberwood sawdust, coco- Household/family Cookstove—top-lit up- Cooking— EFB pellets, coco- nut shells and EFB pellets in TLUD, Vesto, and traditional draft gasifier (TLUD) household nut shells stove; 2. Physico-chemical characterization of biochar; 3. Pot assays (CRD) to identify the best biochar type 62 Malaysia To characterize biochar derived from oil palm empty fruit Farm Commercial pyrolysis, Electricity Oil palm empty bunch and investigate its effectiveness as a soil amend- pilot plant generation— fruit bunches ment for vegetables and field crops, and C sequestration internal combustion (EFB) engine Project location: Scale of biochar Biochar production ID country Project goals production system technology Energy use Feedstocks used 28 Mexico Production, application, and evaluation of an inoculated Yes Charcoal fines, biochar mesquite and brush tree, sawdust 128 Nepal Alternative fuel source in rural communities, income gen- Village Batch retort kiln Cooking— Catweed eration, reduce indoor air pollution household, space or hemp heating, food, fuel or agrimony, crop drying, cook- forest wastes, ing— agriculture institutional wastes 105 Nigeria Development of local capability for the production of Farm Batch retort kiln No Coconut shells activated carbons from agricultural wastes 79 Pakistan To compare the effects of various integrated plant nutrient Regional Traditional pit, mound, Food, fuel or crop drying Crop residue, management practices on wheat-based cropping system or brick kiln animal waste, under rain-fed conditions and biopower 50 Philippines Conversion of wood wastes and various agri-wastes into car- Cooperative Batch retort kiln Cooking— Tree bark, fruit bon (white charcoal) for household fuel, soil conditioner, household frond, sawmill water filters. To make people appreciate the value of wastes charcoal in their daily lives 99 Philippines To encourage farmers to organically produce farm products Farm The biochar we used are Cooking— Rice husk intended for human consumption waste products from commercial, electric- rice hulls being used ity as fuel for mechanical generation— dryers in our locality internal combustion engine 154 Senegal Biochar production for local agronomic application Cooperative Pro-Natura pyrolyser No Rice husk Pyro 77 South Africa Determine the effect of biochar application in South African Farm Continuous kiln Yes Plantation waste and perennial orchard environments 82 South Africa To add carbon via fertilizer into soil Regional Pyrolysis No Wood chips and macadamia nut shells table continues next page 167 Table A.7  Summary of Project Data from Survey (continued) 168 Project location: Scale of biochar Biochar production ID country Project goals production system technology Energy use Feedstocks used 117 South Africa To manufacture biochar for use as a soil amendment in the Cooperative Continuous feed retort Food, fuel or crop drying, Eucalyptus, pine, aiREG bio-energy/agroforestry model system electricity genera- and alien tion—thermoelectric vegetation generator 18 Vietnam Finding out the adoptable biochar technology to improve Household/family Batch retort kiln Cooking— Waste from the infertile soil crop yield with safety products and household maize, rice, environment in Vietnam. Determining the good sources wood for BC production and develop in Vietnam 80 Vietnam IBM Food, fuel or crop drying 87 Vietnam Small-scale energy and biochar generation Farm Cookstove—top-lit up- Cooking—household, Rice hulls, coffee draft gasifier (TLUD) food, fuel or crop bean husks, drying wood shav- ings 140 Vietnam Vietnam is an agricultural country with an agricultural land Household/family Cookstove—top-lit up- No of over 9 M ha, of which there are light texture soils, draft gasifier (TLUD) consisting of 530 thousand ha of arenosols, and approxi- mately 4.5 M ha of acrisols (National Institute for Soils and Fertilizers, 1996). These soils are poor 160 Vietnam To improve soil and water utilization in tree crop farming Village Gasifier Cooking— Rice husk systems in central coastal Vietnam institutional Source: World Bank. Note: GHG = greenhouse gas; BC = black carbon. APPENDIX B Case Studies Kenya Case Study Life-Cycle Assessment Data Quality Assessment The survey had a number of open-ended questions and a space for general com- ments. This open-ended feedback was useful for identifying previously unknown applications and techniques. The data quality for each process was assessed using the method from the University of Washington’s Design for Environment Laboratory, based on the guidelines from Ansems and Ligthart (2002). Each process was assigned a data quality score for each indicator on a scale of 1 to 5, 1 being the best, and the average score was calculated for each process, as outlined in the goal and scope. The scoring of the processes is provided in table B.1. The majority of processes received an average score of 2. The process that received the poorest score was bus transport (2.4), because the data were from a diesel bus in the United States in 1998, as emissions data from buses in Kenya were not available. Within the pyrolysis emissions subprocess, higher scores were received in the areas of geography, technology, representativeness, and reproducibility, due to the fact that the emissions data were not a direct measurement, but rather were calculated from ratios of emissions species for a gasifier cookstove. For the bio- char application subprocess, higher scores were received in representativeness, reproducibility, and source, because the data were based on estimates for applica- tion methods. The cookstove production also received high scores in the areas of representativeness, reproducibility, and source, because the cookstoves had not been produced in quantity at that stage. Rather, the data were estimated based on the production of one prototype stove and the experiences of biomass cook- stove researchers. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   169 170 Case Studies Table B.1  Data Quality Scores for Kenya Pyrolysis Cookstove System Representativeness Reproducibility Average score Uncertainty Technology Geography Sources Time Process Primary feedstock, on-farm, as collected 1 1 1 2 1 2 1 1 Primary feedstock, off-farm, as collected 1 1 1 2 1 2 1 1 Secondary feedstock, on-farm, as collected 1 1 1 2 1 2 1 1 Secondary feedstock, off-farm, as collected 1 1 1 2 1 2 1 1 Primary feedstock, on-farm, air-dry 1 1 2 2 2 3 2 2 Primary feedstock, off-farm, air-dry 1 1 2 2 2 3 2 2 Secondary feedstock, on-farm, air-dry 1 1 2 2 2 3 2 2 Secondary feedstock, off-farm, air-dry 1 1 2 2 2 3 2 2 Pyrolysis cooking 1 1 1 1 2 2 3 2 Pyrolysis emissions 1 3 3 2 3 3 1 2 Biochar production 1 1 1 2 2 2 3 2 Avoided traditional cooking 1 3 1 2 2 2 1 2 Avoided residue burning 1 3 2 2 2 2 1 2 Biochar, field application 1 1 1 2 3 3 3 2 Biochar, crop response 1 1 1 2 2 2 1 1 Cookstove production 1 1 1 2 3 3 4 2 Transport, bus 3 4 3 2 2 2 1 2 Source: World Bank. Sensitivity Analysis The parameters tested in the sensitivity analysis are listed in table B.2 (table 5.4 from chapter 5). In order to facilitate the data interpretation, the discussion of each sensitivity test is followed by a list of the results for those impact categories (greenhouse gas [GHG], money, and time) that are relevant to the test (that is, results are not presented if the value does not vary from the baseline). The 1.15–3.02 tonnes of dry matter per household per year range for primary feedstock consumption is based on cooking fuelwood consumption data c ­ ollected by two different methodologies, as described in chapter 5, subsection “Pyrolysis and Cooking.” The results from the low (baseline) and high feedstock scenarios are shown in table B.3. The higher primary feedstock consumption results in a 61 percent higher net GHG reduction because of the larger amount of avoided emis- sions from cooking with a traditional three-stone stove. There is an additional 105 percent time savings with the higher feedstock consumption scenario, again because of the assumed higher fuelwood consumption for ­ traditional cooking. (Note: the functional unit is 1 tonne of dry secondary ­ feedstock, even though the parameter varied in this case is the primary feedstock.) Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 171 Table B.2  Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Primary feedstock (tonnes of dry matter per household per year) 1.15 1.15–3.02 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) +29 –50 to +97 Maize prices ($ per 90-kg bag) 0 18–36 Duration of biochar’s effect (years) 50 1–100 Pyrolysis methane emissions (kg per tonne of dry matter) 1.98 1.64–6.4 Three-stone fire methane emissions (kg per tonne of dry matter) 5.17 0.60–6.4 Fraction of nonrenewable biomass for off-farm wood 0.8 0–1.0 Biochar application rate (tonnes per hectare) 27 2.7–27 Soil nitrous oxide emissions (%) 0 –50 to +50 Fraction of secondary feedstock collected off-farm 0 0–1.0 Source: World Bank. Table B.3  Sensitivity Results for Primary Feedstock Parameter Primary feedstock GHG (tonnes CO2e per Time (hrs per tonne (tonnes of dry matter) tonne of dry matter) Change (%) of dry matter) Change (%) 1.15 −1.8 0 62 0 3.02 −2.9 +61 127 +105 Source: World Bank. Note: GHG = greenhouse gas. Table B.4  Sensitivity Results for Stable Carbon Content of Biochar Parameter GHG (tonnes CO2e per Stable carbon content of biochar (%) tonne of dry matter) Change (%) 0 −1.23 −31 50 −1.57 −11 80 −1.77 0 90 −1.83 +3 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. The stable carbon content is varied in the range 0–90 percent with a baseline of 80 percent. A change in the stable fraction of carbon in the biochar from the baseline of 80 percent to 50 percent lowers the net GHG reductions by only 11 percent (table B.4). Meanwhile, a 90 percent stable carbon fraction increases the net GHG by 3 percent compared to the baseline. Even if the stable fraction of the carbon in the biochar is 0 percent, the net GHG is still −1.2 tonnes of carbon dioxide equivalent (CO2e) per tonne of dry matter. From this analysis it is evident that the stable carbon content of the biochar is not a major driver in the ­ net GHG balance of the Kenya household cookstove system. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 172 Case Studies The methane emissions during pyrolysis were varied in the range 1.64–6.4 kilograms of methane per tonne of dry fuel, based on low and high values found in the literature (table B.5). The low value of 1.64 kilograms of methane is based on low-power gasifier operation (MacCarty et al. 2008), while the high of 6.4 kilograms of methane is for an open fire (Johnson et al. 2008). For the lower emissions of 1.64 kilograms of methane per tonne of dry fuel, the net GHG reductions are increased by only 0.01 percent. On the higher emissions end at 6.4 kilograms of methane per tonne of dry fuel, the net GHG reductions decrease by 10 percent. Even if the pyrolysis cookstove emitted as much methane as an open fire, the net GHG balance for the biochar-producing house- ­ hold would only decrease by 10 percent. This indicates that the pyrolysis cook- stove methane emissions do not dominate the net GHG emissions of the project life cycle within the uncertainty range. The emissions range of 0.60–6.4 kilograms of methane per tonne of dry fuel for traditional three-stone fire cooking is also based on low and high values in the literature (table B.6). The 0.60 kilograms of methane is for a high-power three- stone fire (MacCarty et al. 2008), and the 6.4 kilograms of methane is from the open fire (Johnson et al. 2008). This range highlights the variability in emissions measurement results due to methodologies and experimental procedures, even for seemingly comparable technologies (the open fire and the three-stone fire). A higher methane emissions value for traditional cooking (6.4 kilograms of methane per tonne of dry fuel) results in higher avoided methane emissions, thus a 3 percent increase in net GHG reductions. For lower three-stone fire methane Table B.5  Sensitivity Results for Pyrolysis Emissions Parameter Pyrolysis methane emissions GHG (tonnes of CO2e per (kg of methane per tonne of fuel) tonne of dry matter) Change (%) 1.64 −1.78 +0.01 1.98 −1.77 0 6.4 −1.59 −10 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.6  Sensitivity Results for Three-Stone Fire Emissions Parameter Three-stone fire methane emissions (kg GHG (tonnes CO2e per per tonne of dry fuel) tonne of dry mater) Change (%) 0.60 −1.57 −11 5.17 −1.77 0 6.4 −1.82 +3 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 173 emissions of 0.60 kilograms of methane per tonne of dry fuel, the net GHG reductions decrease by 11 percent. Similar to the pyrolysis cookstove emissions, the three-stone fire methane emissions do not dominate the GHG balance within the uncertainty range. The duration of biochar’s effect on crop productivity is varied from 1 year to 100 years, where the baseline is assumed to be 50 years. The “surplus maize” is the quantity of maize grown in excess of what would be grown without biochar additions over the 1-, 50-, or 100-year duration on the area to which biochar was applied by the household for that year (0.04 hectares). This assumes that the biochar is applied at the specified rate of 18 tonnes of carbon per hectare, rather than over the whole farm at a lower rate. Thus, the following year the family could gain additional benefits from the new area to which the biochar produced in that year was applied. If the $24 per bag of maize value is assigned to this surplus, the revenues are as listed in table B.7. It is important to note that these revenues are summed over the 1-, 50-, or 100-year duration of the biochar’s effect on crop productivity. The net GHG balance changes only ±2 percent due to the effect of soil organic carbon accumulation over the duration of biochar’s effect. Maize prices are ranged from the baseline (no revenue for surplus maize) to up to $36 per 90-kilogram bag of grain, based on Kenya maize prices from 2000 to 2009 (Kirimi 2009). The “maize $” scenarios in figure 5.4 and discussed above utilize a $24 per bag price (based on August 2010 prices). Any monetary value for the maize results in an increased revenue for the household as compared to the baseline. However, one must consider that the baseline situation focuses on responsible household management and places the top priority on the family’s nourishment. If maize grain was sold at the market but food in the home was insufficient, this is obviously a net loss for the family in terms of nutrition and health, regardless of maize sales. The sensitivity analysis compares varying the maize price for both a 1-crop effect and a 50-year effect for biochar on crop yields, where the 50-year effect exhibits strong sensitivity to the maize price. This comparison illustrates the importance of considering the sensitivity of another input parameter: the duration of biochar’s agronomic effect. As the numbers in table B.8 demonstrate, even the lowest price for maize results in significant rev- enues when considering biochar’s 50-year effect. Table B.7  Sensitivity Results for Duration of Biochar’s Effect on Productivity Parameter Duration of Surplus maize Revenue ($ per GHG (tonnes biochar effect on (kg per tonne of tonne of dry CO2e per tonne productivity (yr.) dry matter) matter) Change (%) of dry matter) 1 +15 +3 −99 −1.73 50 +739 +245 0 −1.77 100 +1,478 +491 +100 −1.80 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 174 Case Studies Table B.8  Sensitivity Results for Maize Price Parameter Revenue ($ per tonne Revenue ($ per tonne Maize price ($ of dry matter) of dry matter) per 90-kg bag) 1-crop effect Change (%) 50-year effect Change (%) 0 −1.43 0 −1 0 18 +0.49 +135 +183 +184 24 +1.13 +179 +245 +246 36 +2.41 +269 +368 +369 Source: World Bank. Table B.9  Sensitivity Results for Maize Yield Response Parameter Surplus maize Revenue ($ per GHG (tonnes Yield response (kg per tonne of tonne of CO2e per tonne (%) dry matter) Change (%) dry matter) of dry matter) 1-crop effect −50 −13 −263 −6 −1.72 0 0 −100 −1 −1.73 29 +8 0 +1 −1.73 97 +26 +225 +7 −1.73 50-year effect −50 −1,274 −272 −426 −1.66 0 0 −100 −1 −1.73 29 +739 0 +245 −1.77 97 +2,463 +233 +819 −1.86 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. In order to consider the effect of varying the maize yield response with bio- char amendments, the surplus maize is valued at $24 per bag (even though the baseline assumes no monetary value for the surplus maize). A 1-crop biochar effect is also compared to a 50-year biochar effect in table B.9. The maize yield is ranged from –50 percent (a decrease in yield with biochar additions as com- pared to the control) to a 97 percent increase in yield (the maximum for fully fertilized maize plots from Kimetu et al. 2008). It is probable that smallholder farmers neither have access to the same quantities of fertilizers nor utilize the same farm management techniques as those in the Kimetu study. For this reason, it is possible that maize yields with biochar additions would vary within this range. When there is a 29 percent maize yield increase, there is an 8-kilogram surplus of grain per tonne of dry feedstock per crop, or 739 kilograms surplus grain per tonne of dry matter over 50 years. For the maximum yield increase of 97 percent, the net revenue is +$7 per tonne of dry matter and the surplus grain is 26 kilograms per tonne of dry matter for a 1-crop effect, while a 50-year effect results in $819 and 2,463 kilograms of grain per tonne of dry matter. With no Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 175 change in crop yield, the net revenue actually goes negative and becomes a net cost at −$1 per tonne of dry matter. A 50 percent decrease in yield results in a more than 250 percent decrease in grain yield for both the 1-crop and 50-year biochar effects, and the net revenue is dominated by the lost maize sales. The changes in GHG emissions with a variation in maize yield are in the order of only a few kilograms of CO2e per household per year, which is less than a fraction of a percent in change from the baseline for the 1-crop effect, and a 6 percent change or less for the 50-year effect. Small changes in net GHG are because the effect of yield increases on soil organic carbon is minimal, as discussed in the contribution analysis above. This also corresponds well with Whitman, Scholz, and Lehmann 2010, where the contribution of soil organic carbon to the overall GHG impact is only a fraction of the impact from avoided emissions and stable carbon in the biochar. The fraction of nonrenewable biomass for off-farm wood is varied from 0 to 1, with a baseline of 0.8, as discussed in the life-cycle inventory data (table B.10). This analysis compares results for the 50-year biochar effect. The net GHG reductions decrease by 60 percent to −0.7 tonnes of CO2e per tonne of dry mat- ter when all of the biomass is assumed to be renewable. In this scenario, where the fraction of nonrenewable biomass (fNRB) equals 0, the avoided emissions from traditional cooking with a three-stone fire contribute only −0.2 tonnes of CO2e per tonne of dry matter to the GHG reductions, as compared to the base- line, where avoided three-stone fire emissions are −1.3 tonnes of CO2e per tonne of dry matter. When all of the off-farm wood is assumed to be nonrenewable (fNRB = 1), then the net GHG reductions increase by 15 percent to −2.0 tonnes of CO2e per tonne of dry matter because all carbon dioxide emissions from avoided traditional cooking are included, as there would be no regrowth to uptake carbon dioxide emissions under this scenario. The baseline biochar application rate is 18 tonnes of carbon per hectare, or 27 tonnes of biochar per hectare, where the biochar has an average carbon content of 66 percent. This application rate is relatively high and was used for research purposes, but it is possible that crop productivity improvements can be achieved at much lower application rates. Preliminary studies and unpublished data from Torres (2011) and Lehmann (2011) have seen increases in crop productivity with a biochar application rate of 2.6 tonnes per hectare, which is used as the lower bound for the sensitivity analysis using the 50-year biochar effect (table B.11). Table B.10  Sensitivity Results for Fraction of Nonrenewable Biomass Parameter GHG (tonnes CO2e per fNRB tonne of dry matter) Change (%) 0 −0.71 −60 0.8 −1.77 0 1 −2.03 +15 Source: World Bank. Note: fNRB = fraction of nonrenewable biomass; GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 176 Case Studies Table B.11  Sensitivity Results for Biochar Application Rate Parameter Biochar application GHG (tonnes CO2e Surplus maize Revenue ($ per rate (tonnes per per tonne of (kg per tonne of tonne of hectare) dry matter) Change (%) dry matter) Change (%) dry matter) 2.6 −2.12 +20 7,763 +950 +2,586 10 −1.83 +3 2,018 +173 +671 27 −1.77 0 739 0 +245 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.12  Sensitivity Results for Soil Nitrous Oxide Emissions Parameter Soil nitrous oxide GHG (tonnes CO2e per GHG (tonnes CO2e per emissions (% of tonne of dry matter) tonne of dry matter) baseline) 1-crop effect Change (%) 50-year effect Change (%) −50 −1.74 +0.01 −2.54 +44 0 −1.73 0 −1.77 0 +50 −1.72 −0.01 −1.00 −44 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. At the 2.6 tonnes per hectare application rate, the net GHG reductions increase by 20 percent, while the surplus maize increases an order of magni- tude to 7,763 kilograms per tonne of dry matter. Or, the 10 tonnes per hectare application rate (which is a common application rate for biochar projects) results in a 3 percent increase in GHG reductions while the surplus maize increases to 2,018 kilograms per tonne of dry matter. Varying the biochar application rate has a very strong impact on the quantity of surplus maize produced per tonne of feedstock, that is, the same amount of feedstock is con- verted to biochar but can make a larger impact when the application rate is lower and the biochar can be spread over a larger area (assuming the a­ gronomic effect is the same). Soil nitrous oxide emissions are varied from +50 percent to −50 percent, estimated from literature values (Singh et al. 2010). This analysis compares the 1-crop and the 50-year biochar effects (table B.12). The changes in net GHG reductions are only ±0.01 percent when considered on a 1-crop basis. On a 50-year biochar effect basis, the soil nitrous oxide emissions could play a more substantial role at ±44 percent of the baseline. This analysis emphasizes the need for improved data on biochar’s role in soil nitrous oxide emissions. The fraction of secondary feedstock (such as crop residues and other herba- ceous sources) sourced on-farm is ranged from 0 to 1.0, where the baseline is 0 (meaning all secondary feedstock required for the pyrolysis cookstove is supplied on the farm). This scenario is considered because of the potential need to retain Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 177 all crop residues on the fields for erosion protection, thus requiring off-farm col- lection from sources such as invasive weeds and sawmill wastes. The life-cycle assessment (LCA) assumes that all secondary feedstock collected both on the farm and off the farm is from renewable sources. If residues are collected ­ off-farm, the soil organic carbon depletion from the on-farm residue harvest is eliminated, but the net impact on the GHG balance is small, as this is only a small contribution to the total (4 kilograms of CO2e per tonne of dry matter), as seen in figure 5.3. However, the impact on the net labor of the system would be substantial because of the time spent collecting secondary feedstock off the farm. Although there are no data available specific to how far and what types of ­ herbaceous residues could be collected off the farm, if the time to collect the residues is assumed to be the same as for off-farm wood (and assuming a mois- ture content of 50 percent for herbaceous biomass), then the net labor changes to −65 hours per tonne of dry matter, meaning that even though there are labor savings from reduced off-farm primary fuel collection (as in the baseline ­ scenario), time is now lost due to increased off-farm secondary feedstock collection. Alternatively, if one assumes that secondary feedstock could be ­ collected closer to home and the time to collect is halved, the net labor of the ­ system is −2 hours per tonne of dry matter, thus still a net loss in labor. However, one benefit that would remain under this scenario is that the off-farm harvest of nonrenewable wood for traditional cooking could be replaced by off-farm harvest of renewable herbaceous feedstocks. ­ Vietnam Case Study Life-Cycle Assessment Data Quality Assessment Each process was assigned a data quality score for each indicator on a scale of 1 to 5, 1 being the best. The average of the scores was calculated for each process, as provided in table B.13. The majority of processes received an average score of 2. The process that received the poorest score was the rice wafer stove construc- tion (2.7) because the stove construction and operation are outside the scope of the biochar project. The rice wafers are produced regardless of the biochar proj- ect, and have been for some time, thus it has not been a high priority for the project participants. The next highest score was for the biochar wetting process, as this again is part of the stove operation, and no experimental data have been measured. The moisture content has been estimated, and from this the approxi- mate volume of water needed to wet the biochar. The stove construction, biochar production, and biochar wetting all received scores of 4 in the “uncertainty” category because the mean value, standard devia- tion, uncertainty type, and description of strengths and weaknesses were not available and could be approximated. The nitrogen, phosphorus, and potassium (NPK) fertilizer productions each received scores of 4 in geography because the data are specific to the United States. The data quality assessment highlights that there are concerns over uncertainty and representativeness in the data, and weak- nesses in the data are explored in the sensitivity analysis. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 178 Case Studies Table B.13  Data Quality Scores for Vietnam Rice Husk Biochar System Representativeness Reproducibility Average score Uncertainty Technology Geography Sources Time Process Rice husk, at mill 1 2 1 2 3 2 3 2 Stove production 4 1 1 4 3 3 3 3 Biochar production 1 1 1 4 3 3 2 2 Biochar, wetting 1 1 1 4 3 4 3 2 Biochar, field application 1 1 1 2 2 2 2 2 Manure production 1 1 1 3 3 3 3 2 Transport, bullock cart 1 1 1 3 3 3 3 2 Nitrogen fertilizer production 1 4 2 2 3 1 1 2 P2O5 fertilizer production 1 4 2 2 3 1 1 2 K2O fertilizer production 1 4 2 2 3 1 1 2 Avoided residue burning 1 3 1 2 2 2 1 2 Source: World Bank. Note: P2O5 = phosphorus pentoxide; K2O = potassium oxide. Table B.14   Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Biomass throughput (tonnes of dry matter per year) 26 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) +16 –50 to +47 Peanut prices ($ per tonne) 750 682–818 Rice wafer stove methane emissions (kg per tonne of 2.24 1.64–6.4 dry matter) Avoided rice husk burning methane emissions (kg per 3.71 3.71–25.7 tonne of dry matter) Duration of biochar’s effect (years) 50 1–100 Biochar transportation distance (km) 5 1–25 Soil nitrous oxide emissions (%) 0 –50 to +50 Source: World Bank. Sensitivity Analysis A sensitivity analysis was conducted in order to measure the variability in the LCA results as a function of varying key input parameters. The input parameters that were tested are listed in table B.14 (table 5.12 from chapter 5), and include the fraction of recalcitrant carbon in the biochar, the yield response of peanut crops with biochar additions, the price the farmer receives for peanuts, methane emissions of the rice wafer stove, methane emissions from avoided rice husk burn- ing, the duration of biochar’s agronomic effectiveness, the biochar transportation Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 179 distance, and soil nitrous oxide emissions. In order to facilitate the data interpreta- tion, the discussion of each sensitivity test is followed by a list of the results for those impact categories (GHG or monetary value) that are relevant to the test (that is, results are not presented if the value does not vary from the baseline). The stable carbon content is varied in the range 0–90 percent with a baseline of 80 percent (table B.15). A change in the stable fraction of carbon in the bio- char from the baseline of 80 percent to 50 percent lowers the net GHG reduc- tions by 29 percent. Meanwhile, a 90 percent stable carbon fraction increases the net GHG by 10 percent compared to the baseline. Even if the stable fraction of the carbon in the biochar is 0 percent, the net GHG is still −0.1 tonnes of CO2e per tonne of dry matter. From this analysis it is evident that the stable carbon content of the biochar is a major driver in the net GHG balance of the Vietnam rice husk biochar system. The methane emissions during rice wafer cooking and biochar production were varied from 1.64 to 6.4 kilograms of methane per tonne of dry fuel, based on low and high values found in the literature, where the baseline value is 2.24 kilograms per tonne of dry fuel (table B.16). The low value of 1.64 kilograms of methane is based on low-power gasifier operation (MacCarty et al. 2008), while the high of 6.4 kilograms of methane is for an open fire (Johnson et al. 2008). For both the lower and upper bounds of the emissions, the net GHG reductions change by less than 0.01 percent. This indicates that the pyrolysis cookstove methane emissions do not dominate the net GHG emissions of the project life cycle within the uncer- tainty range. The allocation assigned to the biochar production affects this impact, where if 100 percent of the impacts of rice wafer cooking were assigned to biochar production, then the result changes two orders of magnitude more than at only 0.6 percent allocation, but the net GHG still only change by less than 1 percent. Table B.15  Sensitivity Results for Stable Carbon Content of Biochar Parameter Stable carbon content GHG (tonnes CO2e per of biochar (%) tonne of dry matter) Change (%) 0 −0.1 −77 50 −0.4 −29 80 −0.5 0 90 −0.6 +10 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.16  Sensitivity Results for Rice Wafer Stove Methane Emissions Parameter Rice wafer stove methane emissions GHG (tonnes CO2e per tonne (kg of methane per tonne of fuel) of dry matter) Change (%) 1.64 −0. 51237 < 0.001 2.24 −0.51239 0 6.4 −0.51231 < −0.001 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 180 Case Studies The emissions range of 3.71–25.7 kilograms of methane per tonne of dry fuel for rice husk burning is also based on low and high values in the literature (table B.17). The low value of 3.71 kilograms of methane per tonne of dry fuel is as described in the process data previously (for rice husk burning in smoldering piles). The high value of 25.7 kilograms of methane per tonne of dry fuel is from rice husk piles in a wind tunnel simulating open-air burning (Yonemura and Kawashima 2007). This range highlights the variability in emissions measurement results due to methodologies and experimental procedures, feedstock material, and environ- mental factors. A higher methane emissions value for avoided burning results in higher avoided methane emissions, thus a 0.8 percent increase in net GHG reduc- tions. Similar to the rice wafer stove emissions, the avoided rice husk methane emissions do not dominate the GHG balance within the uncertainty range. The duration of biochar’s effect on crop productivity is varied from 1 year to 100 years, where the baseline is assumed to be 50 years (table B.18). The “surplus peanuts” are the quantity of peanuts grown in excess of what would be grown without biochar additions over the 1-, 50-, or 100-year duration on the area to which biochar was applied by the farmer. This assumes that the biochar is applied at the specified rate of 20 wet tonnes per hectare. The $750 per tonne value is assigned to the peanut surplus. It is important to note that these revenues are summed over the duration of biochar’s effect on crop productivity (from as short as 1 year to as long as 100 years). Note also that there are two cropping seasons per year. The net GHG balance varies 20–30 percent, primarily due to the avoided phosphorus and potassium fertilizers and also to the effect of soil organic carbon accumulation to a smaller extent. Peanut prices are ranged from $682 to $818 per tonne, with a baseline of $750 per tonne, based on Vietnam peanut prices in that region.1 The sensitivity analy- sis compares varying the peanut price for the 50-year effect for biochar on crop Table B.17  Sensitivity Results for Rice Husk Burning Methane Emissions Parameter Rice husk burning methane emissions GHG (tonnes CO2e per (kg methane per tonne of fuel) tonne of dry matter) Change (%) 3.71 −0.512 0 25.7 −0.516 +0.8 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.18  Sensitivity Results for Duration of Biochar’s Agronomic Effect Parameter Duration of Surplus peanut Revenue ($ per GHG (tonnes biochar’s effect on (kg per tonne of tonne of CO2e per tonne of productivity (yr) dry matter) dry matter) Change (%) dry matter) 1 +16 +15 −98 −0.4 50 +822 +948 0 −0.5 100 +1,644 +1,900 +100 −0.6 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 181 yields. As the numbers in table B.19 demonstrate, even the lowest price for pea- nuts results in significant revenues when considering biochar’s 50-year effect, where the change in the net economic balance is relatively small, at ±6 percent. In order to consider the effect of varying the crop yield response with biochar amendments, a 1-crop biochar effect is compared to a 50-year biochar effect in table B.20. The peanut yield is ranged from −50% (a decrease in yield with biochar additions as compared to the control) to a 47 percent increase in yield (the maxi- mum percent increase for peanut plots receiving biochar alone compared to no amendments) (Slavich et al. 2010).2 At the baseline value of 16 percent, there is an 8-kilogram surplus of peanuts per tonne of dry feedstock per crop, or an 822-kilogram surplus per tonne of dry matter over 50 years. For the maximum yield increase of 47 percent, the net revenue is increased to +$19 per tonne of dry matter and a surplus of 24 kilograms of peanuts per tonne of dry matter for a 1-crop effect, while a 50-year effect results in $2,158 and 2,423 kilograms of pea- nuts per tonne of dry matter. With no change in crop yield, the net revenue decreases but remains positive for both the 1-crop and 50-year effects, as the offset manure and fertilizer still provide savings. A 50 percent decrease in yield results in a more than 400 percent decrease in peanut yield for both the 1-crop and 50-year biochar effects, and the net revenue is dominated by the lost peanut sales. The changes in GHG emissions with a variation in crop yield are less than a fraction of a percent from the baseline because the effect of yield increases on soil organic carbon is minimal, as discussed in other case studies. Table B.19  Sensitivity Results for Peanut Price Parameter Peanut price ($ per tonne) Revenue ($ per tonne of dry matter) Change (%) 682 +892 −6 750 +948 0 818 +1,004 +6 Source: World Bank. Table B.20  Sensitivity Results for Yield Response Parameter Surplus peanuts Revenue ($ per (kg per tonne of tonne of Yield response (%) dry matter) Change (%) dry matter) Change (%) 1-crop effect −50 −26 −425 −19 −400 0 0 −100 +1 −86 16 +8 0 +7 0 47 +24 +200 +19 +157 50-year effect −50 −2,590 −415 −1,612 −270 0 0 −100 +331 −65 16 +822 0 +948 0 47 +2,423 +195 +2,158 +128 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 182 Case Studies The transportation distance of the biochar is ranged from 1 to 25 kilome- ters, with a baseline of 5 kilometers (table B.21). Even at a distance of 25 kilometers, the net revenue decreases by only 3 percent for the 50-year biochar effect, corresponding to the increased transportation cost of $2.05 per tonne- kilometer of biochar. However, considering a 1-crop effect, a 25-kilometer distance makes the yearly net revenue negative at −$17 per tonne of dry mat- ter. In fact, a biochar transportation distance greater than 10 kilometers will cause the yearly net revenue to go from a positive to negative balance for the 1-crop effect. Therefore, even with a 50-year biochar effect, if transportation distances for the biochar are farther than 10 kilometers, it is possible that the first few peanut seasons may see a net loss, which is balanced by increased revenues in later years. Soil nitrous oxide emissions are ranged from +50 percent to −50 percent, estimated from literature values (Singh et al. 2010) (table B.22). This analysis compares the 1-crop and the 50-year biochar effects. The changes in net GHG reductions are ±1 percent when considered on a 1-crop basis, demonstrating that biochar’s effect on soil nitrous oxide emissions are minimal when consid- ered only in the short term. However, for the cumulative 50-year biochar effect, the soil nitrous oxide emissions could play a more substantial role at more than ±100 percent of the net GHG of the baseline. The change in soil nitrous oxide emissions as a result of biochar’s interaction with nitrogen fertil- izer applications is summed over the 50 years with two crops per year, and becomes a very important parameter at this scale. These results, along with the Kenya cookstove case study, emphasize the need for improved data on bio- char’s role in soil nitrous oxide emissions. Table B.21  Sensitivity Results for Biochar Transportation Distance Parameter Biochar transport Revenue ($ per tonne distance (km) of dry matter) Change (%) 1 953 +0.5 5 948 0 25 924 −3 Source: World Bank. Table B.22  Sensitivity Results for Soil Nitrous Oxide Emissions Parameter Soil nitrous oxide GHG (tonnes CO2e per GHG (tonnes CO2e per emissions (% of tonne of dry matter) tonne of dry matter) baseline) 1-crop effect Change (%) 50-year effect Change (%) −50 −0.420 +1 −1.1 +102 0 −0.415 0 −0.5 0 50 −0.409 −1 +0.03 −106 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 183 Senegal Case Study Life-Cycle Assessment Data Quality Assessment Each process was assigned a data quality score for each indicator on a scale of 1 to 5, 1 being the best. The average of the scores was calculated for each process, as provided in table B.23. Each process received an average score of 2. The pro- cess that received the poorest score was the pyrolysis unit construction (2.4), because the construction materials were based on a rough estimation from the project contacts. The next highest score was 2.3 and was received by the fossil fuel production and combustion processes (residual oil, truck transport, and so on) as these are based on U.S. data. The Pyro-6F construction and biochar production received scores of 4 in the “uncertainty” category because the mean value, standard deviation, uncertainty type, and description of strengths and weaknesses were not available and could not be approximated. The fossil fuel production and combustion processes each received scores of 4 in geography because the data are specific to the United States. The data quality assessment highlights that there are concerns over uncer- tainty and representativeness in the data, and weaknesses in the data are explored in the sensitivity analysis. Sensitivity Analysis A sensitivity analysis was conducted in order to measure the variability in the LCA results as a function of varying key input parameters (table B.24). The input Table B.23  Data Quality Scores for Senegal Biochar System Representativeness Reproducibility Average score Uncertainty Technology Geography Sources Time Process Rice husk, at mill 1 1 2 2 2 2 1 2 Rice husk, bagged 1 1 2 2 2 2 1 2 Pyro unit construction 1 1 1 4 3 4 3 2 Biochar production 1 1 1 4 3 3 3 2 Residual oil, utility boiler combustion 1 4 3 2 2 2 2 2 Biochar, field application 1 1 1 2 2 2 3 2 U.S. class 8B diesel truck 1 4 3 2 2 2 2 2 U.S. barge: residual fuel 1 4 3 2 2 2 2 2 Transport, pyro unit 1 1 3 2 2 2 2 2 Transport, bullock cart 1 1 1 3 3 3 3 2 Residual oil, at point of use 1 4 3 2 2 2 2 2 Electricity 1 2 3 2 3 3 2 2 Avoided rice husk decay 1 2 2 2 3 3 2 2 Average steel, 30% virgin, 70% recycled 1 4 3 2 2 2 2 2 Source: World Bank. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 184 Case Studies Table B.24  Sensitivity Analysis Input Parameters, Including Baseline and Range Values Parameter Baseline Sensitivity range Biomass throughput (tonnes of dry matter per year) 1,388 Stable carbon content of biochar (%) 80 0–90 Yield response with biochar additions (%) +52 –50 to +233 Onion price ($ per tonne) 287 70–552 Pyro-6F methane emissions (kg per tonne of dry matter) 2.9 2.2–6.4 Avoided rice husk decay methane emissions (kg per tonne of dry 0.33 0.33–2.46 matter) Duration of biochar’s effect (years) 50 1–100 Biochar price ($ per tonne) 200 100–300 Pyro-6F production time (% of capacity) 50 25–100 Biochar transportation distance (km) 10 1–25 Soil nitrous oxide emissions (%) 0 –50% to +50 Source: World Bank. Table B.25  Sensitivity Results for Stable Carbon Content of Biochar Parameter GHG (tonnes CO2e per Stable carbon content of biochar (%) tonne of dry matter) Change (%) 0 +0.03 −108 50 −0.25 −39 80 −0.41 0 90 −0.47 +15 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. parameters that were tested are the fraction of recalcitrant carbon in the biochar, the yield response of onion crops with biochar additions, the price the farmer receives for onions, methane emissions from the pyrolysis unit, methane emis- sions from avoided rice husk decay, the duration of biochar’s agronomic effec- tiveness, the price of the biochar, the production time for the pyrolysis unit, the biochar transportation distance, and soil nitrous oxide emissions. In order to facilitate the data interpretation, the discussion of each sensitivity test is followed by a list of the results for those impact categories (GHG or monetary value) that are relevant to the test (that is, results are not presented if the value does not vary from the baseline). The stable carbon content is varied in the range 0–90 percent with a baseline of 80 percent (table B.25). A change in the stable fraction of carbon in the bio- char from the baseline of 80 percent to 50 percent lowers the net GHG reduc- tions by 39 percent. Meanwhile, a 90 percent stable carbon fraction increases the net GHG by 15 percent compared to the baseline. If the stable fraction of the carbon in the biochar is 0 percent, the net GHG goes slightly positive, to +0.03 tonnes of CO2e per tonne of dry matter. From this analysis it is evident that the stable carbon content of the biochar is a major driver in the net GHG balance of the Senegal biochar system. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 185 Table B.26  Sensitivity Results for Yield Response Parameter Yield response Surplus onion (kg per Revenue ($ per tonne (% of baseline) tonne of dry matter) Change (%) of dry matter) Change (%) 1-crop effect −50 −227 −197 −109 −554 0 0 −100 −43 −279 52 235 0 24 0 233 1,060 +351 261 +988 50-year effect −50 −22,700 −195 −6,565 −198 0 0 −100 −43 −100 52 24,000 0 6,696 0 233 106,000 +342 30,394 +354 Source: World Bank. In order to consider the effect of varying the crop yield response with biochar amendments, a 1-crop biochar effect is compared to a 50-year biochar effect in table B.26. The onion yield is ranged from −50 percent (a decrease in yield with biochar additions as compared to the control) to a 233 percent increase in yield (the maximum percent increase for maize trials).3 At the baseline value of 52 percent, there is a 235-kilogram surplus of onions per tonne of dry feedstock per crop, or a 24,000-kilogram surplus per tonne of dry matter over 50 years. For the maximum yield increase of 233 percent, the net revenue increases to +$261 per tonne of dry matter and a surplus of 1,060 kilograms of onions per tonne of dry matter for a 1-crop effect, while a 50-year effect results in $30,394 and 106,000 kilograms of onions per tonne of dry matter. With no change in crop yield, the net revenue becomes negative for both the 1-crop and 50-year effects, at −$43. A 50 percent decrease in yield results in about a 200 percent decrease in yield for both the 1-crop and 50-year biochar effects, and the net revenue is domi- nated by the lost onion sales. The changes in GHG emissions with a variation in crop yield are less than a fraction of a percent from the baseline because the effect of yield increase on soil organic carbon is minimal, as discussed in other case studies. Onion prices are ranged from $70 to $552 per tonne, with a baseline of $287 per tonne. The lower price is based on the minimum farmer price for onions in Kenya (Weinberger and Pichop 2009), and the upper price assumes the farmer receives the entire retail price for onions in Senegal (David-Benz, Wade, and Egg 2005). The sensitivity analysis compares varying the onion price for the 50-year effect for biochar on crop yields. As the numbers in table B.27 demonstrate, even though the net revenue decreases by 76 percent at the low- est onion price, the net revenues are still significant when considering biochar’s 50-year effect ($1,600 per tonne of dry matter) because of the high yield of onions. (Note: there are two onion crops per year, thus a 50-year effect is for 100 onion crops.) Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 186 Case Studies Table B.27  Sensitivity Results for Onion Price Parameter Assuming a 50-Year Effect Onion price ($ per tonne) Revenue ($ per tonne of dry matter) Change (%) 70 1,600 −76 287 6,696 0 552 12,917 +93 Source: World Bank. Table B.28  Sensitivity Results for Pyro-6F Methane Emissions Parameter Pyro-6F methane emissions GHG (tonnes CO2e per (kg methane per tonne of dry matter) tonne of dry matter) Change (%) 2.2 −0.43 +5 2.9 −0.41 0 6.4 −0.33 −20 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. The methane emissions during pyrolysis were varied from 2.2 to 6.4 kilograms of methane per tonne of dry fuel, based on low and high values found in the literature, where the baseline value is 2.9 kilograms per tonne of dry fuel (table B.28). The low value of 2.2 kilograms of methane is based on the lower range for a controlled continuous process (Brown 2009), while the high of 6.4 kilograms of methane is for an open fire (Johnson et al. 2008). The net GHG reductions change by 5 percent and −20 percent for the lower and upper bounds of the emissions, respectively. This indicates that the methane emissions do not domi- nate the net GHG emissions of the project life cycle within the reasonable range for the technology. However, although unlikely, under very poor operating condi- tions with methane emissions as high as an open fire, the impacts could be quite significant on the net GHG balance. The low end of the emissions range of 0.33 kilograms of methane per tonne of dry matter for rice husk decay is based on calculations following the Clean Development Mechanism (CDM) methodology as discussed in the process description in chapter 5 (table B.29). The upper end of 2.46 kilograms of meth- ane per tonne of dry matter is from emissions during composting of yard waste residues (Hellebrand 1998). A higher methane emissions value for avoided decay results in higher avoided methane emissions, thus a 15 percent increase in net GHG reductions. Similar to the Pyro-6F emissions, the avoided rice husk decay methane emissions do not dominate the GHG balance within the uncertainty range. The duration of biochar’s effect on crop productivity is varied from 1 to 100 years, where the baseline is assumed to be 50 years (table B.30). The “surplus onions” are the quantity of onions grown in excess of what would be grown without biochar additions over the 1-, 50-, or-100 year duration on the area to which biochar was applied by the farmer. This assumes that the biochar is Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 187 Table B.29  Sensitivity Results for Rice Husk Decay Methane Emissions Parameter Rice husk decay methane emissions (kg GHG (tonnes CO2e per per tonne of dry matter) tonne of dry matter) Change (%) 0.33 −0.41 0 2.46 −0.47 +15 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.30  Sensitivity Results for Duration of Biochar’s Agronomic Effect Parameter Duration of biochar’s Surplus onion Revenue effect on productivity (kg per tonne of ($ per tonne of GHG (tonnes CO2e per (yr) dry matter) dry matter) Change (%) tonne of dry matter)  1 470 91 −99 −0.36  50 23,485 6,696 0 −0.41 100 46,970 13,436 +101 −0.47 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.31  Sensitivity Results for Biochar Price Parameter Biochar price ($ per tonne) Revenue ($ per tonne of dry matter) Change (%) 100 6,618 −1 200 6,696 0 300 6,774 +1 Source: World Bank. applied at the specified rate of 10 tonnes per hectare. The $287 per tonne value is assigned to the onion surplus. It is important to note that these revenues are summed over the duration of biochar’s effect on crop productivity (from as short as 1 year to as long as 100 years). Note also that there are two cropping seasons per year. The net revenue changes by about ±100% over the range of tested timeframes for biochar’s agronomic effect. The price of biochar is varied ±50 percent from $100 to 300 per tonne with a baseline of $200 per tonne (table B.31). The change in net revenues is small, at only ±1 percent, because the relative contribution of the biochar price in the net economics is only 1 percent. The production time that the Pyro-6F is in operation is ranged from 25 per- cent to 100 percent of capacity, with a baseline of 50 percent (the production time also is representative of the biomass throughput) (table B.32). Neither the net revenue nor the net GHG change significantly when the production time is varied within this range. The pyrolysis emissions are small compared to the net GHG balance and the economics are dominated by onion revenues, which make Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 188 Case Studies Table B.32  Sensitivity Results for Pyro-6F Production Time Parameter Pyro-6F production time Revenue ($ per tonne GHG (tonnes CO2e per (% of capacity) of dry matter) Change (%) tonne of dry matter)  25 6,590 −2 −0.411  50 6,696  0 −0.414 100 6,750 +1 −0.415 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. Table B.33  Sensitivity Results of Revenue for Biochar Transportation Distance Parameter Biochar transport distance (km) Revenue ($ per tonne of dry matter) Change (%)  1 6,707 +0.2 10 6,696 0 25 6,679 −0.3 Source: World Bank. Table B.34 Sensitivity Results for Soil Nitrous Oxide Parameter Soil nitrous oxide GHG (tonnes CO2e per GHG (tonnes CO2e per emissions (% of tonne of dry matter) tonne of dry matter) baseline) 1-crop effect Change (%) 50-year effect Change (%) −50 −0.366 +2 −1.12 +170  0 −0.359  0 −0.414 0  50 −0.352 −2 +0.291 −170 Source: World Bank. Note: GHG = greenhouse gas; CO2e = carbon dioxide equivalent. savings from increased production time appear small. However, it is important to recall that the net revenues are calculated per tonne of dry feedstock. The net revenues for the nongovernmental organization (NGO) operating the pyrolysis unit would be affected much differently than those per functional unit or per farmer. Although there may be feedback in terms of biochar price as a function of the production time, at the same time the biochar price may be limited by what farmers can afford to pay. The transportation distance of the biochar is ranged from 1 to 25 kilometers, with a baseline of 10 kilometers (table B.33). Even at a distance of 25 kilometers, the net revenue decreases by only 0.3 percent for the 50-year biochar effect, corresponding to the increased transportation cost. Thus, the cost of the biochar transportation plays only a small role in the net revenues for the Senegal system. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Case Studies 189 Soil nitrous oxide emissions are ranged from +50 percent to −50 percent, estimated from literature values (Singh et al. 2010), assuming a nitrogen fertilizer application rate of 30 kilograms of nitrogen per hectare (table B.34). This analysis compares the 1-crop and the 50-year biochar effects. The changes in net GHG reductions are ±2 percent when considered on a 1-crop basis, demonstrating that biochar’s effect on soil nitrous oxide emissions are minimal in the short term. However, for a 50-year biochar effect basis, the cumulative soil nitrous oxide emissions could play a more substantial role at ±170 percent of the net GHG of the baseline. The change in soil nitrous oxide emissions as a result of biochar’s interaction with nitrogen fertilizer applications is summed over the 50 years with two crops per year, and becomes a very important parameter at this scale. These results, along with the other case studies, emphasize the need for improved data on biochar’s role in soil nitrous oxide emissions. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 APPENDIX C Biographies: Biochar Guidance Group Members Pedro Sanchez is the Director of the Tropical Agriculture and the Rural Environment Program, Senior Research Scholar, and Director of the Millennium Villages Project at the Earth Institute at Columbia University. He also directs AfSIS, the African Soils Information Service developing the digital soils map of the world. Sanchez was Director-General of the World Agroforestry Centre (ICRAF) headquartered in Nairobi, Kenya, from 1991 to 2001, and served as Co-chair of the United Nations Millennium Project Hunger Task Force. He is also Professor Emeritus of Soil Science and Forestry at North Carolina State University. Sanchez received his BS, MS, and PhD degrees in Soil Science from Cornell University. His professional career has been dedicated to helping elimi- nate world hunger and absolute rural poverty while protecting and enhancing the tropical environment. He is the author of Properties and Management of Soils of the Tropics (rated among the top 10 best-selling books in soil science world- wide) and coauthor of Halving Hunger: It Can Be Done, and has authored or coauthored over 250 scientific publications. He is a Fellow of the American Academy of Arts and Sciences, the American Society of Agronomy, the Soil Science Society of America, and the American Association for the Advancement of Science. He serves on the Board of Agriculture and Natural Resources of the National Academy of Sciences. Sanchez has received honorary Doctor of Science degrees from the Catholic University of Leuven, Belgium, the University of Guelph, Canada, and Ohio State University, United States. He has received decorations from the governments of Colombia and Peru, and was anointed Luo Elder with the name of Odera Akang’o by the Luo community of western Kenya. Sanchez is the 2002 World Food Prize Laureate and 2004 MacArthur Fellow. Rosina M. Bierbaum serves as Dean, School of Natural Resources and Environment, and Professor, Natural Resources and Environmental Policy, University of Michigan. She was appointed Dean of the School of Natural Resources and Environment in October 2001. Previously, she served in environ- mental science policy leadership positions in both the legislative and executive branches of U.S. government, culminating in appointment as Director of the Environment Division of the White House Office of Science and Technology Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   191 192 Biographies: Biochar Guidance Group Members Policy, a Senate-confirmed position. In April 2008, Dr. Bierbaum was selected by the World Bank to codirect the 2010 edition of the World Development Report, an annual publication that focuses on a different topic each year and aims both to consolidate existing knowledge on a particular aspect of development and to stimulate debate on new directions for development policy. Dr. Bierbaum has been elected a Fellow of the American Academy of Arts and Sciences and the American Association for the Advancement of Science, and was appointed by President Barack Obama to the President’s Council of Advisors on Science and Technology. She is currently on the boards of the Federation of American Scientists, the Environmental and Energy Study Institute, the Energy Foundation, and the Gordon and Betty Moore Foundation. She is also a member of the Executive Committee for the Tyler Prize for Environmental Achievement. Dr. Bierbaum received her BS in Biology and BA in English from Boston College, and earned her PhD in Ecology and Evolution at the State University of New York, Stony Brook. Sasha Lyutse is a Policy Analyst at the Center for Market Innovation of the Natural Resources Defense Council (NRDC), focusing on climate and energy policy in the agricultural sector. Prior to joining NRDC, she worked as an analyst at Goldman Sachs, providing client relationship management, custodial, financ- ing, and reporting services for hedge funds, as well as at United States embassies in both London and Paris. She holds a Bachelor of Science in Foreign Service from Georgetown University and a dual Masters in Public Administration from the London School of Economics and Sciences Po University in Paris. Patricia (Pipa) Elias is a forest science and policy consultant. Over the past few years she has represented the Union of Concerned Scientists at the United Nations climate negotiations, working to create science-based reducing ­ emissions from deforestation and forest degradation (REDD)+ policies. She has a bachelor’s degree in Environmental Science from the University of Notre Dame ­ and a master’s degree in Forestry from Virginia Tech. In the past she has worked for the U.S. Forest Service and conducted soil chemistry research in the Appalachian forests. Dr. Christian Witt is Senior Program Officer, Agricultural Development, at The Bill & Melinda Gates Foundation. He manages the foundation’s subinitiative on soil health, which aims to increase soil fertility and productivity in small- holder farming. Prior to joining the foundation, he was a scientist and project manager in international agricultural research, with more than 15 years’ experi- ence in plant nutrition and soil nutrient management in the tropics. Witt spent most of his career working in Asia. Most recently, he was Director of the International Plant Nutrition Institute Southeast Asia, based in Singapore and Malaysia for six years, after a long career at the International Rice Research Institute in the Philippines, where he started his PhD research in 1993 and last held the position of Affiliate Scientist in 2003. A native of Germany, he holds a Diploma (MSc degree) in Biology from the University of Hamburg (1992) and a Doctorate degree in Biology from Justus-von-Liebig University, Germany, received in 1997. Dr. Witt has coordinated multinational research projects Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Biographies: Biochar Guidance Group Members 193 working on rice, maize, wheat, and oil palm, published more than 100 papers, including 25 refereed journal articles and book chapters, served as book editor, and developed a wide range of training materials and extension tools, including pocket guides, software and film products, and a leaf color chart for efficient nitrogen management in rice. He is codeveloper of the widely accepted site- specific nutrient management (SSNM) approaches for rice and maize in Asia. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References Abhayawick, L., J. C. Laguerre, V. Tauzin, and A. Duquenoy. 2002. “Physical Properties of Three Onion Varieties as Affected by the Moisture Content.” Journal of Food Engineering 55: 253–62. Aggarwal, R. K., and S. S. Chandel. 2004. “Review of Improved Cookstoves Programme in Western Himalayan State of India.” Biomass and Bioenergy 27: 131–44. Ansems, L., and T. N. Ligthart. 2002. “Data Certification for LCA Comparisons: Inventory of Current Status and Strength and Weakness Analysis.” TNO Report R2002-601, TNO, The Netherlands. Antal, M. J., K. Mochidzuki, and L. S. Paredes. 2003. “Flash Carbonization of Biomass.” Industrial and Engineering Chemistry Research 42: 3690–99. Asai, H., B. K. Samson, H. M. Stephan, K. Songyikhangsuthor, K. Homma, Y. Kiyono, Y. Inoue, T. Shiraiwa, and T. Horie. 2009. “Biochar Amendment Techniques for Upland Rice Production in Northern Laos: 1. Soil Physical Properties, Leaf SPAD and Grain Yield.” Field Crops Research 111 (1–2): 81–84. Ayodele, A., P. Oguntunde, A. Joseph, and D. M. de Souza. 2009. “Numerical Analysis of the Impact of Charcoal Production on Soil Hydrological Behavior, Runoff Response, and Erosion Susceptibility.” Revista Brasilieria de Ciência do Solo 33: 137–45. Azcón, R., and R. M. Tobar. 1998. “Activity of Nitrate Reductase and Glutamine Synthetase in Shoot and Root of Mycorrhizal Allium cepa: Effect of Drought Stress.” Plant Science 133: 1–8. Baldock, J. A., and R. J. Smernik. 2002. “Chemical Composition and Bioavailability of Thermally Altered Pinus resinosa (Red Pine) Wood.” Organic Geochemistry 33: 1093– 109. Barnes, D., K. Openshaw, K. R. Smith, and R. van der Plas. 1993. “The Design and Diffusion of Improved Cooking Stoves.” World Bank Research Observer 8 (2): 119–41. Batjes, N. H. 1996. “Total Carbon and Nitrogen in the Soils of the World.” European Journal of Soil Science 47: 151–163. Baumann, H., and A.-M. Tillman. 2004. The Hitch Hiker’s Guide to LCA: An Orientation in Life Cycle Assessment Methodology and Application. Lund, Sweden: Studentlitteratur AB. Beagle, E. C. 1978. “Rice Husk Conversion to Energy.” FAO Agricultural Services Bulletin 31. Food and Agriculture Organization of the United Nations, Rome. Beck, D. A., G. R. Johnson, and G. A. Spolek. 2011. “Amending Greenroof Soil with Biochar to Affect Runoff Water Quantity and Quality.” Environmental Pollution 59 (8–9): 2111–18. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7   195 196 References Bird, M. I., C. Moyo, E. M. Veenedaal, J. Lloyd, and P. Frost. 1999. “Stability of Elemental Carbon in a Savanna Soil.” Global Biogeochemical Cycles 13 (4): 923–32. Blackwell, P., G. Riethmuller, and M. Collins. 2009. “Biochar Application to Soil.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 207–26. London: Earthscan. Bond, W. J., and J. E. Keeley. 2005. “Fire as a Global ‘Herbivore’: The Ecology and Evolution of Flammable Ecosystems.” Trends in Ecology and Evolution 20 (7): 387–94. Borlaug, N. 2007. “Feeding a Hungry World.” Science 318 (5849): 359. Bradford, S. A., E. Segal, W. Zheng, Q. Q. Wang, and S. S. Hutchins. 2008. “Reuse of Concentrated Animal Feeding Operation Wastewater on Agricultural Lands.” Journal of Environmental Quality 37 (5): S97–S115. Bridgwater, A. 2007. “IEA Bioenergy Update 27: Biomass Pyrolysis.” Biomass and Bioenergy 31: I–V. Brock, C. A., J. Cozic, R. Bahreini, K. D. Froyd, A. M. Middlebrook, A. McComiskey, J. Brioude, O. R. Cooper, A. Stohl, K. C. Aikin, J. A. D. Gouw, D. W. Fahey, R. A. Ferrare, R.-S. Gao, W. Gore, J. S. Holloway, G. Hübler, A. Jefferson, D. A. Lack, S. Lance, R. H. Moore, D. M. Murphy, A. Nenes, P. C. Novelli, J. B. Nowak, J. A. Ogren, J. Peischl, R. B. Pierce, P. Pilewskie, P. K. Quinn, T. B. Ryerson, K. S. Schmidt, J. P. Schwarz, H. Sodemann, J. R. Spackman, H. Stark, D. S. Thomson, T. Thornberry, P. Veres, L. A. Watts, C. Warneke, and A. G. Wollny. 2011. “Characteristics, Sources and Transport of Aerosols Measured in Spring 2008 during the Aerosol, Radiation and Cloud Processes Affecting Arctic Climate (ARCPAC) Project.” Atmospheric Chemistry and Physics 11: 2423–53. Brodowski, S. B. 2004. “Origin, Function, and Reactivity of Black Carbon in the Arable Soil Environment.” Unpublished doctoral thesis, University of Bayreuth, Bayreuth, Germany. Brown, R. C. 2009. “Biochar Production Technology.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 127–46. London: Earthscan. Brown, R. A., A. Kercherb, T. Nguyen, D. Nagle, and W. Ball. 2006. “Production and Characterization of Synthetic Wood Chars for Use as Surrogates for Natural Sorbents.” Organic Geochemistry 37 (3): 321–33. Bruun, S., T. El-Zahery, and L. Jensen. 2009. “Carbon Sequestration with Biochar: Stability and Effect on Decomposition of Soil Organic Matter.” IOP Conference Series: Earth and Environmental Science 6: 24. Busscher, W. J., J. M. Novak, D. E. Evans, D. W. Watts, M. A. S. Niandou, and M. Ahmedna. 2010. “Influence of Pecan Biochar on Physical Properties of a Norfolk Loamy Sand.” Soil Science 175 (1): 10–14. Carbon Gold. 2009. “General Methodology for Quantifying the Greenhouse Gas Emission Reductions from the Production and Incorporation of Soil of Biochar in Agricultural and Forest Management Systems.” http://v-c-s.org/sites/v-c-s.org/files/ Methodology%20for%20Biochar%20Production%20and%20Incorporation%20in%20 ALM%20and%20IFM.pdf. Chan, K. Y., L. van Zwieten, I. Meszaros, A. Downie, and S. Joseph. 2007. “Agronomic Values of Greenwaste Biochar as a Soil Amendment.” Soil Research 45: 629–34. Chan, K. Y., and Z. Xu. 2009. “Biochar: Nutrient Properties and Their Enhancement.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 67–84. London: Earthscan. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 197 Cheng, C.-H., J. Lehmann, and M. H. Engelhard. 2008. “Natural Oxidation of Black Carbon in Soils: Changes in Molecular Form and Surface Charge along a Climosequence.” Geochimica et Cosmochimica Acta 72 (6): 1598–610. Cheng, C.-H., J. Lehmann, J. E. Thies, and S. D. Burton. 2008. “Stability of Black Carbon in Soils across a Climatic Gradient.” Journal of Geophysical Research 113: G02027. Cheng, C.-H., J. Lehmann, J. E. Thies, S. D. Burton, and M. H. Engelhard. 2006. “Oxidation of Black Carbon by Biotic and Abiotic Processes.” Organic Geochemistry 37: 1477–88. ClimateCare. 2010. “Indicative Programme, Baseline, and Monitoring Methodology for Improved Cook-Stoves and Kitchen Regimes.” CDM Gold Standard. http://www. cdmgoldstandard.org/wp-content/uploads/2011/11/GS_Methodology_Cookstove. pdf. Clough, T. J., F. M. Kelliher, R. R. Sherlock, and C. D. Ford. 2004. “Lime and Soil Moisture Effects on Nitrous Oxide Emissions from a Urine Patch.” Soil Science Society of America Journal 68: 1600–1609. Couto, L. 2010. “Brazilian Network of Biomass for Energy (RENABIO).” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. Crane-Droesch, A., S. Abiven, M. Schmidt, and M. Torn. 2010. “A Meta-Analysis of Plant Response to Biochar.” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. CSIRO (Commonwealth Scientific and Industrial Research Organisation). 2010. “Investigating Biochar: From Source to Sink.” http://www.csiro.au/science/Biochar- Overview.html. David-Benz, H., I. Wade, and J. Egg. 2005. “Market Information and Price Instability: An Insight into Vegetable Markets in Senegal.” EconWPA 05122005. De Capitani, E. M., E. Algranti, M. Z. Aantonieta, A. M. Z. Handar, M. A. Albina, A. M. A. Altemani, R. G. Ferreira, A. B. Balthazar, E. M. F. P. Cerqueira, and J. S. Ota. 2007. “Wood Charcoal and Activated Carbon Dust Pneumoconiosis in Three Workers.” American Journal of Industrial Medicine 50: 191–96. Defries, R. S., T. Rudel, M. Uriarte, and M. Hansen. 2010. “Letter: Deforestation Driven by Urban Population Growth and Agricultural Trade in the Twenty-First Century.” Nature Geosciences 3: 178–81. De Gryze, S., M. Cullen, and L. Durschinger. 2010. “Evaluation of the Opportunities for Generating Carbon Offsets from Soil Sequestration of Biochar.” Terra Global Capital, Paper commissioned by the Climate Action Reserve. DeLuca, T. H., M. D. MacKenzie, M. J. Gundale, and W. E. Holben. 2006. “Wildfire- Produced Charcoal Directly Influences Nitrogen Cycling in Ponderosa Pine Forests.” Soil Science Society of America Journal 70: 448–53. Duguma, L. A., I. Darnhofer, and H. Hager. 2009. “The Financial Return of Cereal Farming for Smallholder Farmers in the Central Highlands of Ethiopia.” Experimental Agriculture 46 (2): 137–53. Dünisch, O., V. C. Lima, G. Seehann, J. Donath, V. R. Montola, and T. Schwarz. 2007. “Retention Properties of Wood Residues and Their Potential for Soil Amelioration.” Wood Science and Technology 41 (2): 169–89. Elad, Y., D. Rav David, Y. Meller Harel, M. Borenshtein, H. Ben Kalifa, A. Silber, and E. R. Graber. 2010. “Induction of Systemic Resistance in Plants by Biochar, a Soil-Applied Carbon Sequestering Agent.” Phytopathology 100: 913–21. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 198 References Elmer, W. H., and J. J. Pignatello. 2011. “Effect of Biochar Amendments on Mycorrhizal Associations and Fusarium Crown and Root Rot of Asparagus in Replant Soils.” Plant Disease 95 (8): 960–66. Energy and Mining Sector Board. 2001. The World Bank Group’s Energy Program: Poverty Reduction, Sustainability, and Selectivity. Washington, DC: World Bank. Erb, K.-H., F. Krausmann, V. Gaube, S. Gingrich, A. Bondeau, M. Fischer-Kowalski, and H. Haberl. 2009. “Analyzing the Global Human Appropriation of Net Primary Production: Processes, Trajectories, Implications—An Introduction.” Ecological Economics 69 (2): 250–59. Fairhead, J., and M. Leach. 2009. “Amazonian Dark Earths in Africa?” Chapter 13 of Amazonian Dark Earths: Wim Sombroek’s Vision, edited by W. I. Woods, W. G. Teixeira, J. Lehmann, C. Steiner, A. M. G. A. WinklerPrins, and L. Rebellato. Springer Science. FAO (Food and Agriculture Organization of the United Nations). 2008. Gender and Equity Issues in Liquid Biofuels Production: Minimizing the Risks to Maximize the Opportunities. Rome: FAO. ———. 2009. How to Feed the World in 2050. Rome: FAO. ———. 2010. Making Integrated Food-Energy Systems Work for People and Climate. Rome: FAO. Fisher, B. 2010. “Letter to the Editor: African Exception to Drivers of Deforestation.” Nature Geosciences 3: 375–76. Forbes, M. S., R. J. Raison, and J. O. Skjemstad. 2006. “Formation, Transformation and Transport of Black Carbon (Charcoal) in Terrestrial and Aquatic Ecosystems.” Science of the Total Environment 370: 190–206. Garcia-Perez, M. 2008. “The Formation of Polyaromatic Hydrocarbons and Dioxins During Pyrolysis: A Review of the Literature with Description of Biomass Composition, Fast Pyrolysis Technologies and Thermochemical Reactions.” Washington S t a t e   U n i v e r s i t y.   h t t p : / / w w w. p a c i f i c b i o m a s s . o r g / d o c u m e n t s / TheFormationOfPolyaromaticHydrocarbonsAndDioxinsDuringPyrolysis.pdf. Gaunt, J., and A. Cowie. 2009. “Biochar, Greenhouse Gas Accounting and Emissions Trading.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 317–40. London: Earthscan. Gaunt, J. L., and J. Lehmann. 2008. “Energy Balance and Emissions Associated with Biochar Sequestration and Pyrolysis.” Environmental Science and Technology 42: 4152– 58. GEF (Global Environment Facility). 2003. Operational Program on Sustainable Land Management. Washington, DC: GEF. ———. 2007. “The Global Environment Facility—GEF: Sustainable Forest Management Program.”  http://www.cifor.cgiar.org/publications/pdf_files/cop/session%20 4/7-Sumba-4-7-4-GEF’s%20Programmatic-NRMT.pdf. ———. 2009. GEF Sustainable Forest Management & REDD+ Investment Program. Washington, DC: GEF. ———. 2010. “The GEF Small Grants Program: Community Action, Global Impact.” http://sgp.undp.org/. Glaser, B., E. Balashov, L. Haumaier, G. Guggenberger, and W. Zech. 2000. “Black Carbon in Density Fractions of Anthropogenic Soils of the Brazilian Amazon Region.” Organic Geochemistry 31 (7–8): 669–78. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 199 Glaser, B., L. Haumaier, G. Guggenberger, and W Zech. 2001. “The ‘Terra Preta’ Phenomenon: A Model for Sustainable Agriculture in the Humid Tropics.” Naturwissenschaften 88: 37–41. Glaser, B., J. Lehmann, and W. Zech. 2002. “Ameliorating Physical and Chemical Properties of Highly Weathered Soils in the Tropics with Charcoal: A Review.” Biology and Fertility of Soils 35: 219–30. Golding, C. J., R. J. Smernik, and G. F. Birch. 2004. “Characterisation of Sedimentary Organic Matter from Three South-Eastern Australian Estuaries Using Solid-State13 C-NMR Techniques.” Marine and Freshwater Research 55: 285–93. Graber, E. R., Y. M. Harel, M. Kolton, E. Cytryn, A. Silber, D. R. David, L. Tsechansky, M. Borenshtein, and Y. Elad. 2010. “Biochar Impact on Development and Productivity of Pepper and Tomato Grown in Fertigated Soilless Media.” Plant and Soil 337: 481–96. Guggenberger, G., A. Rodionov, O. Shibistova, M. Grabe, O. A. Kasansky, H. Fuchs, N. Mikheyeva, G. Zhazhevskaya, and H. Flessa. 2008. “Storage and Mobility of Black Carbon in Permafrost Soils in the Forest Tundra Ecotone in Northern Siberia.” Global Change Biology 14: 1367–81. Haefele, S., C. Knoblauch, M. Gummert, Y. Konboon, and S. Koyama. 2009. “Black Carbon (Biochar) in Rice-Based Systems: Characteristics and Opportunities.” In Chapter 26 of Amazonian Dark Earths: Wim Sombroek’s Vision, edited by W. I. Woods, W. G. Teixeira, J. Lehmann, C. Steiner, A. M. G. A. WinklerPrins, and L. Rebellato. Berlin: Springer Science. Haefele, S. M., Y. Konboon, W. Wongboon, S. Amarante, A. A. Maarifat, E. M. Pfeiffer, and C. Knoblauch. 2011. “Effects and Fate of Biochar from Rice Residues in Rice-Based Systems.” Field Crops Research 121 (3): 430–40. Hamer, U., B. Marschner, S. Brodowski, and W. Amelung. 2004. “Interactive Priming of Black Carbon and Glucose Mineralisation.” Organic Geochemistry 35 (7): 823–30. Hammond, J., S. Shackley, S. P. Sohi, and P. Brownsort. 2011. “Prospective Life Cycle Carbon Abatement for Pyrolysis Biochar Systems in the UK.” Energy Policy 39: 2646– 55. Hayes, M. 2010. “Development of a Biochar Classification System Based on Its Effect on Plant Growth.” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. Hellebrand, H. J. 1998. “Emission of Nitrous Oxide and Other Trace Gases During Composting of Grass and Green Waste.” Journal of Agricultural Engineering Research 69: 365–75. Huang, M.-T., and D. L. Ketring. 1987. “Root Growth Characteristics of Peanut Genotypes.” Journal of Agricultural Research of China 36: 41–52. Hyman, E. 1985. The Experience with Improved Charcoal and Wood Stoves for Households and Institutions in Kenya. Washington, DC: Appropriate Technology International. IBI (International Biochar Initiative). 2012. “Developing Guidelines for Specifications of Biochars.” http://www.biochar-international.org/characterizationstandard. Iliffe, R. 2009. “Is the Biochar Produced by an Anila Stove Likely to Be a Beneficial Soil Additive?” UKBRC Working Paper 4, United Kingdom Biochar Research Centre. Ioannidou, O., A. Zabaniotou, E. V. Antonakou, K. M. Papazisi, A. A. Lappas, and C. Athanassiou. 2009. “Investigating the Potential for Energy, Fuel, Materials and Chemicals Production from Corn Residues (Cobs and Stalks) by Non-catalytic and Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 200 References Catalytic Pyrolysis in Two Reactor Configurations.” Renewable and Sustainable Energy Reviews 4: 750–62. IPCC (Intergovernmental Panel on Climate Change). 2006. 2006 IPCC Guidelines for National Greenhouse Gas Inventories. Japan: IPCC National Greenhouse Gas Inventories Programme, Technical Support Unit. ———. 2007. “Climate Change 2007: Mitigation.” Contribution of Working Group III to the Fourth Assessment Report of the Intergovernmental Panel on Climate Change, edited by B. Metz, O. R. Davidson, P. R. Bosch, R. Dave, and L. A. Meyer. Cambridge: Cambridge University Press. ISO (International Organization for Standardization). 1997. “ISO 14040:1997: Environmental Management—Life Cycle Assessment—Principles and Framework.” http://www.iso.org/iso/catalogue_detail.htm?csnumber=23151. Johnson, M., R. Edwards, C. Alatorre Frenk, and O. Masera. 2008. “In-field Greenhouse Gas Emissions from Cookstoves in Rural Mexican Households.” Atmospheric Environment 42: 1206–22. Johnson, M., R. Edwards, A. Ghilardi, V. Berrueta, D. Gillen, C. A. Frenk, and O. Masera. 2009. “Quantification of Carbon Savings from Improved Biomass Cookstove Projects.” Environmental Science and Technology 43 (7): 2456–62. Jones, M., E. Lopez Capel, and D. Manning. 2008. “Polycyclic Aromatic Hydrocarbons (PAH) in Biochars and Related Materials.” Presentation at International Biochar Initiative Conference, Newcastle, UK. Joseph, S. 2009. “Socio-Economic Assessment and Implementation of Small-Scale Biochar Projects.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 359–74. London: Earthscan. Kammann, C. I., S. Linsel, J. W. Gößling, and H.-W. Koyro. 2011. “Influence of Biochar on Drought Tolerance of Chenopodium quinoa Willd and on Soil-Plant Relations.” Plant and Soil 345: 195–210. Kanagawa, M., and T. Nakata. 2007. “Analysis of the Energy Access Improvement and Its Socio-Economic Impacts in Rural Areas of Developing Countries.” Ecological Economics 62: 319–29. Kapkiyai, J. J., N. K. Karanja, J. N. Qureshi, P. C. Smithson, and P. L. Woomer. 1999. “Soil Organic Matter and Nutrient Dynamics in a Kenyan Nitisol under Long-Term Fertilizer and Organic Input Management.” Soil Biology and Biochemistry 31 (13): 1773–82. Karhu, K., T. Mattila, I. Bergström, and K. Regina. 2011. “Biochar Addition to Agricultural Soil Increased CH4 Uptake and Water Holding Capacity: Results from a Short-Term Pilot Field Study.” Agriculture, Ecosystems and Environment 140: 309–13. Karve, P., R. Prabunhe, S. Shackley, S. Carter, P. Anderson, S. Sohi, A. Cross, S. Haszeldine, S. Haefele, T. Knowles, J. Field, and P. Tanger. 2011. “Biochar for Carbon Reduction, Sustainable Agriculture and Soil Management (BIOCHARM).” Asia Pacific Network for Global Climate Change Research. http://www.apn-gcr.org/newAPN/activities/ ARCP/2009/ARCP2009-12NSY-Kerve/ARCP2009-12NSY-Karve.pdf. Kato, M., D. M. DeMarini, A. B. Carvalho, M. A. V. Rego, A. V. Andrade, A. S. V. Bomfim, and D. Loomis. 2005. “World at Work: Charcoal-Producing Industries in Northeastern Brazil.” Occupational and Environmental Medicine 62: 128–32. Kaygusuz, K. 2011. “Energy Services and Energy Poverty for Sustainable Rural Development.” Renewable and Sustainable Energy Reviews 15: 936–47. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 201 Keiluweit, M., P. S. Nico, M. G. Johnson, and M. Kleber. 2010. “Dynamic Molecular Structure of Plant Biomass-Derived Black Carbon (Biochar).” Environmental Science and Technology 44: 1247–53. Khan, A. A., and D. N. Iortsuun. 1989. “The Pattern of Dry-Matter Distribution during Development in Onion.” Journal of Agronomy and Crop Science 162: 127–34. Kimetu, J. M., and J. Lehmann. 2010. “Stability and Stabilisation of Biochar and Green Manure in Soil with Different Organic Carbon Contents.” Australian Journal of Soil Research 48 (6–7): 577–85. Kimetu, J. M., J. Lehmann, S. O. Ngoze, D. N. Mugendi, J. M. Kinyangi, S. Riha, L. Verchot, J. W. Recha, and A. N. Pell. 2008. “Reversibility of Soil Productivity Decline with Organic Matter of Differing Quality along a Degradation Gradient.” Ecosystems 11: 726–39. Kirimi, L. 2009. “Kenya’s Maize Pricing Situation: Challenges and Opportunities.” Presentation at Round Table on Kenya’s Food Situation: Challenges and Opportunities, Nairobi, September 18, 2009. http://www.tegemeo.org/Maize-pricing-2.asp. Knicker, H. 2007. “How Does Fire Affect the Nature and Stability of Soil Organic Nitrogen and Carbon? A Review.” Biogeochemistry 85: 91–118. Kuzyakov, Y., J. K. Friedel, and K. Stahr. 2000. “Review of Mechanisms and Quantification of Priming Effects.” Soil Biology and Biochemistry 32 (11–12): 1485–98. Kuzyakov, Y., I. Subbotina, H. Chen, I. Bogomolova, and X. Xu. 2009. “Black Carbon Decomposition and Incorporation into Soil Microbial Biomass Estimated by 14C Labeling.” Soil Biology and Biochemistry 41 (2): 210–19. Laird, D., P. Fleming, B. Wang, R. Horton, and D. Karlen. 2010. “Biochar Impact on Nutrient Leaching from a Midwestern Agricultural Soil.” Geoderma 158 (3–4): 436–42. Lal, R. 2009. “Soil Degradation as a Reason for Inadequate Human Nutrition.” Food Security 1: 45–57. Lal, R., and D. Pimentel. 2007. “Biofuels from Crop Residues (Editorial).” Soil and Tillage Research 93: 237–38. Lang, T., A. D. Jensen, and P. A. Jensen. 2005. “Retention of Organic Elements during Solid Fuel Pyrolysis with Emphasis on the Peculiar Behavior of Nitrogen.” Energy and Fuels 19: 1631–43. Lapola, D. M., R. Schaldach, J. Alcamo, A. Bondeau, J. Koch, C. Koelking, and J. A. Priess. 2010. “Indirect Land-Use Changes Can Overcome Carbon Savings from Biofuels in Brazil.” Proceedings of the National Academy of Sciences of the United States of America 107 (8): 3388–93. Lee, J. W., B. Hawkins, D. M. Day, and D. C. Reicosky. 2010. “Sustainability: The Capacity of Smokeless Biomass Pyrolysis for Energy Production, Global Carbon Capture and Sequestration.” Energy and Environmental Science 3: 1695–1705. Lehmann, J. 2007. “Bio-Energy in the Black.” Frontiers in Ecology and Environment 5 (7): 381–87. ———. 2009. “Terra Preta Nova—Where to from Here?” In Amazonian Dark Earths: Wim Sombroek’s Vision, edited by W. I. Woods, W. G. Teixeira, J. Lehmann, C. Steiner, A. M. G. A. WinklerPrins, and L. Rebellato, 473–486. The Netherlands: Springer Science. Lehmann, J., C. Czimczik, D. Laird, and S. Sohi. 2009. “Stability of Biochar in Soil.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 183–206. London: Earthscan. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 202 References Lehmann, J., J. P. da Silva, M. Rondon, C. M. da Silva, J. Greenwood, T. Nehls, C. Steiner, and B. Glaser. 2002. “Slash-and-Char: A Feasible Alternative for Soil Fertility Management in the Central Amazon?” Paper No. 49, 17th World Congress of Soil Science, Thailand. Lehmann, J., J. P. da Silva, C. Steiner, T. Nehls, W. Zech, and B. Glaser. 2003. “Nutrient Availability and Leaching in an Archaeological Anthrosol and a Ferralsol of the Central Amazon Basin: Fertilizer, Manure and Charcoal Amendments.” Plant and Soil 249: 343–57. Lehmann, J., and S. Joseph. 2009. “Biochar Systems.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 146–68. London: Earthscan. Lehmann, J., M. Rillig, J. Thies, C.A. Masiello, W.C. Hockaday, and D. Crowley. 2011. “Biochar Effects on Soil Biota: A Review.” Soil Biology and Biochemistry 43 (9): 1812–36. Lehmann, J., and M. Rondon. 2006. “Bio-Char Soil Management on Highly Weathered Soils in the Humid Tropics.” In Biological Approaches to Sustainable Soil Systems, edited by N. Uphoff, 517–30. Boca Raton, FL: CRC Press. Lehmann, J., J. Skjemstad, S. Sohi, J. Carter, M. Barson, P. Falloon, K. Coleman, P. Woodbury, and E. Krull. 2008. “Australian Climate Carbon Cycle Feedback Reduced by Soil Black Carbon.” Nature Geoscience 1 (12): 832–35. Lehmann, J., and D. Solomon. 2010. “Organic Carbon Chemistry in Soils Observed by Synchrotron-Based Spectroscopy.” In Synchroton-Based Techniques in Soils and Sediment, edited by B. Singh and M. Gräfe, 289–312. Amsterdam: Elsevier. Liang, B., J. Lehmann, S. P. Sohi, J. E. Thies, B. O’Neill, L. Trujillo, J. Gaunt, D. Solomon, J. Grossman, E. G. Neves, and F. J. Luizão. 2010. “Black Carbon Affects the Cycling of Non-black Carbon in Soil.” Organic Geochemistry 41 (2): 206–13. Liang, B., J. Lehmann, D. Solomon, J. Kinyangi, J. Grossman, B. O’Neill, J. O. Skjemstad, J. Thies, F. J. Luizão, J. Petersen, and E. G. Neves. 2006. “Black Carbon Increases Cation Exchange Capacity in Soils.” Soil Science Society of America Journal 70 (5): 1719–30. Liang, B., J. Lehmann, D. Solomon, S. Sohi, J. E. Thies, J. O. Skjemstad, F. J. Luizão, M. H. Engelhard, E. G. Neves, and S. Wirick. 2008. “Stability of Biomass-Derived Black Carbon in Soils.” Geochimica et Cosmochimica Acta 72 (24): 6069–78. Libra, J. A., K. S. Ro, C. Kammann, A. Funke, N. D. Berge, Y. Neubauer, M.-M. Titirici, C. Fühner, O. Bens, J. Kern, and K. H. Emmerich. 2011. “Hydrothermal Carbonization of Biomass Residuals: A Comparative Review of the Chemistry, Processes and Applications of Wet and Dry Pyrolysis.” Biofuels 2 (1): 89–124. Lim, H. H., Z. Domala, S. Joginder, S. J. Lee, C. S. Lim, and C. M. A. Bakar. 1984. “Rice Millers’ Syndrome: A Preliminary Report.” British Journal of Industrial Medicine 41: 445–49. Lundie, S., and G. M. Peters. 2005. “Life Cycle Assessment of Food Waste Management Options.” Journal of Cleaner Production 13 (3): 275–86. MacCarty, N., D. Ogle, D. Still, T. Bond, and C. Roden. 2008. “A Laboratory Comparison of the Global Warming Impact of Five Major Types of Biomass Cooking Stoves.” Energy for Sustainable Development 12 (2): 56–65. MacCarty, N., D. Ogle, D. Still, T. Bond, C. Roden, and B. Willson. 2007. Laboratory Comparison of the Global-Warming Potential of Six Categories of Biomass Cooking Stoves. Creswell, OR: Aprovecho Research Center. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 203 Major, J., J. Lehmann, M. Rondon, and C. Goodale. 2010. “Fate of Soil-Applied Black Carbon: Downward Migration, Leaching and Soil Respiration.” Global Change Biology 16: 1366–79. Manning, D. A. C., and E. Lopez-Capel. 2009. “Test Procedures for Determining the Quantity of Biochar within Soils.” In Chapter 17 of Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph. London: Earthscan. Martin, D. A., and J. A. Moody. 2001. “Comparison of Soil Infiltration Rates in Burned and Unburned Mountainous Watersheds.” Hydrological Processes 15: 2893–903. Masiello, C. A. 2004. “New Directions in Black Carbon Organic Geochemistry.” Marine Chemistry 92: 201–13. Mitra, A., T. S. Bianchi, B. A. McKee, and M. Sutula. 2002. “Black Carbon from the Mississippi River: Quantities, Sources, and Potential Implications for the Global Carbon Cycle.” Environmental Science and Technology 36: 2296–302. Moebius-Clune, B. N., H. M. van Es, O. J. Idowu, R. R. Schindelbeck, D. J. Moebius-Clune, and D. W. Wolfe. 2008. “Long-Term Effects of Harvesting Maize Stover and Tillage on Soil Quality.” Soil Science Society of America Journal 72 (4): 960–69. Molina, M., D. Zaelke, K. M. Sarma, S. O. Andersen, V. Ramanathan, and D. Kaniaru. 2009. “Reducing Abrupt Climate Change Risk Using the Montreal Protocol and Other Regulatory Actions to Complement Cuts in CO2 Emissions.” Proceedings of the National Academy of Sciences 106 (49): 20616–21. Müller, D., and J. Mburu. 2009. “Forecasting Hotspots of Forest Clearing in Kakamega Forest, Western Kenya.” Forest Ecology and Management 257: 968–77. Mungai, N. W., and P. P. Motavalli. 2006. “Litter Quality Effects on Soil Carbon and Nitrogen Dynamics in Temperate Alley Cropping Systems.” Applied Soil Ecology 31 (1–2): 32–42. Murphy, L., and P. Edwards. 2003. Bridging the Valley of Death: Transitioning from Public to Private Sector Financing. Golden, CO: National Renewable Energy Laboratory. National Institute for Soils and Fertilizers. 1996. “Data Set.” Tu Liem, Hanoi, Vietnam. Nguyen, B. T., and J. Lehmann. 2009. “Black Carbon Decomposition under Varying Water Regimes.” Organic Geochemistry 40: 846–53. Nguyen, B. T., J. Lehmann, W. C. Hockaday, S. Joseph, and C. A. Masiello. 2010. “Temperature Sensitivity of Black Carbon Decomposition and Oxidation.” Environmental Science and Technology 44 (9): 3324–31. Nguyen, B. T., J. Lehmann, J. Kinyangi, R. Smernik, S. J. Riha, and M. J. Engelhard. 2008. “Long-Term Black Carbon Dynamics in Cultivated Soil.” Biogeochemistry 92: 163–76. Nhantumbo, I., and A. Salomão. 2010. Biofuels, Land Access, and Rural Livelihoods in Mozambique. London: International Institute for Environment and Development. Norberg-Bohm, V. 2002. “Pushing and Pulling Technology into the Marketplace: The Role of Government in Technology Innovation in the Power Sector.” In The Role of Government in Energy Technology Innovation: Insights for Government Policy in the Energy Sector, edited by V. Norberg-Bohm, 127–46. Energy Technology Innovation Project, Belfer Center for Science and International Affairs, John F. Kennedy School of Government, Harvard University. Novak, J. M., W. J. Busscher, D. L. Laird, M. Ahmedna, D. W. Watts, and M. A. S. Niandou. 2009. “Impact of Biochar Amendment on Fertility of a Southeastern Coastal Plain Soil.” Soil Science 174 (2): 105–12. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 204 References Novak, J. M., W. J. Busscher, D. W. Watts, D. A. Laird, M. A. Ahmedna, and M. A. S. Niandou. 2010. “Short-Term CO2 Mineralization after Additions of Biochar and Switchgrass to a Typic Kandiudult.” Geoderma 154: 281–88. Offerman, R., T. Seidenberger, D. Thrän, M. Kaltschmitt, S. Zinoviev, and S. Miertus. 2011. “Assessment of Global Bioenergy Potentials.” Mitigation and Adaptation Strategies for Global Change 16: 103–15. Ogawa, M., and Y. Okimori. 2010. “Pioneering Works in Biochar Research, Japan.” Australian Journal of Soil Research 48: 489–500. Pacala, S., and R. Socolow. 2004. “Stabilization Wedges: Solving the Climate Problem for the Next 50 Years with Current Technologies.” Science 305 (5686): 968–72. Pennise, D. M., K. R. Smith, J. P. Kithinji, M. E. Rezende, T. J. Raad, J. F. Zhang, and C. W. Fan. 2001. “Emissions of Greenhouse Gases and Other Airborne Pollutants from Charcoal Making in Kenya and Brazil.” Journal of Geophysical Research—Atmospheres 106: 24143–55. Perez, C., C. Roncoli, C. Neely, and J. S. Steiner. 2007. “Can Carbon Sequestration Markets Benefit Low-Income Producers in Semi-arid Africa? Potentials and Challenges.” Agricultural Systems 94: 2–12. Phyllis. 2008. “The Composition of Biomass and Waste.” Energy Research Centre of the Netherlands. http://www.ecn.nl/phyllis. Pimentel, D., A. Marklein, M. A. Toth, M. N. Karpoff, G. S. Paul, R. McCormack, J. Kyriazis, and T. Krueger. 2009. “Food Versus Biofuels: Environmental and Economic Costs.” Human Ecology 37: 1–12. Pratt, K., and D. Moran. 2010. “Evaluating the Cost-Effectiveness of Global Biochar Mitigation Potential.” Biomass and Bioenergy 34: 1149–58. Qadir, S. A., and T. C. Kandpal. 1995. “A Note on the Financial Evaluation of Improved Biomass Cookstoves.” Renewable Energy 6: 455–57. Raju, S. P. 1954. Smokeless Kitchens for the Millions. Park Town, Madras: Christian Literature Society. Raveendran, K., A. Ganesh, and K. C. Khilar. 1995. “Influence of Mineral Matter on Biomass Pyrolysis Characteristics.” Fuel 74 (12): 1812–22. Reinaud, G. 2010. “Pro-Natura International: Update on Pro-Natura’s Work around the World.” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. Ringler, C. 2010. “Climate Change and Hunger: Africa’s Smallholder Farmers Struggle to Adapt.” EuroChoices 9 (3): 16–21. Roberts, K. G., B. A. Gloy, S. Joseph, N. R. Scott, and J. Lehmann. 2010. “Life Cycle Assessment of Biochar Systems: Estimating the Energetic, Economic, and Climate Change Potential.” Environmental Science and Technology 44: 827–33. Robertson, G. P., and P. M. Groffman. 2007. “Nitrogen Transformations.” In Soil Microbiology, Ecology, and Biochemistry, edited by E. A. Paul, 341–64. New York, NY: Elsevier. Roden, C. A., T. C. Bond, S. Conway, A. B. O. Pinel, N. MacCarty, and D. Still. 2009. “Laboratory and Field Investigations of Particulate and Carbon Monoxide Emissions from Traditional and Improved Cookstoves.” Atmospheric Environment 43: 1170–81. Rondon, M. A., J. Lehmann, J. Ramirez, and M. Hurtado. 2007. “Biological Nitrogen Fixation by Common Beans (Phaseolus vulgaris L.) Increases with Bio-Char Additions.” Biology and Fertility of Soils 43 (6): 699–708. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 205 Rondon, M. A., D. Molina, M. Hurtado, J. Ramirez, J. Lehmann, J. Major, and E. Amezquita. 2006. “Enhancing the Productivity of Crops and Grasses while Reducing Greenhouse Gas Emissions through Bio-Char Amendments to Unfertile Tropical Soils.” Presentation at 18th World Congress of Soil Science, July 9–15, 2006, Philadelphia, PA. Roth, C. 2011. Micro Gasification: Cooking with Gas from Biomass. Germany: GIZ HERA. Roth, C. H., B. Meyer, H. G. Frede, and R. Derpsch. 1988. “Effect of Mulch Rates and Tillage Systems on Infiltrability and Other Soil Physical Properties of an Oxisol in Paraná, Brazil.” Soil and Tillage Research 11 (1): 81–91. RSB (Roundtable on Sustainable Biofuels). 2010. “RSB Principles and Criteria for Sustainable Biofuel Production.” http://rsb.epfl.ch/files/content/sites/rsb2/files/ Biofuels/Version%202/PCs%20V2/10-11-12%20RSB%20PCs%20Version%202.pdf. Rumpel, C., V. Chaplot, O. Planchon, J. Bernadou, C. Valentin, and A. Mariotti. 2006. “Preferential Erosion of Black Carbon on Steep Slopes with Slash and Burn Agriculture.” Catena 54: 30–40. Searchinger, T. D. 2010. “Biofuels and the Need for Additional Carbon.” Environmental Research Letters 5 (024007): 1–10. Seifritz, W. 1993. “Should We Store Carbon in Charcoal?” International Journal of Hydrogen Energy 18: 405–7. Shackley, S., and S. Sohi. 2010. “An Assessment of the Benefits and Issues Associated with the Application of Biochar to Soil.” Paper commissioned by the UK Government, UK Biochar Research Centre. Sheehan, J., V. Camobreco, J. Duffield, M. Graboski, and H. Shapouri. 1998. “Life Cycle Inventory of Biodiesel and Petroleum Diesel for Use in an Urban Bus.” Report pre- pared for U.S. Department of Energy’s Office of Fuels Development and U.S. Department of Agriculture’s Office of Energy, National Renewable Energy Laboratory, Golden, Colorado. Shinohara, Y., and N. Kohyama. 2004. “Quantitative Analysis of Tridymite and Cristobalite Crystallized in Rice Husk Ash by Heating.” Industrial Health 42: 277–85. Singh, B. P., B. Hatton, B. Singh, A. L. Cowie, and A. Kathuria. 2010. “Influence of Biochars on Nitrous Oxide Emission and Nitrogen Leaching from Two Contrasting Soils.” Journal of Environmental Quality 39 (4): 1224–35. Slavich, P., H. M. Tam, T. T. Dung, and B. Keen. 2010. “Industry and Investment, NSW: Rice Husk Biochar Improves Fertility of Sandy Soils in Central Coastal Vietnam.” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. Smith, K. R., D. M. Pennise, P. Khummongkol, V. Chaiwong, K. Ritgeen, J. Zhang, W. Panyathanya, R. A. Rasmussen, M. A. K. Khalil, and S. A. Thorneloe. 1999. “Greenhouse Gases from Small-Scale Combustion Devices in Developing Countries: Charcoal- Making Kilns in Thailand.” EPA-600/R-99-109, United States Environmental Protection Agency, National Risk Management Research Laboratory, Washington, DC. http://www.epa.gov/nrmrl/pubs/600r99109/600r99109.pdf. Sohi, S. P., E. Lopez-Capel, R. Bol, and E. Krull. 2010. “A Review of Biochar and Its Use and Function in Soil.” Advances in Agronomy 105: 47–82. Sombroek, W., M. L. Ruivo, P. M. Fearnside, B. Glaser, and J. Lehmann. 2003. “Amazonian Dark Earths as Carbon Stores and Sinks.” In Amazonian Dark Earths: Origin, Properties, Management, edited by J. Lehmann, D. C. Kern, B. Glaser, and W. I. Woods, 125–140. Dordrecht, The Netherlands: Kluwer Academic Publishers. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 206 References Spokas, K. 2010. “Review of the Stability of Biochar in Soils: Predictability of O:C Molar Ratios.” Carbon Management 1 (2): 289–303. Spokas, K. A., J. M. Baker, and D. C. Reicosky. 2010. “Ethylene: Potential Key for Biochar Amendment Impacts.” Plant and Soil 333: 443–52. Spokas, K. A., W. C. Koskinen, J. M. Baker, and D. C. Reicosky. 2009. “Impacts of Woodchip Biochar Additions on Greenhouse Gas Production and Sorption/Degradation of Two Herbicides in a Minnesota Soil.” Chemosphere 77 (4): 574–81. Steinbeiss, S., G. Gleixner, and M. Antonietti. 2009. “Effect of Biochar Amendment on Soil Carbon Balance and Soil Microbial Activity.” Soil Biology and Biochemistry 41: 1301–10. Steiner, C. 2010. “Biochar Carbon Sequestration in Tropical Land Use Systems.” Presentation at Third International Biochar Conference, Rio de Janeiro, Brazil, September 12–15, 2010. Steiner, C., K. C. Das, N. Melear, and L. Donald. 2010. “Reducing Nitrogen Loss during Poultry Litter Composting Using Biochar.” Journal of Environmental Quality 39 (4): 1236–42. Steiner, C., B. Glaser, W. G. Teixeira, J. Lehmann, W. E. H. Blum, and W. Zech. 2008. “Nitrogen Retention and Plant Uptake on a Highly Weathered Central Amazonian Ferralsol Amended with Compost and Charcoal.” Journal of Plant Nutrition and Soil Science 171 (6): 893–99. Steiner, C., W. G. Teixeira, J. Lehmann, T. Nehls, J. L. V. de Macedo, W. E. H. Blum, and W. Zech. 2007. “Long-Term Effects of Manure, Charcoal and Mineral Fertilization on Crop Production and Fertility on a Highly Weathered Central Amazonian Upland Soil.” Plant and Soil 291 (1–2): 275–90. Taghizadeh-Toosi, A., T. J. Clough, L. M. Condron, R. R. Sherlock, C. R. Anderson, and R. A. Craigie. 2011. “Biochar Incorporation into Pasture Soil Suppresses In Situ Nitrous Oxide Emissions from Ruminant Urine Patches.” Journal of Environmental Quality 40 (2): 468–76. Thomas, A. E. 2008. “Creating a Low-Cost, Low-Particulate Emissions Corn Cob Charcoal Grinder for Use in Peru.” Unpublished baccalaureate thesis, Massachusetts Institute of Technology, Cambridge, MA. Tisdall, J. M., and J. M. Oades. 1982. “Organic Matter and Water-Stable Aggregates in Soils.” Journal of Soil Science 33: 141–63. Titirici, M. M., A. Thomas, and M. Antonietti. 2007. “Back in the Black: Hydrothermal Carbonization of Plant Material as an Efficient Process to Treat the CO2 Problem?” New Journal of Chemistry 31: 787–89. Torres, D. 2011. “Biochar Production with Cook Stoves and Use as a Soil Conditioner in Western Kenya.” Unpublished doctoral dissertation, Cornell University, Ithaca, NY. Torres, D., J. Lehmann, P. Hobbs, S. Joseph, and H. Neufeldt. 2011. “Biomass Availability, Energy Consumption and Biochar Production in Rural Households of Western Kenya.” Biomass and Bioenergy 35 (8): 3537–46. Tryon, E. H. 1948. “Effect of Charcoal on Certain Physical, Chemical, and Biological Properties of Forest Soils.” Ecological Monographs 18: 81–115. UNEP & WMO. 2011. “Integrated Assessment of Black Carbon and Tropospheric Ozone: Summary for Decision Makers.” http://www.unep.org/dewa/Portals/67/pdf/Black_ Carbon.pdf. UNFCCC (United Nations Framework Convention on Climate Change). 2006. “Approved Baseline and Monitoring Methodology AM0041: Mitigation of Methane Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 References 207 Emissions in the Wood Carbonization Activity for Charcoal Production.” CDM Executive Board 27. http://cdm.unfccc.int/methodologies/DB/ B2SCH5WZLQYHTVSHQ4BIADMCBQ1P9U. ———. 2008. “Methodological Tool: Tool for the Demonstration and Assessment of Additionality.” CDM Executive Board 39, Annex 10, United Nations, Bonn, Germany. ———. 2009. “Energy Efficiency Measures in Thermal Applications of Nonrenewable Biomass.” CDM Executive Board 51, United Nations, Bonn, Germany. ———. 2010. “Clean Development Mechanism Methodology Booklet.” https://cdm. unfccc.int/methodologies. Unger, P. W., B. A. Stewart, J. F. Parr, and R. P. Singh. 1991. “Crop Residue Management and Tillage Methods for Conserving Soil and Water in Semi-arid Regions.” Soil and Tillage Research 20 (2–4): 219–40. U.S. Department of State. 2009. “2008 Human Rights Report: Kenya.” http://www.state. gov/g/drl/rls/hrrpt/2008/af/119007.htm. Van Oost, K., T. A. Quine, G. Govers, S. De Gryze, J. Six, J. W. Harden, G. W. McCarty, G. Heckrath, C. Kosmas, J. V. Giraldez, J. R. Marques da Silva, and R. Merckx. 2007. “The Impact of Agricultural Soil Erosion on the Global Carbon Cycle.” Science 318 (5850): 626–29. van Zwieten, L., S. Kimber, A. Downie, S. Morris, S. Petty, J. Rust, and K. Y. Chan. 2010. “A Glasshouse Study on the Interaction of Low Mineral Ash Biochar with Nitrogen in a Sandy Soil.” Australian Journal of Soil Research 48: 569–76. van Zwieten, L., S. Kimber, S. Morris, K. Y. Chan, A. Downie, J. Rust, S. Joseph, and A. Cowie. 2010. “Effects of Biochar from Slow Pyrolysis of Papermill Waste on Agronomic Performance and Soil Fertility.” Plant and Soil 327: 235–46. van Zwieten, L., S. Kimber, S. Morris, A. Downie, E. Berger, J. Rust, and C. Scheer. 2010. “Influence of Biochars on Flux of N2O and CO2 from Ferrosol.” Australian Journal of Soil Research 48: 555–68. van Zwieten, L., B. Singh, S. Joseph, S. Kimber, A. Cowie, K. Y. Chan. 2009. “Biochar and Emissions of Non-CO2 Greenhouse Gases from Soil.” In Biochar for Environmental Management: Science and Technology, edited by J. Lehmann and S. Joseph, 227–50. London: Earthscan. Verheijen, F. G. A., S. Jeffery, A. C. Bastos, M. van der Velde, and I. Diafas. 2010. “Biochar Application to Soils: A Critical Scientific Review of Effects on Soil Properties, Processes, and Functions.” EUR 24099 EN, Office for the Official Publications of the European Communities, Luxembourg. von Lützow, M., I. Kögel-Knabner, K. Ekschmitt, E. Matzner, G. Guggenberger, B. Marschner, and H. Flessa. 2006. “Stabilization of Organic Matter in Temperate Soils: Mechanisms and Their Relevance under Different Soil Conditions—A Review.” European Journal of Soil Science 57: 426–45. Wang, M. 2007. The Greenhouse Gases, Regulated Emissions, and Energy Use in Transportation (GREET) Model, 1.8b and 2.7. UChicago Argonne, LLC. Wardle, D. A., M.-C. Nilsson, and O. Zackrisson. 2008. “Fire-Derived Charcoal Causes Loss of Forest Humus.” Science 320 (5876): 629. Weinberger, K., and G. N. Pichop. 2009. “Marketing of African Indigenous Vegetables along Urban and Peri-urban Supply Chains in Sub-Saharan Africa.” In African Indigenous Vegetables in Urban Agriculture, edited by C. M. Shackleton, M. W. Pasquini, and A. W. Drescher, 225–44. London: Earthscan. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 208 References Whitman, T., C. F. Nicholson, D. Torres, and J. Lehmann. 2011. “Climate Change Impact of Biochar Cook Stoves in Western Kenyan Farm Households: System Dynamics Model Analysis.” Environmental Science and Technology 45 (8): 3687–94. Whitman, T., S. M. Scholz, and J. Lehmann. 2010. “Biochar Projects for Mitigating Climate Change: An Investigation of Critical Methodology Issues for Carbon Accounting.” Carbon Management 1 (1): 89–107. WHO (World Health Organization). 2000. Addressing the Links between Indoor Air Pollution, Household Energy and Human Health. Washington, DC: WHO. ———. 2011. “Indoor Air Pollution and Health.” Fact Sheet No. 292. http://www.who.int/ mediacentre/factsheets/fs292/en/. Woods, J., S. Hemstock, and W. Burnyeat. 2006. “Bioenergy Systems at the Community Level in the South Pacific: Impacts and Monitoring.” Mitigation and Adaptation Strategies for Global Change 11: 469–500. Woolf, D., J. Amonette, F. Street-Perrott, J. Lehmann, and S. Joseph. 2010. “Sustainable Biochar to Mitigate Global Climate Change.” Nature Communications 1: 56. World Bank. 2009. “10 Years of Experience in Carbon Finance: Insights from Working with Carbon Markets for Development and Global Greenhouse Gas Mitigation.” World Bank, Washington, DC. http://go.worldbank.org/XIG411DYP0. ———. 2011. Household Cookstoves, Environment, Health, and Climate Change: A New Look at an Old Problem. Washington, DC: World Bank. ———. 2013. On Thin Ice: How Cutting Pollution Can Slow Warming and Save Lives. Washington, DC: World Bank. Yanai, Y., K. Toyota, and M. Okazaki. 2007. “Effects of Charcoal Addition on N2O Emissions from Soil Resulting from Rewetting Air-Dried Soil in Short-Term Laboratory Experiments.” Soil Science and Plant Nutrition 53: 181–88. Yonemura, S., and S. Kawashima. 2007. “Concentrations of Carbon Gases and Oxygen and Their Emission Ratios from the Combustion of Rice Hulls in a Wind Tunnel.” Atmospheric Environment 41 (7): 1407–16. Zhang, J., K. R. Smith, Y. Ma, S. Ye, F. Jiang, W. Qi, P. Liu, M. A. K. Khalil, R. A. Rasmussen, and S. A. Thorneloe. 2000. “Greenhouse Gases and Other Airborne Pollutants from Household Stoves in China: A Database for Emission Factors.” Atmospheric Environment 34: 4537–49. Zimmerman, A. R. 2010. “Abiotic and Microbial Oxidation of Laboratory-Produced Black Carbon (Biochar).” Environmental Science and Technology 44 (4): 1295–301. Zimmerman, A. R., B. Gao, and M.-Y. Ahn. 2011. “Positive and Negative Carbon Mineralization Priming Effects among a Variety of Biochar-Amended Soils.” Soil Biology and Biochemistry 43 (6): 1169–79. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 Environmental Benefits Statement The World Bank is committed to reducing its environmental footprint. In support of this commitment, the Publishing and Knowledge Division leverages electronic publishing options and print-on-demand technology, which is located in regional hubs worldwide. Together, these initiatives enable print runs to be lowered and shipping distances decreased, resulting in reduced paper consumption, chemical use, greenhouse gas emissions, and waste. The Publishing and Knowledge Division follows the recommended standards for paper use set by the Green Press Initiative. Whenever possible, books are printed on 50 percent to 100 percent postconsumer recycled paper, and at least 50 percent of the fiber in our book paper is either unbleached or bleached using Totally Chlorine Free (TCF), Processed Chlorine Free (PCF), or Enhanced Elemental Chlorine Free (EECF) processes. More information about the Bank’s environmental philosophy can be found at http://crinfo.worldbank.org/wbcrinfo/node/4. Biochar Systems for Smallholders in Developing Countries  •  http://dx.doi.org/10.1596/978-0-8213-9525-7 B iochar is the carbon-rich organic matter that remains after heating biomass under minimization of oxygen during a process called pyrolysis. Biochar is relevant to deforestation, agricultural resilience, and energy production, particularly in developing countries. Biochar Systems for Smallhold- ers in Developing Countries: Leveraging Current Knowledge and Exploring Future Potential for Climate- Smart Agriculture reviews the opportunities and risks of biochar systems and discusses the current knowledge of biochar science. The report also offers a reconciling view on different scientific opinions about biochar, showing the various perspectives of its science and application. This includes soil and agricultural impacts of biochar, climate change impacts, social impacts, and competing uses of biomass. The authors contextualize the current scientific knowledge so that it can address the development–climate change nexus, including social and environmental sustainability. World Bank Studies are available individually or on standing order. The World Bank Studies series is also available online through the Open Knowledge Repository (https://openknowledge.worldbank.org/) and the World Bank e-Library (www.worldbank.org/elibrary). ISBN 978-0-8213-9525-7 SKU 19525